Z4 E86 3.0Si Coupé (N52): 2 Repair Instructions
Also for this vehicle: Z Series E86 M coupe (S54) COUPE.
Maintenance
General
Diagnostics
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
0 Maintenance And General Data55 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Pre-delivery Check2345
- Lifting Vehicle With A Lifting Platform
- Notes On Using Repair Instructions, Technical Data, Tightening Torques
- Raising Vehicle With Trolley Jack
- Symbols Used And Information In Repair Instructions2
- Battery: Checking Display. If Necessary, Recharge Battery
- Body And Underbody: Checking For Corrosion And Damage
- Body: Check For Corrosion (except Cavities)
- Brake Lines And Connections: Visual Inspection For Leaks, Damage And Correct Pos
- Check Windscreen Wash/wipe System
- Checking Coolant Level And Concentration, Correcting If Necessary
- Checking Horn, Headlight Flashers And Hazard Warning System
- Checking Instrument And Indication Field Lighting, Heater Blower
- Checking Lighting System
- Checking Roadworthiness (test Drive)
- Diagnostic Brief Test
- Information/warning Labels23
- Microencapsulated Screws
- Raising BMW Multi-trailer23
- Seat Belts: Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
- Steering Components: Checking For Zero Clearance, Leaks, Damage And Wear2
- Steering Fluid Reservoir: Check Oil Level2
- Tyres: Checking Inflation Pressure, Correcting If Necessary (incl
- Underbody Incl
- Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid23
- Windscreen Washer System: Checking Fluid Level, Topping Up If Necessary
- Interrogating Fault Memories In Diagnosis System
- Engine Oil Service Incl2
- Checking/topping Up Oil Level In Rear Differential
- Draining/topping Up Gear Oil In Manual Transmission
- Oil Change In Manual Transmission
- Checking/topping Up Fluid Level In Automatic Transmission (GA6HP19Z)2
- Oil Change In Rear Differential Incl2
- Notes On Handling Wiring Harnesses And Cables
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
11 Engine (N52)154 pages
0 Engine, General16 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Repairing Threads On Magnesium Engine Block23
- Securing Engine In Installation Position (N52)23
- Engine Identification2345
- Mounting Engine On Assembly Stand (N52)2
12 Cylinder Head With Cover16 pages
- Removing And Installing/sealing Cylinder Head Cover (N52)2
- Removing And Installing Cylinder Head (N52)23456
- Replacing Cylinder Head Gasket (N52)23
- Remachining A Valve Seat - Disassembling Cylinder Head (N52)
- Checking A Valve Guide For Wear (N52)
- Resurfacing Cylinder Head Sealing Face (N52)
- Checking Cylinder Head For Water Leaks (N52)2
21 Crankshaft With Bearing11 pages
- 22 Flywheel › Removing And Installing Or Replacing Flywheel (N52)2
- 23 Vibration Damper › Removing And Installing Or Replacing Vibration Damper (N52)
- 24 Connecting Rod With Bearing › Replacing All Connecting Rod Bearings (N52)23
25 Piston With Rings And Pin10 pages
28 V-ribbed Belt W.tens.-deflect.elemt4 pages
- 33 Rocker Arm With Bearing Mount › Removing And Installing/replacing All Rocker Arms (N52)2
36 Variable Camshaft Timing4 pages
- 40 Oil Supply › Checking Engine Oil Pressure (N52)2
41 Oil Pump With Filter And Drive6 pages
- 42 Oil Filter And Lines › Removing And Installing/replacing Fullflow Oil Filter (N52)2
- 44 Oil Cooler › Removing And Installing/replacing Oil-water Heat Exchanger (N52)2
- 51 Water Pump With Drive › Removing And Installing/replacing Water Pump (N52)2
53 Thermostat And Connections4 pages
- 61 Intake Manifold › Removing And Installing Intake Air Manifold (N52)2
- 66 Vacuum Pump › Removing And Installing/replacing Vacuum Pump (N52)2
- 71 Exhaust Gas Recirculation › Removing And Installing Or Replacing EGR Cooler (N47)2
78 Emission Control, Oxygen Sensor4 pages
12 Engine Electrical System (N52)61 pages
0 Troubleshooting8 pages
- 12 Ignition Wires, Spark Plugs › Replacing All Spark Plugs (N42, N40, N46, N45, N52, N52K, N51)
14 Electronic Switching Or Contr.units13 pages
- Replacing Crankshaft Pulse Generator (N52, N52K, N51, N53)2
- Replacing Inlet Camshaft Pulse Generator (N52, N52K, N51, N53)
- Replacing Exhaust Camshaft Pulse Generator (N52, N52K, N51, N53)
- Replacing Control Unit (DME)23
- Removing/replacing Knock Sensors (N52, N52K, N51)2
- Coding Control Module (DME / DDE)
- Programming Control Unit (DME / DDE)
- Replacing Fan For Electronics Box (N52)
- Removing And Installing/replacing Engine Compartment B- Terminal
- 32 Regulator › Replacing Voltage Regulator23
41 Starter With Mounting3 pages
51 Engine Wiring Loom6 pages
61 Oil Pressure-oil Temperature-oil Gauge2 pages
90 Control Unit Box2 pages
13 Fuel System (N52)25 pages
31 Fuel Pump With Drive And Line5 pages
53 Injection Nozzle And Lines4 pages
62 Sensor For Control Unit5 pages
- 72 Air Cleaner › Replacing Air Filter Element (N52)
- 90 Carbon Canister Ventilation › Replacing Tank Vent Valve (N52 / N52K / N51 / N53)
