X5 E53 3.0i (M54): 2 Repair Instructions
Also for this vehicle: X Series E53 X5 3.0d (M57) OFFRD, X Series E53 X5 3.0d (M57TU) OFFRD, X Series E53 X5 4.4i (M62) OFFRD, X Series E53 X5 4.4i (N62) OFFRD, X Series E53 X5 4.6is (M62) OFFRD, X Series E53 X5 4.8is (N62-S) OFFRD.
Maintenance
General
Diagnostics
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
0 Maintenance And General Data87 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- BMW Service-inspection (petrol/gasoline Vehicles)2
- Pre-delivery Check2345
- Lifting Vehicle With A Lifting Platform
- Notes On Using Repair Instructions, Technical Data, Tightening Torques
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Symbols Used And Information In Repair Instructions2
- Air Cleaner: Replacing Air Cleaner Element (shorten Replacement Interval Accordi
- Battery: Check Display (magic Eye); If Necessary, Recharge Battery
- Battery: Checking Acid Level, Topping Up With Distilled Water If Necessary
- Body And Underbody: Checking For Corrosion And Damage
- Body And Underbody: Checking For Corrosion And Damage - Except Cavities
- Brake And Clutch Hydraulic System: Checking Fluid Level, Topping Up If Necessary
- Brake Lines And Connections: Visual Inspection For Leaks, Damage And Correct Pos
- Changing Brake Fluid
- Changing Coolant
- Changing Differential Oil
- Changing Engine Oil And Oil Filter
- Changing Front Axle Differential Oil
- Changing Oil In Transfer Box (NV125/LWX500)
- Changing Oil In Transfer Box (NV125/LWX500)
- Checking Clutch Drive Plate For Wear
- Checking Coolant Level In Event Of Topping Up: Checking Concentration
- Checking Handbrake Lever Travel, Adjusting According To Setting Specifications I
- Checking Horn, Headlight Flashers And Hazard Warning System
- Checking Instrument And Indication Field Lighting, Heater Blower
- Checking Lighting System
- Checking Roadworthiness
- Coolant Hoses: Visual Inspection For Leaks
- Diagnostic Brief Test
- Exhaust System: Checking Condition, Mounting And Inspecting For Leaks
- Fault Memory Interrogation
- Front And Rear Brake Linings: Checking Lining Thickness With Measuring Gauge
- Fuel Lines, Fuel Tank And Fuel Hoses: Visual Inspection For Routing, Condition A
- Heating/air Conditioning: Replacing Microfilter/carbon Canister (shorten Replace
- Information/warning Labels23
- Locking Systems: Checking Status And Function, Oiling Or Greasing If Necessary
- Microencapsulated Screws
- Oil Change In Manual Transmission
- Oil Change In Rear Differential
- Oil Change In Transfer Case
- Output Shafts: Checking Gaiters For Leaks
- Parking Brake: Checking Function, Adjusting/repairing As Prescribed
- Parking Brake: Checking Lining Thickness
- Power Steering/ride-height Control: Visual Inspection For Leaks, Checking Fluid
- Raising BMW Multi-trailer23
- Replacing Spark Plugs
- Resetting Service Interval Indicator According To Factory Specifications2
- Seat Belts: Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
- Steering Components: Checking For Zero Clearance, Leaks, Damage And Wear2
- Steering Fluid Reservoir: Checking Fluid Level, Topping Up If Necessary
- Transmission (all Gears): Visual Inspection For Leaks
- Tyres: Checking Inflation Pressure, Correcting If Necessary (incl
- Underbody Incl
- Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid23
- Windscreen Wash/wipe System: Checking Washer Fluid Reservoir And Spray Nozzle Ad
- Windscreen Washer System And Intensive Cleaning System: Checking Fluid Level, To
- 60 M56)2
- Checking/topping Up Oil Level In Rear Differential
- Draining/topping Up Gear Oil In Manual Transmission
- Oil Change In Manual Transmission
- Oil Change In Rear Differential Incl2
- Checking/topping Up Fluid Level In Automatic Transmission (A5S 360R / 390R, A4S
- Changing Oil In Transfer Box (ATC 400/500)2
- Notes On Handling Wiring Harnesses And Cables
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
11 Engine (M54)171 pages
0 Engine, General16 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- 4 M56)2
- Checking Compression Of All Cylinders (M60 / M62 / M73 / S62 / M54)2
- Checking Absolute Compression Of All Cylinders
- Removing And Installing Engine (M54)23
- Engine Identification2345
12 Cylinder Head With Cover19 pages
- Removing And Installing, Sealing Cylinder Head Cover (M52TU / M54 / M56)2
- Removing And Installing/replacing Cylinder Head (M52TU / M54 / M56)234
- Removing And Installing/sealing Cylinder Head (M54)234
- Replacing Cylinder Head Gasket (M52 / S52 / M52TU / M54 / M56)
- Disassembling And Assembling Cylinder Head (M52 / S52 / M52TU / M54 / M56)2
- Remachining A Valve Seat (M52 / S52 / M52TU / M54 / M56)
- Checking A Valve Guide For Wear (M52 / S52 / M52TU / M54 / M56)
- Reaming A Valve Guide (M52 / S52 / M52TU / M54 / M56)
- Resurfacing Cylinder Head Sealing Surface (M52 / M52TU / M54 / M56)
- Checking Cylinder Head For Watertightness (M52TU / M54 / M56)2
- 23 Vibration Damper › Removing And Installing Or Replacing Vibration Damper (M52TU / M54 / M56)2345
- 24 Connecting Rod With Bearing › Replacing All Connecting Rod Bearings (M52 / S52 / M52TU / M54 / M56)2
28 V-ribbed Belt W.tens.-deflect.elemt3 pages
- 40 Oil Supply › Checking Engine Oil Pressure2
- 41 Oil Pump With Filter And Drive › Removing And Installing/replacing Oil Pump (M52TU / M54 / M56)23
- 42 Oil Filter And Lines › Removing And Installing Complete Full-flow Oil Filter (M52 / S52 / M52TU / M542
- 51 Water Pump With Drive › Removing And Installing Complete Water Pump (M52 / S52 / M52TU / M54 / M56)2
- 52 Fan › Removing And Installing/replacing Fan Clutch (S52 / S54 / M52 / M52TU / M54 / M52
- 53 Thermostat And Connections › Removing And Installing/replacing Coolant Thermostat (M52TU / M54 / M56)2
- 61 Intake Manifold › Removing And Installing Intake Air Manifold (M54)234
- 62 Exhaust Manifold › Removing And Installing, Sealing Or Replacing Both Exhaust Manifolds With Cataly2
- 71 Exhaust Gas Recirculation › Removing And Installing Or Replacing EGR Cooler (N47)2
78 Emission Control, Oxygen Sensor4 pages
12 Engine Electrical System (M54)78 pages
0 Troubleshooting8 pages
- 12 Ignition Wires, Spark Plugs › Replacing All Spark Plugs
13 Ignition Coil12 pages
- Notes On Checking Ignition System
- Checking Secondary Signal For Stationary Ignition Distribution
- Normal Oscillogram (M, S, W Engines Only)2
- Checking Rod-type Ignition Coils (M54, M56, N40, N42, N43, N45, N46, N52, N62, N234
- Replacing Ignition Coil (M52, M52TU, S52, S50US, M54)23
- Replacing A Spark Plug Connector (M60, M62, M54)
14 Electronic Switching Or Contr.units15 pages
- Replacing Pulse Generator On Crankshaft (M54/M56)2
- Replacing Pulse Generator On Inlet Camshaft (M52TU / M54 / M56)2
- Replacing Pulse Generator On Exhaust Camshaft (M52TU, M54, M56)
- Replacing Control Unit (Digital Motor Electronics) (M62, M54)23
- Replacing Knock Sensor (M52TU, M54, M56)2
- Coding Control Module (DME / DDE)
- Programming Control Unit (DME / DDE)
- Replacing Main Relay (M62, M54)2
- Note On Replacing Codable/programmable Control Units
32 Regulator6 pages
41 Starter With Mounting3 pages
51 Engine Wiring Loom10 pages
- 63 Switches And Relays › Replacing Main Relay (M62, M54)2
- 72 Sensor For Control Unit › Removing And Installing/replacing Pedal Travel Sensor (M62, M54)
13 Fuel System (M54)40 pages
- 0 Checking-setting Engine-emission › Checking Function Of Digital Engine Electronics (DME)
31 Fuel Pump With Drive And Line6 pages
- 32 Fuel Filter › Replacing Fuel Filter (M62, M54)2
- 41 Speed Governor › Replacing Idle Speed Control Valve (M52TU, M54)23
- 51 Inj.pump, Regulator, Mixt.regulator › Replacing Fuel Pressure Regulator (M62, M54)23
53 Injection Nozzle And Lines5 pages
- 63 Throttle Potentiometer, Fuel Pump Relay › Replacing Fuel Pump Relay2
- 64 Start Valves › Replacing All Fuel Injectors
- 71 Intake Silencer › Removing And Installing Intake Filter Housing (M54)
- 72 Air Cleaner › Replacing Air Cleaner Element (M54)
- 90 Carbon Canister Ventilation › Replacing Tank Venting Valve (M52TU, M54)2
16 Fuel Supply System (M54)45 pages
0 Fuel Pick-up, Cleaning System15 pages
- Fuel Supply System E5323
- General Function Description For Fuel Supply Systems
- Draining And Filling Fuel Tank2
- Checking Fuel Tank And Tank Ventilation System For Leaks23
- Checking Fuel Tank And Tank Venting System For Leaks With Tank Leakage Diagnosis2
- Conducting Leak Test On Fuel Tank And Tank Ventilation System2
- Checking Filler Cap Pressure Relief Valve2
11 Fuel Tank With Mounting18 pages
17 Cooling System (M54)48 pages
0 Coolant, Checking Cooling System15 pages
- Instructions For Working On Cooling System23
- Draining And Adding Coolant (M54, M56)2
- Draining And Topping Up Coolant (M62, M54 And M57)23
- Checking Cooling System For Water Leaks2
- Checking Cooling System For Water Leaks2
- Checking For Leaks Between Cooling System And Combustion Chamber
- Venting Cooling System And Checking For Leaks (M54 / M56)2
- 10 Radiator, Expansion Tank, Pipes › Checking Cooling System For Water Leaks2
11 Engine Radiator With Attachment16 pages
- Removing And Installing Radiator (M62, M54 And M57)2345
- Replacing Fan Cowl (M62 / M54)23
- Removing And Installing/replacing Thermostat Insert For Transmission Oil Cooling
- Removing And Installing/replacing Coolant Expansion Tank (M54 / M57)23
- Removing And Installing/replacing Cooling Loop For Power Steering
- Flushing Radiator
- Removing And Installing Cassette (condenser For Air Conditioner)2
- 21 Oil Cooler › Flushing Oil Cooler With Lines (automatic Transmission)2345
- 40 Auxiliary Electrical Fan › Removing And Installing/replacing Complete Auxiliary Fan (M62, M54, M57)23
18 Exhaust System (M54)18 pages
21 Clutch35 pages
0 Maintenance And Inspections4 pages
- 51 Clutch Release Controller W. Lever › Removing And Installing Or Replacing Clutch Release Bearing/lever2345
52 Clutch Operation (hydraulic)5 pages
- 90 Troubleshooting › Troubleshooting The Clutch23
22 Engine And Gearbox Suspension7 pages
32 Transmission Suspension, Autom. Transmis3 pages
23 Manual Transmission (MECH)54 pages
0 Complete Transmission26 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Draining/topping Up Gear Oil In Manual Transmission
- Oil Change In Manual Transmission
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Removing And Installing Transmission (GS6-37BZ)2345
- Removing And Installing Transmission (S5D 280Z, M54)234567
- Installing Replacement Transmission (S5D 280Z)2
- Installing Replacement Transmission (GS6-37BZ)2
12 Bearing In Housing, Sealing Ring11 pages
- 31 Inner Gearshift Components › Replacing Bearing Bushing For 5th/reverse Gear Locking Pin (C/F Transmission) -23
24 Automatic Transmission (AUT)57 pages
0 Transmission Assembly19 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Adjusting Selector Lever (A5S 360R / 390R, A4S 200R, 6HP26Z/19Z)
- Removing And Installing Automatic Transmission (A5S 360R / 390R)2345678
- Removing And Installing Replacement Transmission (A5S 360R / 390R, A4S 200R)2
- 12 Torque Converter Bearing, Seal › Replacing Radial Shaft Seal For Torque Converter (A5S 360R / 390R, A4S 200R)23
- 13 Extension Housing, Bearings, Seal › Replacing Radial Shaft Seal For Transmission Extension (A5S 360R / 390R, 4WD)2
- 30 Hydr-el Control Components-elements › Removing And Installing/replacing Selector Unit (A5S 360R/390R, A4S 200R)23
35 Wiring Harness, Shift Elements And Senso7 pages
- Replacing Pulse Generator (turbine Speed) (A5S 360R / 390R, A4S 200R)
- Replacing Pulse Generator (output Speed) (A5S 360R / 390R, A4S 200R)
- Replacing Transmission Switch (A5S 360R / 390R, A4S 200R)2
- Replacing Wiring Harness In Automatic Transmission (A5S 360R/390R, A4S 200R)2
- Programming/replacing Control Unit
- 40 Torque Converter › Removing And Installing/replacing Torque Converter (A5S 360R / 390R, A4S 200R)2
- 50 Shift Function › Replacing Radial Shaft Seal For Manual Shift Valve Shaft (A5S 360R / 390R, A4S 223
- 52 Internal Gearshift › Replacing Radial Shaft Seal For Manual Shift Valve Shaft (A5S 360R / 390R, A4S 223
61 Electronic Control Unit2 pages
25 Gear Shift Mechanism (AUT) › 16 Centre Shift, Automatic Transmission10 pages
25 Gear Shift Mechanism (MECH) › 11 Centre Shift, Manual Transmission14 pages
26 Propeller Shaft14 pages
- 0 Propeller Shaft, General › Propeller Shaft Deflection Angles
11 Propeller Shaft Assembly11 pages
- Removing And Installing Complete Propeller Shaft23
- Replacing Joint Disk For Propeller Shaft
- Removing And Installing /replacing Centering Mount For Propeller Shaft2
- Replacing Constant-velocity Joint For Propeller Shaft2
- Removing And Installing Front Propeller Shaft2
- Replacing Joint Disk For Front Propeller Shaft
- 12 Centre Console Assembly › Replacing Complete Propeller Shaft Centre Bearing (constant-velocity Joint)2
27 Transfer Box43 pages
10 Transfer Case22 pages
- Checking Function Of Front Differential And Transfer Case
- Removing And Installing ATC 500 X-Drive Transfer Box (automatic Transmission)23
- Removing And Installing Transfer Case (automatic Transmission)23456
- Removing And Installing Transfer Case (manual Transmission)2345
- Installing Replacement Transfer Box (ATC 500 X-Drive)2
- Installing Replacement Transfer Case2
- Replacing Output Flange For Front Axle Output (ATC 400/500 X-Drive)
- Replacing Resistor For Servomotor (ATC 500 X-Drive)
- Replacing Servomotor (ATC 400/500 X-Drive)
21 Transmission Shafts18 pages
- Replacing Radial Shaft Seal For Drive Flange (ATC 400/500 X-Drive)2
- Replacing Radial Shaft Seal For Drive Flange (NV125: LWX-500 Transmission)23
- Replacing Radial Shaft Seal For Output Flange23
- Replacing Radial Shaft Seal For Output Flange (ATC 400/500 X-Drive)234
- Replacing Radial Shaft Seal For Front Axle Output (ATC 400/500 X-Drive)23
- Replacing Radial Shaft Seal For Output Front Axle23
31 Front Axle95 pages
0 General13 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Layout Of Spring Strut Shock Absorber
- Front Axle Assembly
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Notes On Repairing Threads2
- Overview Of Front Differential / Output Shafts
- 11 Front Sub-frame › Replacing Front Axle Carrier23
12 Struts W.rubber Mounts13 pages
- Replacing Left Or Right Control Arm2
- Measuring Play Of Wheel Control Joints23
- Removing And Installing/replacing Guide Joint In Swivel Bearing2
- Removing And Installing/replacing Both Tension Struts
- Replacing Rubber Mount In Left Or Right Control Arm2
- Replacing Rubber Mounts On Both Tension Struts2
- Replacing Rubber Mount In Left Or Right Control Arm (control Arm Removed)
60 Output Shaft15 pages
- Replacing Radial Seal On Left Output Shaft23
- Replacing Radial Seal On Right Output Shaft23
- Pressing Output Shaft Out Of Drive Flange (wheel Hub) And Drawing In23
- Removing And Installing Left Or Right Output Shaft2
- Replacing An Output Shaft Gaiter (on Transmission Side) (output Shaft Removed)
- Replacing Both Gaiters On Left And Right Of Output Shaft23
90 Troubleshooting3 pages
32 Steering And Wheel Alignment116 pages
0 Electronic Chassis Alignment30 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Chassis/wheel Alignment Check Procedure
- General Chassis And Suspension Definitions
- General Information And Definitions2
- Identification Of Suspension Without Label
- Information On Replacing Steering Gear After Accident Damage2