16 Fuel Supply System (N52)31 pages
0 Fuel Pick-up, Cleaning System14 pages
- E85 Fuel Supply System (spark-ignition Engines)23
- General Function Description For Fuel Supply Systems
- Draining And Filling Fuel Tank2
- Checking Fuel Tank And Tank Venting System For Leaks (petrol/gasoline Without Ta23
- Checking Fuel Tank And Tank Venting System For Leaks With Tank Leakage Diagnosis2
- Conducting Leak Test On Fuel Tank And Tank Ventilation System2
- Conducting Leak Test On Fuel Tank And Tank Ventilation System
12 Fuel Transfer, Sensor For Gauge4 pages
- 13 Fuel Ventilation › Removing And Installing/replacing Tank Leakage Diagnosis Module
17 Cooling System (N52)33 pages
18 Exhaust System (N52)13 pages
- 0 Exhaust System, Complete › Removing And Installing Complete Exhaust System (N52)23
40 Exhaust Manifold With Integrated Catalyt6 pages
21 Clutch29 pages
- 0 Maintenance And Inspections › Bleeding Clutch Hydraulic System23
- 21 Clutch With Driving Disc › Removing And Installing Or Replacing Clutch (SAC 228)2345678910111213
- 51 Clutch Release Controller W. Lever › Removing And Installing Or Replacing Clutch Release Bearing/lever2345
52 Clutch Operation (hydraulic)5 pages
- 90 Troubleshooting › Troubleshooting The Clutch23
22 Engine And Gearbox Suspension7 pages
23 Manual Transmission (MECH)26 pages
0 Complete Transmission18 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Draining/topping Up Gear Oil In Manual Transmission
- Oil Change In Manual Transmission
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Overview Of Transmission Housing (GS6-37BZ / H-transmission)
- Removing And Installing Transmission (GS6-37BZ) N522345
- Installing Replacement Transmission (GS6-37BZ/DZ)2
- 11 Housing With Cover › Replacing Guide Tube For Clutch Release Unit (GS6-37BZ/DZ)
24 Automatic Transmission (AUT)42 pages
0 Transmission Assembly19 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Checking/topping Up Fluid Level In Automatic Transmission (GA6HP19Z)2
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Adjusting Selector Lever (A5S 360R / 390R, A4S 200R, 6HP26Z/19Z)
- Removing And Installing Automatic Transmission (6HP19Z/N52)23456
- Installing Replacement Transmission (GA6HP19Z/N52/N52K/N53/N54)2
- 11 Transmission Case, Oil Sump › Removing And Installing/sealing Or Replacing Transmission Sump (GA6HP19Z)2
- 13 Extension Housing, Bearings, Seal › Replacing Output Flange Shaft Seal (GA6HP19)23
- 14 Mechanical Attachments › Replacing Selector Shaft Seal (GA6HP19)23
- 31 Oil Pump › Replacing Torque Converter Flange Shaft Seal (GA6HP19Z)2
- 40 Torque Converter › Removing And Installing/replacing Torque Converter (GA6HP19Z)2
25 Gear Shift Mechanism (AUT) › 16 Centre Shift, Automatic Transmission6 pages
25 Gear Shift Mechanism (MECH) › 11 Centre Shift, Manual Transmission14 pages
- Overview Of Gearshift Mechanism For Manual Transmission
- Replacing U-gaiter
- Replacing Shift Rod
- Removing And Installing Shift Lever2
- Replacing Complete Shift Lever
- Replacing Bearing Shell For Shift Lever
- Replacing Knob For Shift Lever
- Replacing Gaiter (shift Lever Cover) For Shift Lever
- Replacing Shift Rod Joint
- Replacing Shift Arm For Shift-lever Mount2
- Replacing Bearing Bushes For Shift Arm
- Replacing Shift Arm Support Bearing
26 Propeller Shaft17 pages
- 0 Propeller Shaft, General › Propeller Shaft Deflection Angles
11 Propeller Shaft Assembly10 pages
27 Transfer Box › 0 Transfer Case, General3 pages
31 Front Axle54 pages
0 General11 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Front Axle Overview
- Layout Of Spring Strut Shock Absorber
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Notes On Repairing Threads2
11 Front Sub-frame2 pages
21 Wheel Bearings And Stub Axle6 pages
31 Spring Strut11 pages
90 Troubleshooting3 pages
32 Steering And Wheel Alignment91 pages
0 Electronic Chassis Alignment33 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Overview Of Steering
- Chassis/wheel Alignment Check Procedure
- General Chassis And Suspension Definitions
- General Information And Definitions2
- Identification Of Suspension Without Label
- Information On Replacing Steering Gear After Accident Damage2
- Moving Vehicle Into Design Position
- Moving Vehicle Into Normal Position
- Performing Rim Runout Compensation
- Test Conditions For Chassis/wheel Alignment Check
- Troubleshooting After Wheel/chassis Alignment Check On Front Axle2
- Troubleshooting After Wheel/chassis Alignment Check On Rear Axle2
- KDS Chassis/wheel Alignment Check With Load Up To Design Position23
- KDS Chassis/wheel Alignment Check With Ride-height Measurement Without Load23
- Adjusting Toe-in And Camber On Front Axle23
- Adjusting Rear Axle
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Carrying Out Steering Angle Sensor Adjustment
- 13 Steering Gear With Servo Unit › Information On Replacing Steering Gear After Accident Damage2
21 Steering Arms, Tie Rods, Steer. Damper6 pages
31 Steering Column20 pages
- Removing And Installing/replacing Upper Section Of Steering Column Trim2
- Removing And Installing / Replacing Lower Section Of Steering Column Trim
- Removing And Installing / Replacing Lower Section Of Steering Spindle2
- Removing And Installing/replacing Steering Angle Sensor2
- Removing And Installing Steering Column234
- Replacing Steering Spindle Sleeve
- Removing And Installing/replacing Holder For Steering Spindle Sleeve
- Replacing Adjusting Lever For Steering Column2
- Replacing Complete Steering Lock2
- Replacing Steering Tube Bearing23
- 41 Pump And Oil Supply › Instructions For Removing And Installing Ear Clips2
- 90 Troubleshooting › Troubleshooting On Steering
33 Rear Axle114 pages
0 General18 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Rear Axle Layout
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Notes On Repairing Threads
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Overview Of Rear Differential/output Shafts
- Overview Of Rear Axle Carrier With Rubber Mounts
- Overview Of Control Arms With Rubber Mounts
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
11 Final Drive With Cover14 pages
- Replacing Rear Cover Gasket On Rear Differential (188L / 188LW)
- Replacing Shaft Seal For Input Flange On Final Drive2345
- Replacing Left Drive Flange On Rear Differential2
- Replacing Right Drive Flange On Rear Differential
- Replacing Shaft Seal For Left Drive Flange2
- Replacing Shaft Seal For Right Drive Flange
- Replacing Rear Cover Gasket On Rear Differential2
21 Output Shafts10 pages
32 Control Arms And Struts25 pages
- Overview Of Control Arms With Rubber Mounts
- Replacing Bearing Block For Front Trailing Arm2
- Removing And Installing Complete Left Or Right Trailing Arm2
- Replacing Left Or Right Trailing Arm
- Replacing A Rubber Mount In Trailing Arm, Front2
- Replacing One Rubber Mount/ball Joint In Trailing Arm For Lower Control Arm2
- Removing And Installing/replacing Top Left Control Arm2
- Removing And Installing / Replacing Top Right Control Arm2
- Removing And Installing/replacing Bottom Left Control Arm23
- Removing And Installing/replacing Bottom Right Control Arm2
- Removing And Installing / Replacing Compression Strut For Rear Axle Carrier
- Replacing One Ball Joint In The Semi-trailing Arm (semi-trailing Arm Removed)2
- Replacing One Rubber Mount In The Upper Control Arm (control Arm Removed)
- Replacing One Rubber Mount In Lower Control Arm (control Arm Removed)
- Removing And Installing/replacing Left Or Right Tension Strut (on Rear Axle)
53 Springs With Suspension4 pages
90 Troubleshooting3 pages
34 Brakes77 pages
0 Brake Testing And Bleeding11 pages
11 Front Brakes13 pages
- Overview Of Front Brakes
- Removing And Installing/replacing Brake Linings Of Both Front Disc Brakes234
- Removing And Installing Or Replacing Both Front Brake Discs2
- Removing And Installing / Replacing A Brake Carrier / Brake Guard Plate At Front
- Removing And Installing/replacing Left Or Right Front Brake Caliper2
- Overhauling Left Or Right Front Brake Caliper (brake Caliper Removed)2
- Precision-turning Both Front Brake Discs On Both Sides
21 Rear Brakes13 pages
- Overview Of Rear Brake
- Replacing Rear Left Or Right Brake Anchor Plate
- Removing And Installing/replacing Both Rear Disc Brakes234
- Removing And Installing/replacing Both Brake Discs
- Removing And Installing/replacing Left Or Right Rear Brake Caliper2
- Overhauling Left Or Right Rear Brake Caliper (brake Caliper Removed)23
- Precision-turning Both Rear Brake Discs On Both Sides
- 35 Electrical Components - Wear Indicator › Replacing A Brake Pad Sensor (front)
41 Parking Brake13 pages
- General Information On Braking In New Brake Discs / Brake Pads
- Adjusting Handbrake234
- Overview Of Parking Brake
- Removing And Installing/replacing Handbrake Lever With Mounting Pan23
- Removing And Installing/replacing Both Handbrake Bowden Cables
- Removing And Installing/replacing All Handbrake Shoes2
- Removing And Installing/replacing Expander Lock For Handbrake Shoes
- 51 Mechanical-hydraulic Components › Removing And Installing/replacing DSC Hydraulic Unit2
- 90 Troubleshooting › Troubleshooting Brake System234
35 Pedals5 pages
- 11 Pedal Mounting Block › Removing And Installing Mounting Block For Pedals
- 21 Brake Pedal With Linkage › Removing And Installing/replacing Brake Pedal2
- 31 Clutch Pedal With Linkage › Removing And Installing / Replacing Clutch Pedal
- 40 Accelerator Pedal Actuation › Removing And Installing Or Replacing Accelerator Pedal Module
36 Wheels With Tyres26 pages
37 Integrated Suspension Systems5 pages
14 Electrical Components2 pages
41 Body (COUPE)125 pages
0 Body63 pages
- Contents Of Body, General2
- Bonding Plastic Parts
- Bonding Steel Parts2
- Corrosion Protection2
- Frame Alignment Control Dimensions, Body23
- Gap Dimensions, Body2
- General Cementing Instructions