- Moving Vehicle Into Design Position
- Moving Vehicle Into Normal Position
- Performing Rim Runout Compensation
- Test Conditions For Chassis/wheel Alignment Check
- Troubleshooting After Wheel/chassis Alignment Check On Front Axle2
- Troubleshooting After Wheel/chassis Alignment Check On Rear Axle
- KDS Chassis/wheel Alignment Check With Load Up To Design Position23
- KDS Chassis/wheel Alignment Check With Ride-height Measurement Without Load23
- Adjusting Toe-in And Camber On Front Axle23
- Adjusting Rear Axle
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Carrying Out Steering Angle Sensor Adjustment
21 Steering Arms, Tie Rods, Steer. Damper4 pages
31 Steering Column27 pages
- Replacing Upper Section Of Steering Column Trim
- Removing And Installing/replacing Lower Section Of Steering Column Cover
- Replacing Upper Section Of Steering Spindle
- Removing And Installing / Replacing Lower Section Of Steering Spindle2
- Removing And Installing/replacing Steering Angle Sensor
- Removing And Installing Steering Column23
- Replacing Sleeve For Steering Spindle (vehicle Interior)
- Replacing Sleeve For Steering Spindle (assembly Partition Wall)
- Replacing Upper Steering Spindle Bearing2
- Replacing Lower Steering Spindle Bearing
- Replacing Both Steering Spindle Bearings
- Removing And Installing/replacing Double Joint For Lower Steering Spindle2
- Replacing Adjusting Lever For Steering Column2
- Replacing Both Shafts Of Electric Steering Column Adjuster
- Removing And Installing / Replacing A Gear Motor In Steering Column Adjuster
- Dismantling And Assembling Complete Steering Column23456
34 Steering Wheel For Airbag18 pages
- Notes On Scrapping BMW Vehicles With Gas Generators (airbag System)234
- Removing And Installing/replacing Airbag Unit2
- Removing And Installing/replacing Airbag Unit (plugged Airbag Unit)23
- Notes On Scrapping BMW Vehicles With Gas Generators (central Airbag Control Unit2
- Safety Regulations For Handling Airbag System Components2
- Safety Regulations For Handling Components With Gas Generators2
- Procedure After Airbag Triggering As Result Of An Accident23
41 Pump And Oil Supply15 pages
- Removing And Installing/replacing Cooling Loop For Power Steering
- Bleeding Power Steering Unit2
- Instructions For Removing And Installing Ear Clips2
- Instructions For Using Special Tool 32 4 0002
- Notes On Hydraulic Line With Quick-connect Coupling2
- Servotronic Troubleshooting
- Checking Function Of Power Steering Vane Pump2
- Removing And Installing Power Steering Vane Pump (M52TU / M54)2
- Removing And Installing/replacing Belt Pulley On Vane Pump For Power Steering
- 90 Troubleshooting › Troubleshooting On Steering
33 Rear Axle82 pages
0 General19 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Rear Axle Layout
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Notes On Repairing Threads
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Overview Of Rear Differential/output Shafts
- Overview Of Rear Axle Carrier With Rubber Mounts
- Overview Of Steering Links
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
11 Final Drive With Cover11 pages
- Replacing Rear Cover Gasket On Rear Differential (188K)
- Replacing Rear Cover Gasket On Rear Differential (215K)
- Replacing Shaft Seal For Input Flange On Final Drive234
- Replacing Drive Flange On Left Or Right Of Final Drive2
- Replacing Shaft Seal For Drive Flange Left Or Right2
- Replacing Rear Cover Gasket On Rear Differential
- 17 Final Drive Mounting › Replacing All Rubber Mounts For Final Drive Mount23
32 Control Arms And Struts10 pages
- Removing And Installing/replacing Left Or Right Push Rod/integral Link2
- Removing And Installing/replacing Left Or Right Swinging Arm2
- Replacing One Upper Control Arm2
- Replacing A Guide Arm2
- Replacing A Ball Joint In Lower Steering Knuckle/wheel Carrier
- Removing And Installing / Replacing A Steering Knuckle / Wheel Carrier
- 33 Axle Mounting › Replacing All Rubber Mounts For Rear Axle Carrier23
53 Springs With Suspension3 pages
90 Troubleshooting2 pages
34 Brakes78 pages
0 Brake Testing And Bleeding16 pages
- General Data23
- General Information On Braking In New Brake Discs / Brake Pads
- Testing AWD Vehicles On Dynamic Brake And Power Analyzers (E30, E34, E46, E53, E
- Checking Brakes On Test Stand2
- Checking Thickness Of Brake Lining
- Parking Brake Function Check
- Checking Brake Booster (low-pressure Test)
- Replacing Fluid In ABS/ASC-T Brake System2
- Bleeding Brake System With DSC2
- Checking Parking Brake Setting (for Inspection)
- Checking Service Brake: High- And Low-pressure Tests
11 Front Brakes12 pages
- Removing And Installing/replacing Brake Linings Of Both Front Disk Brakes234
- Removing And Installing/replacing Both Front Brake Disks2
- Removing And Installing/replacing Left Or Right Front Brake Caliper2
- Overhauling Left Or Right Front-brake Caliper (brake Caliper Removed)23
- Fine-grinding Both Sides Of Both Front Brake Disks (brake Disks Removed)
21 Rear Brakes11 pages
- Removing And Installing Or Replacing Brake Linings On Both Rear Disk Brakes234
- Removing And Installing Or Replacing Both Rear Brake Disks
- Removing And Installing Or Replacing Left Or Right Rear Brake Caliper2
- Overhauling Left Or Right Rear Brake Caliper (brake Caliper Removed)23
- Fine-grinding Both Sides Of Both Rear Brake Disks (brake Disks Removed)
- 35 Electrical Components - Wear Indicator › Replacing A Brake Pad Sensor (front)
41 Parking Brake11 pages
- General Information On Braking In New Brake Discs / Brake Pads
- Adjusting Handbrake234
- Removing And Installing Handbrake Lever
- Removing And Installing / Replacing Both Handbrake Bowden Cables2
- Removing And Installing Or Replacing All Handbrake Pads2
- Removing And Installing/replacing Expander Lock For Handbrake Shoes
51 Mechanical-hydraulic Components4 pages
- 90 Troubleshooting › Troubleshooting The Brake System234
36 Wheels With Tyres25 pages
11 Disc Wheels (rims)8 pages
- 12 Tyres › Changing A Tyre (on Front, Rear Or Spare Wheel)2345
37 Integrated Suspension Systems52 pages
0 General13 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Overview Of Integrated Suspension Systems (ride-height Control)
- Overview Of Integrated Suspension Systems (two-axle Ride-height Control)
- Notes On Air Spring System
- Checking Air Spring Struts/air Springs For Damage
- Draining/filling Air Spring System (ride-height Control)2
- Draining/filling Air Spring System (twin-axle Ride-height Control)23
- Carrying Out Ride-height-calibration
- 11 Front Control And Suspension Elements › Replacing Front Left Or Right Air Spring Strut23
12 Rear Control And Suspension Elements11 pages
14 Electrical Components7 pages
- Replacing Front Ride-height Sensor
- Replacing (removing And Installing) Rear Left Or Right Ride-height Sensor
- Removing And Installing/replacing Pressure Sensor For Air Suspension (two-axle R2
- Replacing Control Unit For Air Supply Unit (ride-height Control)
- Replacing Control Unit For Air Supply Unit (two-axle Ride-height Control)
- Removing And Installing/replacing Relay For Air Supply Unit (two-axle Ride-heigh
22 Pump Assembly With Container4 pages
- 90 Troubleshooting › Troubleshooting On Level Control System234
41 Body (OFFRD)159 pages
0 Body71 pages
- Contents Of Body, General2
- Bonding Plastic Parts
- Bonding Steel Parts2
- Corrosion Protection2
- Embossing Chassis Number
- Frame Alignment Control Dimensions, Body, BMW E 5323
- Gap Dimensions, Body2
- General Cementing Instructions
- General Information About Body Repair2
- Gluing Of Body Components
- Grinding Steel Parts
- Handling Airbags And Restraint Systems
- Handling Electrical And Electronic Equipment