- Grinding Aluminum Parts
- Grinding Steel Parts
- Handling Airbags And Restraint Systems
- Handling Electrical And Electronic Equipment
- Information / Warning Labels
- Information On Hazards
- Information On Vehicle Protection
- Installation Of A Cavity Seal With Cavity Foam2
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
- Materials Science23
- Notes On Repairing Threads
- Opening Adhesive Bonds
- Opening Weld Joints
- Position Of Shaped Parts For Cavity Acoustic Baffle
- Quality Standard
- Riveting Aluminium Parts2
- Riveting Steel Parts
- Safety At Work2
- Spot-weld Bonding Steel Parts
- Stamping Vehicle Identification Number2
- Straightening Aluminium Parts2
- Straightening Steel Parts2
- Use Of Materials In Outer Shell2
- Vehicle Identification Number, General
- Welding And Soldering Steel Parts23
- Welding In Reinforcement Plate (steel Plate)2
- Workshop Equipment2
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
- Notes On Cavity Foam2
- General Instructions On Painting
11 Support Members17 pages
- Replacing Front Left Or Right Engine Bracket With Wheel Arch2
- Replacing Left Engine Carrier (partial Replacement Before Front Axle)
- Replacing Front Left Engine Carrier (without Wheel Arch) (partial Replacement Be2
- Replacing Cover For Left Or Right Frame Side Member (partial Replacement Between2
- Replacing Cover For Left Or Right Frame Side Member (side Panel Removed At Front23
- Replacing Front Left Or Right Support Carrier
- Replacing Front Luggage Compartment Floor Cross-member (luggage Compartment Floo2
- Replacing Complete Rear Tension Strut Mounting (luggage Compartment Floor And Ta2
- Replacing Left Or Right Cowl Panel (partial Replacement)2
14 Wheel Wells10 pages
- Stamping Vehicle Identification Number2
- Vehicle Identification Number, General
- Replacing Front Left Or Right Support Carrier
- Replacing Front Left Or Right Wheel Arch
- Replacing Rear Left Outer Wheel Arch Section (rear Left Side Panel Removed)2
- Replacing Complete Rear Left Wheel Arch (rear Left Side Panel Removed)2
- Replacing Left B-pillar (rear Left Side Panel Removed)
21 Side Frame And Door Pillars9 pages
- Replacing Cover For Left Or Right Frame Side Member (partial Replacement Between2
- Replacing Cover For Left Or Right Frame Side Member (side Panel Removed At Front23
- Replacing Left B-pillar (rear Left Side Panel Removed)
- Replacing Front Left Or Right Door Pillar (front Side Panel Removed)
- Replacing Left Or Right Cowl Panel (partial Replacement)2
- 31 Roof Outer Skin › Replacing Roof Outer Skin2
- 33 Front Trim Panel › Replacing Front Wall
51 Front Side Doors4 pages
61 Front Lid3 pages
63 Other Flaps2 pages
51 Body Equipment (COUPE)236 pages
11 Front Bumper12 pages
- Overview Of Front Bumper
- Removing And Installing/replacing Cover For Headlight Washer System On Left
- Removing And Installing / Replacing Carrier For Front Bumper Trim
- Removing And Installing Front Bumper Trim2
- Replacing Front Bumper Trim2
- Replacing Baseplate For License Plate
- Removing And Installing / Replacing Trim Grille In Bumper Trim
- Replacing Left Or Right Bracket For Front Bumper
- Removing And Installing/replacing Left Or Right Deformation Element For Front Bu2
12 Rear Bumper11 pages
- Survey Of Rear Bumper
- Removing And Installing / Replacing Carrier For Rear Bumper Trim
- Removing And Installing/replacing Carrier For Rear Bumper Trim (US Version)
- Removing And Installing Rear Bumper Trim2
- Replacing Rear Bumper Trim2
- Removing And Installing/replacing License Plate Holder
- Replacing An Impact Absorber For Rear Bumper (US Version)
- Replacing Bracket For Rear Bumper At Left Or Right
- Removing And Installing/replacing Guide For Rear Centre Bumper
13 Trim, Covers, Handle Trim11 pages
- Replacing Front Radiator Grill, Middle Left Or Right2
- Removing And Installing/replacing Front Radiator Grille, Middle Left Or Right
- Removing And Installing/replacing Trim On Front Left Or Right Side Panel
- Removing And Installing / Replacing Cowl Panel Cover2
- Replacing Trim Strip On Roof Frame At Left Or Right
- Removing And Installing/replacing Frame On Left Or Right Rear Light2
- Replacing Speaker Cover On Left Or Right Door Trim Panel
- Removing And Installing / Replacing Finishing Strip At Front Left Or Right Entra
14 BMW Emblems, Model Emblems7 pages
- Instructions For Attaching Number/letter Designation Combination
- Replacing Front BMW Badge (removing And Replacing)
- Replacing BMW Badge On Side Direction Indicator2
- Replacing (removing And Installing) Number/letter Combination On Front Left Or R
- Removing And Installing/replacing Rear BMW Badge
- Removing And Installing/replacing Rear Model Designation
16 Mirrors-covers-ashtrays-shelves-trays49 pages
- Cementing Of Mirror Base2
- Removing And Installing/replacing Centre Cover On Instrument Panel
- Removing And Installing/replacing Handbrake Lever Cover2
- Replacing Finisher On Left Instrument Panel Trim