- Information / Warning Labels
- Information On Hazards
- Information On Vehicle Protection
- Installation Of A Cavity Seal With Cavity Foam2
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
- Materials Science23
- Notes On Repairing Threads
- Opening Adhesive Bonds
- Opening Weld Joints
- Position Of Shaped Parts For Cavity Bulkhead
- Quality Standard
- Recommended Working Methods And Tools2
- Removal Of PVC Material In Repair Area
- Riveting Aluminium Parts2
- Riveting Steel Parts
- Safety At Work2
- Spot-weld Bonding Steel Parts
- Straightening Aluminium Parts2
- Straightening Steel Parts2
- Use Of Materials In Outer Shell2
- Vehicle Identification Number, General
- Welding And Soldering Steel Parts23
- Welding In Reinforcement Plate (steel Plate)2
- Welding Of Galvanized Plates
- Workshop Equipment2
- Replacing Unfinished Body Shell
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
- Notes On Cavity Foam2
- General Instructions On Painting
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
11 Support Members19 pages
- Position Of Shaped Parts For Cavity Bulkhead
- Replacing Left Engine Carrier (partial Replacement Before Front Axle) (E53)2
- Replacing Left Front Engine Carrier (without Wheel Housing) (partial Replacement234
- Replacing Left Or Right Side Member Cover (partial Replacement Of A-pillar And R234567
- Replacing Rear Axle Carrier Upper And Lower Sections On Left Or Right (partial R23
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
21 Side Frame And Door Pillars9 pages
- 22 Roof Frame › Position Of Shaped Parts For Cavity Bulkhead
61 Front Lid4 pages
51 Body Equipment (OFFRD)281 pages
11 Front Bumper15 pages
- Removing And Installing/replacing Member (cross-member) For Front Bumper Trim2
- Removing And Installing/replacing Attachment For Front Bumper Trim (HP)
- Removing And Installing Front Bumper Trim (from 10/03)23
- Removing And Installing Front Bumper Trim (up To 10/03)2
- Replacing Front Bumper Trim
- Replacing Baseplate For License Plate
- Removing And Installing/replacing Grill For Bumper Trim (from 10/03)2
- Removing And Installing/replacing Trim Grill For Bumper Trim (up To 10/03)
- Replacing Left Or Right Bracket For Front Bumper2
12 Rear Bumper13 pages
- Removing And Installing Complete Rear Bumper
- Removing And Installing Complete Rear Bumper (HP)2
- Replacing Rear Bumper2
- Removing And Installing/replacing Trim On Attachment For Rear Bumper Trim (HP)
- Removing And Installing/replacing Attachment For Rear Bumper Trim (HP)
- Replacing Rear Bumper Trim (HP)2
- Replacing A Shock Absorber For Rear Bumper (HP)
- Replacing One Impact Absorber For Rear Bumper
- Replacing Bracket For Rear Bumper At Left Or Right2
13 Trim, Covers, Handle Trim10 pages
- Removing And Installing Or Replacing Finisher On Left Or Right Headlight Housing
- Removing And Installing/replacing Cowl Panel Cover2
- Removing And Installing Handle Strip (on Trunk Lid)
- Replacing Handle Strip (on Trunk Lid)23
- Removing And Installing Or Replacing Front Grab Handle
- Removing Window Cavity Cover Strip With Special Tool 00 9 324 At Front Or Rear2
16 Mirrors-covers-ashtrays-shelves-trays54 pages
- Calibrating Compass In Interior Rearview Mirror
- Cementing Of Mirror Base2
- Removing And Installing/replacing Armrest On Cover On Center Armrest
- Removing And Installing/replacing Center Armrest Sliding Unit23
- Replacing Button For Armrest In Center Console
- Replacing Clamping Element For Front Cup Holder
- Removing And Installing/replacing Mirror On Left Or Right Front Door
- Replacing Mirror Glass For Rear-view Mirror (on Front Door)
- Removing And Installing/replacing Housing On Left Or Right Door Mirror2
- Removing And Installing/replacing Interior Rearview Mirror (overview)2
- Removing And Installing/replacing Interior Rearview Mirror (with /X: Cable And P2
- Removing And Installing/replacing Interior Rearview Mirror (with Japanese Toll M23
- Removing And Installing/replacing Interior Rearview Mirror (with Full Foot)
- Removing And Installing/replacing Interior Rearview Mirror (with Mirror Arm End23
- Removing And Installing/replacing Interior Rearview Mirror (with Rain Sensor)23
- Removing And Installing / Replacing Interior Rearview Mirror (with Remote Contro
- Removing And Installing Or Replacing Sun Visor And Left Or Right Counter Support
- Removing And Installing Center Console2
- Replacing Center Console23
- Removing And Installing/replacing Front Cup Holder
- Removing And Installing/replacing Rear Cup Holder23
- Removing And Installing/replacing Trim For Preselector Knob
- Replacing Trims For Center Console2
- Replacing A Clipped Finisher (decorative Strip On Panel For Instrument Panel, Fr2345
- Removing And Installing/replacing Function Carrier On Centre Armrest
- Removing And Installing/replacing Function Carrier On Centre Armrest (with Telep2
- Removing And Installing Right Glove Box
- Removing And Installing Or Replacing Sun Blind At Fixed Side Window Of Left Or R
- Removing And Installing Or Replacing Blind At Side Window Of Left Or Right Rear
- Removing And Installing/replacing Rear Left/right Grab Handle
- Removing And Installing Or Replacing Front Grab Handle
- 17 Lids › Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
21 Front Door Locks, Handles, Fittings21 pages
- Removing Window Cavity Cover Strip With Special Tool 00 9 324 At Front Or Rear2
- Adjusting Front Left Or Right Door Detent (lock Wedge)
- Removing And Installing/replacing Door Lock On Left Or Right Front Door23
- Removing And Installing/replacing Complete Lock Cylinder2
- Blocking, If Necessary Initializing, Car Key In Immobilizer Control Module
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo2
- Removing And Installing/replacing Cover On Outside Handle
- Removing And Installing Cover On Outside Handle With Locking Cylinder
- Replacing Cover On Outside Handle With Locking Cylinder
- Removing And Installing/replacing Outside Handle And Lock Actuator From Left Or2
- Removing And Installing/replacing Inside Door Handle In Left Or Right Front Door2
- Removing And Installing Or Replacing Window Cavity Cover Strip On Outside Of Lef2
- Replacing Window Cavity Seal On Left Or Right Front Door
22 Rear Door Locks, Handles, Fittings14 pages
- Adjusting Rear Left Or Right Door Detent (lock Wedges)
- Removing And Installing/replacing Door Lock On Left Or Right Rear Door23
- Removing And Installing/replacing Outside Handle On Left Or Right Back Door2
- Removing And Installing/replacing Cover On Outside Handle, Left Or Right
- Removing And Installing/replacing Outside Handle And Lock Control On Left Or Rig2
- Removing And Installing/replacing Inside Door Handle Of Rear Left Or Right Door2
- Removing And Installing/replacing Window Cavity Cover Strip On Rear Door On Left2
- Replacing Window Cavity Seal On Inner Left Or Right Rear Door
24 Trunk Latch, Locks10 pages
- Removing And Installing/replacing Bottom Left Or Right Lock Support For Rear Lid
- Adjusting Rear Lid Latch For Rear Lid Upper Section
- Adjusting Rear Lid Latch For Rear Lid Lower Section
- Removing And Installing/replacing Lock For Rear Lid Upper Section
- Removing And Installing/replacing Striker For Rear Lid Upper Section
- Removing And Installing/replacing Left Or Right Lock For Rear Lid Lower Section2
- Removing And Installing/replacing Left Or Right Striker For Rear Lid Lower Secti2
- Removing And Installing Or Replacing Left Or Right Gas Strut For Rear Lid
31 Front And Rear Window20 pages
- Instructions On Gluing Windscreen23456789
- Removing Windscreen With /Roll Out 20002345
- Removing And Installing / Replacing Windscreen
- Repairing Damage To Windscreens Caused By Pitting (stone Chips) (clear And Tinte
- Removing And Installing/replacing Rubber Frame For Windshield (top)
- Removing And Installing/replacing Rear Window
- Replacing Rear Window (rear Window Broken)
- Replacing Rear Window (complete Rear Window)
32 Front Manually Operated Windows8 pages
- Adjusting Left Or Right Front Door Window2
- Removing And Installing/replacing Cover (anti-trapping Protection) On Door Windo
- Removing And Installing/replacing Door Window Glass, Front Left Or Right
- Replacing Front Left Or Right Rubber Guide For Left Or Right Door Window
- Removing And Installing/replacing Decorative Strip On Front Left Or Right Door2
- Removing And Installing/replacing Trim On Front Door Window Frame, Left Or Right
- 33 Front Electrically Operated Windows › Removing And Installing Power Window Regulator In Left Or Right Front Door
34 Rear Manually Operated Windows12 pages
- Removing And Installing/replacing Window Guide Rail Of Rear Door, Rear Left Or R2
- Removing And Installing/replacing Cover (anti-trapping Protection) On Door Windo2
- Replacing Rear Left Or Right Door Window
- Replacing Left Or Right Fixed Door Window In Rear Window Frame
- Replacing Rubber Guide For Rear Left Or Right Door Window
- Removing And Installing/replacing Decorative Strip On Rear Door (top), Left Or R2
- Removing And Installing/replacing Trim On Window Frame Of Rear Door (front), Lef2
- Removing And Installing/replacing Trim On Window Frame Of Rear Door, Rear Left O
- 35 Rear Electrically Operated Windows › Removing And Installing Complete Power Window Regulator From Rear Left And Right
41 Front Door Trim Panel With Arm Rest9 pages
- Removing And Installing Left Or Right Front Door Trim Panel23
- Replacing Front Left Or Right Door Trim
- Removing And Installing/replacing Cover On Door Handle, Front Left Or Right
- Replacing Speaker Frame On Front Left Or Right Door Trim Panel
- Removing And Installing/replacing Door Handle On Door Trim Panel, Front Left Or
- Removing And Installing/replacing Sound Insulation In Front Door, Left Or Right2
42 Rear Door Trim Panel With Arm Rest10 pages
- Removing And Installing Rear Left Or Right Door Trim Panel23
- Replacing Left Or Right Rear Door Trim Panel2
- Removing And Installing/replacing Cover On Door Handle, Rear Left Or Right
- Replacing Speaker Frame On Rear Left Or Right Door Trim Panel
- Removing And Installing/replacing Door Handle On Door Trim Panel, Rear Left Or R
- Removing And Installing/replacing Sound Insulation In Rear Door, Left Or Right2
43 Side Covering With Armrests11 pages
- Removing And Installing/replacing Side Trim Panel, Footwell, On A-pillar, Left
- Removing And Installing/replacing Side Trim Panel, Footwell, On A-pillar, Right
- Removing And Installing Or Replacing Trim On Left Or Right Door Pillar (top)
- Removing And Installing Or Replacing Trim For Left Or Right Door Pillar (bottom)2
- Removing And Installing/replacing Panel For Roof Pillar At Front (A-pillar), Lef2
- Removing And Installing/replacing Trim Panel For Left Or Right Rear Roof Pillar2
- Removing And Installing/replacing Panel For Rear Roof Pillar (D-pillar), Left Or2
44 Roof Trim Panel6 pages
45 Instrument Cluster Trim Panel9 pages
- Removing And Installing Instrument Panel Trim2
- Replacing Instrument Panel Trim23
- Removing And Installing/replacing Airbag Cover On Passenger Side
- Removing And Installing Trim For Instrument Panel, Bottom Left
- Removing And Installing/replacing Trim For Instrument Panel, Bottom Right
- Removing And Installing/replacing Trim For Pedal Assembly
- 46 Parcel Shelf Trim Pan.-roller Sun Blind › Removing And Installing/replacing Finisher For Top Of Rear Apron2
47 Floor-lugg.comp.-eng.comp.tr.panels11 pages
- Removing And Installing/replacing Finisher For Top Of Rear Apron2
- Removing And Installing/replacing Left Or Right Underbody Panelling
- Removing And Installing/replacing The Front (inside) Left Or Right Rocker Panel
- Removing And Installing/replacing Luggage Compartment Floor Trim Panel
- Removing And Installing/replacing Trunk Wheel Housing Trim, Left
- Removing And Installing/replacing Right Trunk Wheel Arch Trim2
- Removing And Installing/replacing Flap In Luggage Compartment Trim, Left Or Righ
- Removing And Installing/replacing Front Assembly Underside Protection
- Removing And Installing/replacing Rear Underbody Protection
49 Rear Lid Trim Panel8 pages
- Removing And Installing/replacing Lower Trim For Rear Lid Upper Section2
- Removing And Installing/replacing Side Trim For Rear Lid Upper Section
- Removing And Installing/replacing Upper Trim For Rear Lid Upper Section
- Removing And Installing/replacing All Trims For Rear Lid Upper Section
- Removing And Installing/replacing Cover For Loading Sill (on Rear Lid Lower Sect
- Removing And Installing/replacing Insert For Trim On Rear Lid Lower Section
- Removing And Installing/replacing Trim For Rear Lid Lower Section
71 Gaskets-seals, Loose Body Components9 pages
52 Seats127 pages
13 Front Seat, Normal, Manual39 pages
- Removing And Installing/replacing Guide For Front Left Or Right Head Restraint2
- Removing And Installing/replacing Seat Pan And Flexmat (normal/manual), Left Or2
- Retrofitting Seat Angle Adjuster On Front Seat (normal/manual)2
- Removing And Installing / Replacing Controls On Left / Right Front Seat (normal23456
- Removing And Installing / Replacing Outer Cover On Left Or Right Front Seat Back2
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Replacing Lumbar Cushion On Front Left Or Right Seat23
- Removing And Installing / Replacing Valve Housing For Left Or Right Lumbar Suppo2
- Removing And Installing/replacing Seat Angle Adjuster (normal/manual) On Left Or2
- Removing And Installing / Replacing Rear Panel On Left Or Right Front Seat Backr23
- Removing And Installing / Replacing Front Headrest (normal: Manual)
- Replacing Seat Cover On Left Or Right Front Seat (normal/manual)2345678
- Replacing Left Or Right Support For Front Seat (normal / Manual)
- Removing And Installing Left Or Right Front Seat (normal / Electric)2
- Removing And Installing/replacing Valve Housing For Front Lumbar Support (normal2
14 Front Seat, Normal, Electric18 pages
- Removing And Installing/replacing Seat Pan And Flexmat (normal/manual), Left Or2
- Removing And Installing Left Or Right Front Seat (normal / Electric)2
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (norma
- Removing And Installing/replacing Inner Cover On Front Left Or Right Seat (norma
- Removing And Installing/replacing Valve Housing For Front Lumbar Support (normal2
- Removing And Installing/replacing Seat Angle Adjuster On Left Or Right Front Sea2
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Head Restraints (normal
- Replacing Seat Cover For Left Or Right Front Seat (normal/electric)
- Replacing Support For Left Or Right Front Seat (normal/electric)
- Additional Work (normal: Electric) With Defective Drive For Longitudinal Adjustm23
- Removing And Installing/replacing Carrier For Outer Cover On Left Or Right Front
- 15 Front Seat, Sports, Manual › Removing And Installing Left Or Right Front Seat (normal / Electric)2
16 Front Seat, Sports, Electric27 pages
- Removing And Installing Left Or Right Front Seat (normal / Electric)2
- Additional Work (normal: Electric) With Defective Drive For Longitudinal Adjustm23
- Removing And Installing/replacing Carrier For Outer Cover On Left Or Right Front
- Removing And Installing Front Seat (sports/electric), Left Or Right
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (sport23
- Removing And Installing/replacing Inner Cover On Front Left Or Right Seat (sport
- Removing And Installing/replacing Seat Angle Adjuster On Left Or Right Front Sea2