- Removing And Installing/replacing Mirror On Left Or Right Front Door
- Replacing Mirror Glass
- Replacing Left Or Right Door Mirror Housing2
- Removing And Installing/replacing Interior Rearview Mirror (overview)2
- Removing And Installing/replacing Interior Rearview Mirror (with Japanese Toll M23
- Removing And Installing/replacing Interior Rearview Mirror (with Mirror Arm End23
- Removing And Installing/replacing Interior Rearview Mirror (with Rain Sensor)23
- Removing And Installing Or Replacing Sun Visor And Left Or Right Counter Support
- Removing And Installing/replacing Storage Compartment2
- Removing And Installing/replacing Front Cup Holder
- Removing And Installing/replacing Trim For Preselector Lever (gearshift Lever)
- Removing And Installing/replacing Trim For Storage Compartment
- Replacing Finisher On Right Instrument Panel Trim2
- Removing And Installing Panel For Rear Storage Box2
- Removing And Installing/replacing Panel For Storage Box Upper Section At Rear
- Removing And Installing/replacing Lid On Rear Storage Box2
- Removing And Installing/replacing Rear Storage Box
- Removing And Installing/replacing Lock On Rear Storage Box2
- Removing And Installing/replacing Lock Fastener For Right Glovebox (with Active2
- Removing And Installing/replacing Lock Fastener For Right Glovebox (without Acti
- Removing And Installing/replacing Lock Cylinder For Passenger Airbag Deactivatio2
- Removing And Installing Right Glovebox (with Active Knee Protection)
- Replacing Right Glovebox (with Active Knee Protection)
- Replacing Right Glovebox (without Active Knee Protection)
- Removing And Installing Right Glovebox With Housing (without Active Knee Protect
- Removing And Installing Right Glovebox With Housing (with Active Knee Protection2
- Removing And Installing/replacing Damper For Glovebox
- 20 Lock Cylinders, Assembly › Removing And Installing/replacing Lock Cylinder For Passenger Airbag Deactivatio2
21 Front Door Locks, Handles, Fittings17 pages
- Adjusting Front Left Or Right Door Detent (lock Wedge)
- Removing And Installing/replacing Door Lock In Left Or Right Front Door2
- Removing And Installing/replacing Complete Lock Cylinder In Left Or Right Front2
- Blocking, If Necessary Initializing, Car Key In Immobilizer Control Module
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo2
- Removing And Installing/replacing Outside Handle And Lock Actuation Of Left Or R23
- Removing And Installing Or Replacing Inside Door Opener In Left Or Right Front D2
- Removing And Installing Or Replacing Door Brake On Left Or Right Front Door2
- Removing And Installing/replacing Window Cavity Cover Strip On Front Door2
23 Hood Latch, Locks9 pages
- Adjusting/replacing Bump Stops2
- Adjusting Hood/bonnet Lock
- Removing And Installing/replacing Right Engine Hood/bonnet Lock
- Removing And Installing/replacing Left Hood/bonnet Lock
- Adjusting Left Or Right Striker On Engine Hood
- Removing And Installing/replacing Arrester Hook On Engine Hood
- Removing And Installing/replacing Cable For Front Hood/bonnet Locks (in Engine C
- Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
24 Trunk Latch, Locks9 pages
- Adjusting Rear Lid Lock (lower Section Of Rear Lid Lock)23
- Removing And Installing/replacing Rear Lid Lock (upper Section)
- Removing And Installing/replacing Striker For Rear Lid Lock
- Removing And Installing/replacing Button For Rear Lid Actuation2
- Removing And Installing Or Replacing Left Or Right Gas Strut For Rear Lid
- Replacing Rubber Mount On Rear Lid Lid Support
31 Front And Rear Window18 pages
- Instructions On Gluing Windscreen23456789
- Removing Windscreen With /Roll Out 20002345
- Removing And Installing / Replacing Windscreen
- Repairing Damage To Windscreens Caused By Pitting (stone Chips) (clear And Tinte
- Removing And Installing/replacing Rubber Frame For Windshield
- Removing And Installing/replacing Rear Window
41 Front Door Trim Panel With Arm Rest11 pages
- Replacing Speaker Cover On Left Or Right Door Trim Panel
- Removing And Installing Left Or Right Front Door Trim Panel23
- Replacing Front Left Or Right Door Trim Panel2
- Removing And Installing/replacing Cover On Door Handle, Front Left Or Right
- Removing And Installing/replacing Door Handle On Door Trim Panel, Front Left Or
- Removing And Installing/replacing Sound Insulation In Front Door, Left Or Right23
43 Side Covering With Armrests11 pages
- Removing And Installing/replacing Rear Left Or Right Upper Side Trim Section2
- Removing And Installing/replacing Rear Left Or Right Lower Side Trim Section
- Removing And Installing/replacing Cover On Side Trim Panel Upper Section On Left2
- Removing And Installing/replacing Side Trim Panel, Footwell, On A-pillar, Left
- Removing And Installing / Replacing Side Trim Panel, Footwell, On A-pillar, Righ
- Removing And Installing/replacing Rear Left Or Right Chest Strip