- Removing And Installing/replacing Rear Panel On Front Left Or Right Seat Backres
- Removing And Installing/replacing Front Head Restraint (sports/electric) On Left
- Replacing Seat Cover For Left Or Right Front Seat (sports/electric)2345678910
- Replacing Support For Left Or Right Front Seat (sport/electric)
- Replacing First Aid Kit With Holder
17 Front Seat, Comfort25 pages
- Replacing First Aid Kit With Holder
- Removing And Installing Front Seat (comfort)
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat (co23
- Removing And Installing/replacing Shaft For Headrest Adjustment (comfort Seat)
- Removing And Installing/replacing Gearing For Head Restraint Adjustment (comfort
- Removing And Installing/replacing Outer Cover On Left Or Right Front Seat (comfo
- Removing And Installing/replacing Inner Cover On Left Or Right Front Seat (comfo
- Replacing Lumbar Cushion On Left Or Right Front Seat (comfort)
- Removing And Installing/replacing Valve Housing For Lumbar Cushion (comfort Seat
- Removing And Installing/replacing Seat Angle Adjuster On Left Or Right Front Sea2
- Removing And Installing/replacing Top Rear Panel On Front Seat Backrest (luxury
- Removing And Installing/replacing Bottom Rear Panel On Front Seat Backrest (luxu
- Removing And Installing/replacing Head Restraint Mount On Left Or Right Front Se
- Removing And Installing Or Replacing Front Left Or Right Head Restraints (comfor
- Replacing Seat Cover For Left Or Right Front Seat (comfort)
- Replacing Backrest Cover For Left Or Right Front Seat (comfort)234
- Replacing Seat And Backrest Covers For Left Or Right Front Seat (comfort Seat)
- Replacing Padding For Left Or Right Front Seat (comfort)
- Replacing Support For Left Or Right Front Seat Backrest (comfort)
26 Rear Seat, Through-loading16 pages
- Removing And Installing/replacing Ski Bag With Cassette On Rear Seat (through-lo
- Removing And Installing/replacing Rear Seat (through-loading System)
- Removing And Installing/replacing Left Or Right Side Section Of Rear Seat Backre2
- Removing And Installing / Replacing Left Or Right Backrest For Rear Seat (load T
- Removing And Installing/replacing Armrest For Rear-seat Backrest (through-loadin
- Removing And Installing /replacing Actuating Mechanism For Left Rear Seat Backre2
- Removing And Installing/replacing Lock For Left Rear Seat Backrest (through-load2
- Removing And Installing/replacing Rear Head Restraints (through-loading System)
- Replacing Seat Cover For Rear Seat (through-loading System)
- Replacing Seat Cover For Rear Seat (through-loading System)
- Replacing Backrest Cover For Rear Seat (through-loading System) On Left23
54 Slide-tilt Sunroof And Convertible Top (OFFRD)81 pages
10 Sunroof27 pages
- Repair Instructions For Bonded Seals23
- Removing And Installing/replacing Drive Cable Plate23
- Removing And Installing Mechanism For Front Glass Lid234567
- Removing And Installing Mechanism For Rear Glass Lid2345
- Removing And Installing/replacing Mechanism For Floating Roofliner2
- Removing And Installing/replacing Slider Set For Floating Roofliner2
- Replacing Left Or Right Gaiter For Glass Slide/tilt Sunroof
- Removing And Installing Front Glass Slide/tilt Sunroof Cover
- Removing And Installing Rear Glass Slide/tilt Sunroof Cover
- Removing And Installing Front Cross-member
- Removing And Installing Rear Cross-member
12 Mechanical Sun Roof Components29 pages
- Notes On Steel And Glass Slide/tilt Sunroofs (initialization/normalization/learn23
- Adjusting Glass Sliding/tilting Sunroof Lid23
- Replacing Left Or Right Rubber Gaiters For Glass Slide/tilt Sunroof
- Removing And Installing Glass Sliding/tilting Sunroof Lid234
- Replacing Glass Sliding/tilting Sunroof Lid
- Replacing Seal For Glass Sliding/tilting Sunroof Lid
- Replacing Seal For Slide/tilt Sunroof Lid
- Removing And Installing / Replacing Headliner Mechanism For Glass Slide/tilt Sun23
- Removing And Installing/replacing Headliner For Sun-roof Lid2
- Removing And Installing / Replacing Headliner For Glass Slide/tilt Sunroof Cover2
- Removing And Installing Complete Slide/tilt Sunroof (frame)2
- Replacing Control Rail For Left/right Glass Slide/tilt Sunroof23
- Adjusting Both Drive Cables For Actuation Of Glass Slide/tilt Sunroof2
- Removing And Installing Or Replacing Wind Deflector
13 Electrical Sun Roof Components25 pages
- Notes On Panorama Glass Roof (initialization/normalization/learning Of Character23
- Notes On Steel And Glass Slide/tilt Sunroofs (initialization/normalization/learn23
- Adjusting Glass Slide/tilt Sunroof Lid2
- Replacing Seal For Slide/tilt Sunroof Lid At Rear
- Replacing Seal For Slide/tilt Sunroof Frame
- Removing And Installing/replacing Front Floating Roofliner For Glass Slide/tilt
- Removing And Installing/replacing Rear Floating Roofliner For Glass Slide/tilt S
- Removing And Installing/replacing Both Floating Roofliners For Glass Slide/tilt23
- Removing And Installing Complete Glass Slide/tilt Sunroof23
- Removing And Installing/replacing Wind Deflector2
- Replacing/cleaning Net For Wind Deflector
- Removing And Installing/replacing Drip Moulding
- Removing And Installing/replacing Rear Drip Moulding
- Removing And Installing Front Cross-member
- Removing And Installing Rear Cross-member
61 General Electrical System169 pages
0 Troubleshooting14 pages
- Instructions On Starting Aid
- Battery
- Notes On Handling Optical Fibers
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Treating Cables And Fibre-optic Cables
13 Plug Connection, Terminal, Fuse Box49 pages
- Notes On Handling Optical Fibers
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Butt Connector For Repairing A Plug Connection234
- Crimping Stop Parts234
- DME Master Relay Connector
- Installing Fan Connector For Retrofitting/repairs2345
- Special Tools For Wiring Harness Repairs23
- Unlocking And Disconnecting Different Plug Connections23
- Base Of Tab Connector Housings
- Crimping Micro Power Quadlock Contacts (MPQ)
- Crimping Micro Quadlock System Contacts (MQS)2
- Crimping Annular Contacts
- Crimping Optical Fibres2
- Cutting Off, Stripping Insulation And Cutting Optical Fibres To Length23
- Cutting To Length And Stripping Insulation From Cables
- In-line Plugs, 30-pin, Hybrid System MQS/MPQ2
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Plug Housing, LCC Contact (load Current Contact)2
- Relay Carrier
- Repairing Ribbon Cables
- Retaining Bracket
- Socket Housing (radio Plug), Hybrid System MQS/MPQ23
- Treating Cables And Fibre-optic Cables
20 Battery16 pages
- Instructions For Disconnecting And Connecting Battery23
- Instructions On Starting Aid
- Battery
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Threshold Values For Battery Inspection Of All Battery (telephone Except For Tel
- AGM Battery234
- Battery Charging
- Battery Open-circuit Current Test
- Disconnecting And Connecting Battery Negative Lead
21 Battery-vapour Separator3 pages
31 Switch32 pages
- Removing And Installing/replacing Fixture For Steering Column Stalk2
- Removing And Installing/replacing Turn Indicator/dimmer Stalk
- Removing And Installing Ignition Switch
- Removing And Installing Light Switch Unit
- Replacing Light Switch Unit
- Removing And Installing/replacing Stalk For Steering Column Adjustment
- Removing And Installing/replacing Stalk For Windshield Wipers
- Removing And Installing Switch Unit In Center Console
- Replacing Switch Unit In Center Console
- Removing And Installing/replacing Switch For Hazard Warning Flashers/central Loc
- Removing And Installing/replacing Switch For Unlocking Rear Lid
- Removing And Installing/replacing Switch For Left Or Right Seat Heating (rear)
- Replacing Rocker Switch For Side Window Operation (door Switch Center)
- Removing And Installing/replacing Switch For Slide/tilt Sunroof
- Replacing Switch Combination For Seat Adjustment
- Removing And Installing/replacing Switch For Front Lumbar Support
- Removing And Installing/replacing Switch For Rear Seat Backrest Adjustment
- Replacing Switch On Impact Cushion For Left Or Right Airbag
- Replacing Switch On Sport Steering Wheel (with Connected Airbag Unit)
- Removing And Installing/replacing Engine Hood Contact Switch
- Replacing Switch For Door Mirror
- Removing And Installing/replacing Switch For Air Suspension (two-axle Ride-heigh
- Replacing Clutch Switch For Cruise Control System
- Removing And Installing/replacing Clutch Switch Module
- Replacing Brake-light Switch2
- Replacing Level Switch For Brake Fluid
- Replacing Level Switch For Coolant
- Removing And Installing/replacing Remote Control For Garage Door Opening
- Replacing Level Switch For Windshield Washer System
- Carrying Out Steering Angle Sensor Adjustment
- 33 Horn › Replacing Horn (anti-theft System)
35 ECUs, Modules12 pages
- Note On Replacing Codable/programmable Control Units
- Notes On ESD Protection (Electro Static Discharge)23
- Removing And Installing/replacing Rain Sensor2
- Initializing Rain Sensor
- Removing And Installing/replacing Electronic Control Unit For Slide/tilt Sunroof2
- Removing And Installing (replacing) Control Unit For Adaptive Headlight
- Removing And Installing/replacing Ring Antenna Of Electronic Immobilizer
- Vehicle Programming And Coding
61 Windscreen Wipers12 pages
- Adjusting Left Or Right Windscreen Wiper23
- Checking/adjusting Approach Angle Of Windshield Wiper Arms On Front Windscreen2
- Replacing Both Windscreen Wiper Blades
- Replacing Left Or Right Windshield Wiper Arm
- Removing And Installing/replacing Both Windshield Wiper Arms2
- Removing And Installing Mounting Bracket For Windshield Wiper System Completely2
- Replacing Bracket For Windshield Washer System
- 66 Windscreen Washer System › Removing And Installing/replacing A Jet Nozzle In Windshield Washer System
- 67 Headlight Washer System › Removing And Installing/replacing Spray Nozzles For Left Or Right Headlight Clea2
62 Instruments3 pages
63 Lights68 pages
12 Headlights21 pages
- Removing And Installing/replacing Left Headlight
- Removing And Installing/replacing Right Headlight
- Removing And Installing Left Headlight (xenon Headlight)2
- Replacing Left Headlight (xenon Headlight)
- Removing And Installing Right Headlight (xenon Headlamp)
- Replacing Right Headlight (xenon Headlight)
- Removing And Installing Left Headlight (adaptive Headlight)
- Replacing Left Headlight (adaptive Headlight)
- Replacing Control Unit For Left Xenon Headlight
- Replacing Control Unit For Right Xenon Headlight
- Replacing Ignition Unit For Left Xenon Headlight (from 10/2003)
- Replacing Ignition Unit For Right Xenon Headlight (from 10/2003)
- Replacing Drive For Left Adaptive Headlight
- Removing And Installing/replacing Left Headlight Vertical Aim Adjuster2
- Removing And Installing/replacing Left Headlight Vertical Aim Adjuster (xenon He23
- Removing And Installing/replacing Right Headlight Vertical Aim Adjuster
- Removing And Installing/replacing Right Headlight Vertical Aim Adjuster (xenon H
- 13 Turn Signal Indicator Lights › Removing And Installing/replacing Front Left Or Right Auxiliary Turn Indicator L
- 14 Clearance And Side Marker Lamps › Removing And Installing/replacing Rear Reflector (on Rear Lid Lower Section)
- 25 Brake Lights › Removing And Installing/replacing Additional Stop Light
- 26 Licence Plate Lights › Removing And Installing/replacing Left Or Right License Plate Light
31 Interior Lights6 pages
- Removing And Installing/replacing Complete Ceiling Light
- Removing And Installing/replacing Footwell Light
- Removing And Installing/replacing Footwell Light (on Floor Trim Panel, Rear)
- Removing And Installing/replacing Mirror Light
- Removing And Installing/replacing Luggage Compartment Light (in Rear Lid, Top)
- Removing And Installing/replacing Glovebox Light
99 Light Bulbs26 pages
- Instructions For Handling Light Bulbs (exterior Lights)
- Instructions For Replacing Light Bulbs (interior Lights)
- Replacing Halogen Bulb For High-beam Headlight On Left2
- Replacing Halogen-light Bulb For Left Or Right Headlight2
- Replacing Bulb For Left Xenon Headlight23
- Replacing Bulb For Right Xenon Headlight
- Replacing Bulb For Side Marker Lamp, Front Left2
- Replacing Bulb For Side Light, Front Right
- Replacing Bulb For Side Marker Lamp, Front Left (in Turn Indicator)
- Replacing Halogen Bulb For Fog Lamp Insert, Left Or Right
- Replacing Bulb For Turn Indicator, Front Left
- Replacing Bulb For Turn Indicator, Front Right
- Replacing Bulb For Auxiliary Turn Indicator Light, Front Left Or Right
- Replacing Light Bulb(s) For Left Or Right Rear Light
- Replacing Bulb For Left Or Right License Plate Light
- Replacing Light Bulb(s) For Ceiling Light2
- Replacing Bulb For Footwell Light (on Floor Trim Panel, Rear)
- Replacing Bulb(s) For Mirror Light
- Replacing Light Bulb For Luggage Compartment Lighting
- Replacing Bulb In Left Or Right Door Mirror
64 Heating And Air Conditioning91 pages
11 Heater With Operation31 pages
- Installing Servodrive
- Replacing Heater Core (automatic A/C)23
- Removing And Installing/replacing Heater - A/C Fan
- Replacing Limit Switch For Fan Of Heater/air Conditioner (climate Control)
- Replacing Output Stage/switch For Heater - A/C System Blower
- Removing And Installing / Replacing Auxiliary Water Pump2
- Replacing Water Valve For Heater
- Replacing Front Plate (automatic A/C)
- Replacing Pushbutton Covers For Heater Controls
- Replacing Heater Controls (automatic Air Conditioning)
- Removing And Installing Heater Controls (A/C Control)
- Removing And Installing Heater Control (automatic Air Conditioning)
- Removing And Installing/replacing The Rear Fan Completely
- Removing And Installing/replacing The Controller For The Rear Fan
- Replacing Servodrive Of Fresh Air/recirculated Air Flap (automatic A/C)
- Replacing Servodrive Of Recirculated Air Flaps (A/C Control)
- Replacing Servodrive Of Ventilation Flaps (automatic A/C)
- Replacing Servodrive Of Footwell Flap (automatic A/C)
- Replacing Servodrive Of Defrosting Flaps (automatic A/C)2
- Replacing Servodrive Of Ram Air Flap (automatic A/C)
- Replacing Servodrive Of Rear Compartment Flap (automatic A/C)
- Replacing Evaporator Temperature Sensor (A/C Control)2
- Replacing Evaporator Temperature Sensor (automatic A/C)
- Removing And Installing/replacing Interior Temperature Sensor (A/C Control)
- Replacing Temperature Sensor For Heater
- Replacing Temperature Sensor For Heater (A/C Control)
12 Auxil. Heater With Control Elements6 pages
- 31 Microfilter › Replacing Microfilter For Interior Ventilation
50 Air Conditioning System19 pages
- Air Conditioner Test (R 134a)
- Instructions For Handling Refrigerant R 134a
- Instructions For Handling Refrigerant Oil (for Refrigerant R 134a)2
- Leak Testing With Ultraviolet Additives (UV Additives) (BMW Leak-testing Case)23
- Leak-testing With Leak Tester Device2
- Safety Instructions For Handling Refrigerant R134a
- Safety Instructions For Handling Refrigerant Oil2
- Troubleshooting By Pressure Measurement (R 134a)23
- Drawing Off, Evacuating And Filling A/C System (R 134a)2
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
51 AC Housing-evaporator, Switching Elemts16 pages
65 Audio, Navigation And Information System43 pages
- 31 Interference Suppression › Removing And Installing/replacing Suppression Filter (left Or Right)