- Removing And Installing/replacing Panel For Left Or Right Door Pillar
- Removing And Installing/replacing Panel For Roof Pillar At Front (A-pillar), Lef
- Removing And Installing/replacing Trim Panel For Left Or Right Rear Roof Pillar
45 Instrument Cluster Trim Panel10 pages
- 46 Parcel Shelf Trim Pan.-roller Sun Blind › Removing And Installing/replacing Top Trim On Rear Apron
47 Floor-lugg.comp.-eng.comp.tr.panels11 pages
- Removing And Installing/replacing Panel In Luggage Compartment At Top Left Or Ri
- Removing And Installing/replacing Front (inside) Left Or Right Entrance Cover St
- Removing And Installing / Replacing Finishing Strip At Front Left Or Right Entra
- Removing And Installing/replacing Luggage Compartment Floor Trim Panel
- Removing And Installing/replacing Panel For Luggage Compartment Partition
- Removing And Installing/replacing Roller Blind
- Removing And Installing/replacing Left Luggage Compartment Wheel Arch Trim2
- Removing And Installing/replacing Right Luggage Compartment Wheel Arch Trim2
- Removing And Installing / Replacing Front Underbody Protection
- 48 Front Lid Insulation Lining › Removing And Installing/replacing Sound Insulation In Front Door, Left Or Right23
71 Gaskets-seals, Loose Body Components12 pages
- Removing And Installing / Replacing Cowl Panel Cover2
- Removing And Installing/replacing Rear Left Or Right Wheel Arch Splash Guard
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover
- Removing And Installing/replacing Rear Left Or Right Wheel Arch Cover
- Removing And Installing/replacing Tension Strut On Left Or Right Spring Strut Do
- Removing And Installing/replacing Reinforcement Plate On Front Axle Support2
- Removing And Installing/replacing Reinforcement Plate On Rear Axle2
- Removing And Installing Or Replacing Panel For Cover On Left Or Right Side Membe
- Removing And Installing/replacing Left Or Right Tension Strut (on Rear Axle)
52 Seats86 pages
13 Front Seat, Normal, Manual24 pages
- Overview Of Front Seat (normal/manual)
- Removing And Installing/replacing Belt Guide On Left Or Right Backrest
- Removing And Installing/replacing Guide For Front Left Or Right Head Restraint
- Replacing Seat Pan And Flexmat On Left Or Right Front Seat2
- Removing And Installing Left Or Right Front Seat
- Removing And Installing/replacing Actuating Unit On Left Or Right Front Seat234
- Removing And Installing/replacing Left Or Right Seat Mechanism (normal/manual)
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat
- Removing And Installing/replacing Outer Cover On Left Or Right Front Seat2
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Headrest
- Replacing Cover For Left Or Right Front Seat234
- Replacing Backrest Cover For Left Or Right Front Seat2
- Replacing Support For Left Or Right Front Seat
- Replacing Padding For Left Or Right Front Seat Backrest
14 Front Seat, Normal, Electric24 pages
- Removing And Installing/replacing Belt Guide On Left Or Right Backrest
- Removing And Installing/replacing Guide For Front Left Or Right Head Restraint
- Replacing Seat Pan And Flexmat On Left Or Right Front Seat2
- Removing And Installing Left Or Right Front Seat
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Headrest
- Replacing Cover For Left Or Right Front Seat234
- Replacing Backrest Cover For Left Or Right Front Seat2
- Replacing Support For Left Or Right Front Seat
- Replacing Padding For Left Or Right Front Seat Backrest
- Additional Work In Event Of Faulty Drive/gearing For Longitudinal Seat Adjustmen2
- Overview Of Front Seat (normal/electric)
- Removing And Installing/replacing Carrier For Outer Cover On Left Or Right Front
- Removing And Installing/replacing Left Or Right Seat Mechanism (normal/electric)
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (norma23
15 Front Seat, Sports, Manual19 pages
- Replacing Seat Pan And Flexmat On Left Or Right Front Seat2
- Removing And Installing/replacing Left Or Right Seat Mechanism (normal/manual)
- Removing And Installing Left Or Right Front Seat
- Removing And Installing/replacing Actuating Unit On Front Left Or Right Seat (sp
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (sport2
- Removing And Installing/replacing Belt Guide On Left Or Right Backrest
- Removing And Installing Backrest On Left Or Right Front Door
- Replacing Backrest On Left Or Right Front Seat
- Replacing Cover For Left Or Right Front Seat2345
- Replacing Backrest Cover For Left Or Right Front Seat2
- Replacing Padding For Left Or Right Front Seat
- Replacing Padding For Left Or Right Front Seat Backrest
16 Front Seat, Sports, Electric19 pages
- Replacing Seat Pan And Flexmat On Left Or Right Front Seat2
- Removing And Installing/replacing Left Or Right Seat Mechanism (normal/electric)
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (norma23
- Removing And Installing Left Or Right Front Seat
- Removing And Installing/replacing Belt Guide On Left Or Right Backrest