- 50 Video And TV Equipment › Removing And Installing/replacing Video Module For On-board Monitor23
75 Anti-theft Alarm System2 pages
77 Airbag Trigger Device, Diagnosis Unit9 pages
- Notes On Scrapping BMW Vehicles With Gas Generators (central Airbag Control Unit2
- Removing And Installing Airbag Control Unit2
- Replacing Airbag Control Unit
- Removing And Installing/replacing Impact Sensor For Left Or Right Side Airbag
- Removing And Installing Impact Sensor For Left Or Right Side Airbag (multiple Re
- Replacing Impact Sensor For Left Or Right Side Airbag (multiple Restraint System
- Replacing Sensor Mat For Passenger Seat Occupancy Detector
90 Navigation Systems7 pages
- Notes On Handling Navigation Computers
- Removing And Installing/replacing Navigation Computer With CD-drive
- Removing And Installing/replacing Receiver Module Of Global Positioning System (
- Removing And Installing/replacing Antenna Of Global Positioning System (GPS)
- Replacing CD/DVD Drive For Navigation Computer23
66 Distance Systems, Cruise Control › 20 Park Distance Control4 pages
67 Electrical Drives22 pages
- 13 Mirror Adjustment › Replacing Drive For Left Or Right Electrically Adjustable Door Mirror (with Mirr
16 Servo-positioning Drives7 pages
- Removing And Installing/replacing Left Headlight Vertical Aim Adjuster2
- Removing And Installing/replacing Left Headlight Vertical Aim Adjuster (xenon He23
- Removing And Installing/replacing Right Headlight Vertical Aim Adjuster
- Removing And Installing/replacing Right Headlight Vertical Aim Adjuster (xenon H
31 Drive, Seat Adjustment6 pages
- Removing And Installing/replacing Drive For Longitudinal Seat Adjustment (front
- Removing And Installing/replacing Drive For Seat Tilt Adjustment (front Seat Rem
- Removing And Installing/replacing Drive For Seat Height Adjustment (front Seat R
- Removing And Installing/replacing Drive For Backrest Angle Adjustment (front Sea
- Removing And Installing/replacing Drive Unit For Head Restraint Adjustment (comf
- Removing And Installing/replacing Drive For Head Restraint Height Adjustment On
- 66 Drive, Seat Adjustment › Removing And Installing/replacing Lumbar Support Drive Mechanism On Front Seat,2
72 Parts - Accessories (Body)69 pages
11 Seat Belts20 pages
- Safety Precautions And General Information
- Belt Catch Tensioner (information On Electrical System)
- Checking Automatic Safety Belt23
- Inspection List For Automatic Seat Belt2
- Removing And Installing/replacing Counter-support Plate On Seatbelt Height Adjus23
- Removing And Installing Or Replacing Front Left Or Right Safety Belt (complete U23
- Removing And Installing/replacing Rear Left Or Right Seat Belt23
- Removing And Installing / Replacing Rear Center Safety Belt234
12 Airbag Generator-airbag Unit For Pass43 pages
- Repairing Airbag Cables2
- Safety Precautions And General Information
- Safety Regulations For Handling Airbag System Components2
- Safety Regulations For Handling Components With Gas Generators2
- Airbag System
- Deactivation Of Airbags234
- Notes On Scrapping Vehicles With Gas Generators (airbag System)2
- Procedure After Airbag Triggering As Result Of An Accident23
- Safety Regulations For Handling Airbag Modules, Airbag Components And Pyrotechni
- Scrapping Vehicles With Passenger Airbag And Pyrotechnic Belt Tensioners
- Unlocking/locking Airbag Plug Connections234
- Removing And Installing/replacing Airbag Module On Passenger Side2
- Removing And Installing/replacing Airbag Module On Left Or Right Front Door
- Removing And Installing/replacing Airbag Module On Left Or Right Rear Door
- Removing And Installing / Replacing Left Or Right ITS Head Airbag (model Not Fit
- Removing And Installing / Replacing Left Or Right ITS Head Airbag (model Fitted234
- Removing And Installing / Replacing Left Or Right Head Airbag In Rear Compartmen2345
- Removing And Installing / Replacing Left Or Right Head Airbag In Rear Compartmen
- Removing And Installing/replacing Left Or Right Head Airbag In Rear Compartment2345
84 Communication Systems15 pages
11 Transceiver, Handset-support, Card Reade12 pages
- Removing And Installing/replacing Eject Box (V Series Cellular Telephone)2
- Removing And Installing/replacing Eject Box2
- Removing And Installing/replacing Transceiver
- Removing And Installing/replacing Interface For D-Network Car Phone
- Removing And Installing/replacing Hands-free Microphone
- Replacing Cordless Keypad Handset
- Removing And Installing/replacing Eject Box (cordless Keypad Handset)2
- Removing And Installing Transmit-receive Unit
- Replacing Transmit-receive Unit
- 21 Handheld Computer › Removing And Installing/replacing Hands-free Charging Electronics
86 Trailers107 pages
10 Loading Platform71 pages
- Body And Underbody: Checking For Corrosion And Damage
- Raising BMW Multi-trailer23
- Adjusting Brake System23
- Adjusting Spring Force Accumulator
- Disassembly Of Camlock Retaining Cam
- Disassembly Of Base Plate
- Disassembly Of Bracket On Platform Base
- Disassembly Of Front Apron
- Disassembly Of Front Protection Bar
- Disassembly Of Jockey Wheel Or Jockey Wheel Mount
- Disassembly Of Left And Right Aprons
- Disassembly Of Left And Right Lamp Housings
- Disassembly Of Left And Right Wheel Boxes
- Disassembly Of Licence Plate Mounting Plate
- Disassembly Of Loading Ramp Frame/disassembly Of Rail, Left/right
- Disassembly Of Rear Apron
- Disconnecting Plug Connection, Wiring Harness, Front/rear
- Installation Position Of BMW Lettering
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Removing Camlock Retaining Cam On Loading Ramp
- Removing Camlock Screw Cap
- Removing And Installing Or Replacing Left Or Right Coil Spring2
- Removing Bolt On Loading Ramp
- Removing Brake Shoes2345
- Removing Entry Profile Section On Loading Ramp, Left, Right And Center
- Removing Left Or Right Shock Absorber
- Removing Loading Ramp Lock2
- Removing Mounting Bracket Sealing Cap
- Removing Mounting Bracket, Center, Left And Right
- Removing Outer Pull Rod Mount, Left And Right
- Removing Overrunning Equipment/maintaining Or Replacing Guide Bush/installing Ov2345
- Removing Plastic Bush/metal Bush
- Removing Rear Supports And Bracket
- Removing Reflecting Rear Light
- Removing Rest On Loading Ramp, Left, Right And Center
- Removing Shock Absorber From Overrunning Equipment
- Removing Trailing Arm, Removing And Installing Or Replacing Mounting23
- Removing Wheel Bearing2
- Removing Wooden Rest On Loading Ramp, Left, Right And Center
- Repair Work On GFP Components With Gelcoat Surface
- Replacing 12 Volt Socket2
- Replacing Bar
- Replacing Drawbar Members, Left And Right2
- Replacing Gaiter
- Replacing Holder For Chock
- Replacing Lashing Plate And Lashing Eye
- Replacing License Plate Light
- Replacing Position Light
- Replacing Rear Light
- Troubleshooting On Multi-trailer2
21 Hood36 pages
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Adjusting Hood Pretension - Camloc Fastener With Spacers23
- Adjusting Rear Lid To Fit2
- Adjusting Rotary Striker Lock
- Adjusting Side Lid To Fit2
- Attaching/replacing BMW Badge2
- Fitting BMW Logo
- Installing Hood Seal
- Installing Rubber Roof Strip
- Installing Seal For Rear Lid And Side Lid
- Installing Sponge Rubber Seal
- Removing Ball Pivot
- Removing Centering Pin From Mounting Bracket
- Removing Gas Spring
- Removing Gas Spring Retaining Bracket
- Removing Hinge Bracket On Rear Lid
- Removing Lid
- Removing Lock Barrel
- Removing Lock Striker Fixture On Rear Lid
- Removing Plug For Inside Light2
- Removing Roof Railing
- Removing Roof Railing Adapter2
- Removing Rotary Striker Lock2
- Removing Side Lid Hinge
- Replacing Inside Light
- Replacing Inside Light Power Cable2
99 Paintwork2 pages