- Removing And Installing Backrest On Left Or Right Front Door
- Replacing Backrest On Left Or Right Front Seat
- Replacing Cover For Left Or Right Front Seat2345
- Replacing Backrest Cover For Left Or Right Front Seat2
- Replacing Padding For Left Or Right Front Seat
- Replacing Padding For Left Or Right Front Seat Backrest
- 54 Slide-tilt Sunroof And Convertible Top (COUPE) › 10 Sunroof › Repair Instructions For Bonded Seals23
61 General Electrical System175 pages
0 Troubleshooting14 pages
- Instructions On Starting Aid
- Battery
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Treating Cables And Fibre-optic Cables
- Performing Battery /power Reset: (for Programming/coding Control Unit(s))
- 11 Wiring Harness › Notes On Handling Wiring Harnesses And Cables
12 Auxiliary Cable16 pages
- Replacing Battery Positive Lead
- Replacing Battery Positive Lead (from Luggage Compartment Connector To Engine Bu234
- Replacing Battery Negative Lead
- Replacing Wiring Harness For Rear Bumper
- Replacing Wiring Harness In Left Or Right Front Door
- Replacing Wiring Harness For Electrically Adjustable Front Seat
- Replacing Cable For Left Or Right Belt Buckle Tensioner
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
13 Plug Connection, Terminal, Fuse Box50 pages
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Butt Connector For Repairing A Plug Connection234
- Crimping Stop Parts234
- DME Master Relay Connector
- Installing Fan Connector For Retrofitting/repairs2345
- Special Tools For Wiring Harness Repairs23
- Unlocking And Disconnecting Different Plug Connections23
- Base Of Tab Connector Housings
- Crimping Micro Power Quadlock Contacts (MPQ)
- Crimping Micro Quadlock System Contacts (MQS)2
- Crimping Annular Contacts
- Crimping Optical Fibres2
- Cutting Off, Stripping Insulation And Cutting Optical Fibres To Length23
- Cutting To Length And Stripping Insulation From Cables
- In-line Plugs, 30-pin, Hybrid System MQS/MPQ2
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Plug Housing, LCC Contact (load Current Contact)2
- Relay Carrier
- Repairing Ribbon Cables
- Retaining Bracket
- Socket Housing (radio Plug), Hybrid System MQS/MPQ23
- Treating Cables And Fibre-optic Cables
- Replacing Fuse Box For Distribution Box2
- 14 Distribution Box, Power Support Points › Removing And Installing/replacing Engine Compartment B- Terminal
20 Battery18 pages
- Instructions For Disconnecting And Connecting Battery23
- Instructions On Starting Aid
- Battery
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Threshold Values For Battery Inspection Of All Battery (telephone Except For Tel
- AGM Battery234
- Battery Charging
- Battery Open-circuit Current Test
- Disconnecting And Connecting Battery Negative Lead2
- Performing Battery /power Reset: (for Programming/coding Control Unit(s))
21 Battery-vapour Separator3 pages
31 Switch36 pages
- Overview Of Switches In Instrument Panel/driver's Footwell
- Overview Of Switches On Center Console Or Panel For Storage Box At Rear
- Removing And Installing/replacing Fixture For Steering Column Stalk
- Removing And Installing/replacing Turn Indicator/headlight Dipping Switch
- Removing And Installing/replacing Cruise Control Switch
- Removing And Installing/replacing Ignition Starter Switch
- Removing And Installing/replacing Light Switch Unit
- Removing And Installing/replacing Switch For Windscreen Wipers
- Removing And Installing/replacing Shift Paddles For SMG Transmission
- Removing And Installing/replacing Switch Unit In Center Console
- Removing And Installing/replacing Switch For Passenger Airbag Deactivation
- Removing And Installing/replacing Indicator For Front Passenger Airbag Deactivat
- Removing And Installing/replacing Switch For Hazard Warning Flashers/central Loc
- Removing And Installing/replacing Switch For Unlocking Rear Lid
- Removing And Installing/replacing Both Shift Paddles For Automatic Transmission2
- Replacing Rocker Switch For Side Window Operation (driver's Side)
- Replacing Rocker Switch For Side Window Operation (passenger Side)
- Removing And Installing/replacing Emergency Call Button
- Replacing Switch Combination For Seat Adjustment
- Removing And Installing/replacing Multifunction Steering Wheel Switch
- Removing And Installing/replacing Engine Hood Contact Switch
- Replacing Switch For Door Mirror (from 04/2006)
- Replacing Switch For Door Mirror (up To 04/2006)
- Replacing Switch For Reversing Light
- Removing And Installing/replacing Driving Dynamics Switch
- Removing And Installing/replacing Clutch Switch Module
- Replacing Brake-light Switch
- Removing Switch For Glovebox Light
- Removing And Installing/replacing Microswitch For Storage Box Lighting2
- Replacing Level Switch For Coolant
- Removing And Installing/replacing Relay/module (in Device Holder On Left)
- Removing And Installing/replacing Relay/module (in Instrument Panel At Bottom Ri
- Replacing Level Switch For Windshield Washer System
- Carrying Out Steering Angle Sensor Adjustment
35 ECUs, Modules11 pages
- Overview Of Control Units, Modules
- Notes On ESD Protection (Electro Static Discharge)23
- Removing And Installing/replacing Module For Folding Door Mirror
- Removing And Installing (replacing) Rain/light Sensor
- Removing And Installing/replacing General Module
- Initializing Rain/light Sensor
- Removing And Installing/replacing Ring Antenna Of Electronic Immobilizer
- Removing And Installing/replacing Control Unit Of Electronic Immobilizer
- Vehicle Programming And Coding
61 Windscreen Wipers10 pages
- Adjusting Left Or Right Windscreen Wiper23
- Overview Of Windscreen Washer System And Headlight Washer System (SRA)
- Checking/adjusting Contact Angle Of Windscreen Wiper Arms On Windscreen2
- Replacing Both Windscreen Wiper Blades
- Removing And Installing/replacing Both Windshield Wiper Arms2
- Removing And Installing/replacing Bracket For Windscreen Wiper System Complete W
67 Headlight Washer System4 pages
- 62 Instruments › 11 Instrument Cluster › Removing And Installing (replacing) Instrument Cluster
63 Lights57 pages
12 Headlights11 pages
- Removing And Installing/replacing Left Headlight
- Removing And Installing/replacing Right Headlight
- Removing And Installing/replacing Left Headlight (xenon Headlight)
- Removing And Installing Right Headlight (xenon Headlight)
- Replacing Control Unit For Left Xenon Headlight
- Replacing Control Unit For Right Xenon Headlight
- Replacing Ignition Unit For Left Xenon Headlight
- Replacing Right Ignition Unit For Right Xenon Headlight
- Removing And Installing/replacing Left Headlight Vertical Aim Adjuster (xenon He2
- Removing And Installing/replacing Right Headlight Vertical Aim Adjuster (xenon H
- 13 Turn Signal Indicator Lights › Removing And Installing/replacing Front Left Or Right Auxiliary Turn Signal Lamp
14 Clearance And Side Marker Lamps2 pages
- 17 Fog Lights, Auxiliary Lights › Removing And Installing (replacing) Left Or Right Front Fog Lamp2
- 25 Brake Lights › Removing And Installing/replacing Auxiliary Brake Light
- 26 Licence Plate Lights › Removing And Installing/replacing Left Or Right Number/license Plate Light
31 Interior Lights7 pages
- Overview Of Interior Lights
- Removing And Installing/replacing Complete Ceiling Light
- Removing And Installing/replacing Footwell Light
- Removing And Installing/replacing Footwell Light (footwell)
- Removing And Installing/replacing Storage Box Light
- Removing And Installing/replacing Luggage Compartment Light
- Removing And Installing/replacing Glovebox Light
99 Light Bulbs24 pages
- Instructions For Handling Light Bulbs (exterior Lights)
- Instructions For Replacing Light Bulbs (interior Lights)
- Replacing Halogen Bulb For Left (or Right) High-beam Headlight2
- Replacing Halogen Bulb For Left (or Right) Headlight2
- Replacing Bulb For Left (or Right) Xenon Headlight2
- Replacing Bulb For Front Left (or Right) Side Lights2
- Replacing Bulb For Front Left (or Right) Side Lights (xenon Headlight)2
- Replacing Halogen Bulb For Left Or Right Front Fog Lamp
- Replacing Bulb For Left (or Right) Front Turn Indicator2
- Replacing Bulb For Auxiliary Turn Signal Light, Front Left Or Right
- Replacing Light Bulb(s) For Left Or Right Rear Light2
- Replacing Bulb For Left Or Right License Plate Light
- Replacing Bulb For Front Ceiling Light
- Replacing Light Bulb For Footwell Light
- Replacing Light Bulb For Luggage Compartment Lighting
- Replacing Bulb For Glovebox Light
- Replacing Bulb For Storage Box Light
64 Heating And Air Conditioning84 pages
- 0 General › Overview Of Heater - A/C System Components
11 Heater With Operation22 pages
- Overview Of Heater - A/C System Components
- Overview Of Heater/air Conditioner Components
- Installing Servodrive
- Removing And Installing/replacing Trims On Control Panel For Heater - A/C System
- Removing And Installing Or Replacing Heater23
- Replacing Heater Core
- Removing And Installing/replacing Heater - A/C Fan2
- Replacing Controller For Heater - A/C Fan
- Removing And Installing (replacing) Control Panel For Heater - A/C System2
- Removing And Installing/replacing Servodrive For Fresh-/recirculated-air Flap
- Removing And Installing/replacing Servodrive For Ventilation Flaps (automatic A
- Removing And Installing/replacing Servodrive For Footwell Flap (automatic A/C)
- Removing And Installing/replacing Servodrive For Central Kinematics (heater - A
- Removing And Installing/replacing Servodrive For Blending Flap
- Removing And Installing/replacing Servodrive For Defrosting Flap (automatic A/C)
- Replacing Evaporator Temperature Sensor
- Replacing Temperature Sensor For Heater
- Removing And Installing/replacing Sensor For Automatic Recirculated Air Control
50 Air Conditioning System17 pages
- Overview Of Heater - A/C System Components
- Air Conditioner Test (R 134a)
- Instructions For Handling Refrigerant R 134a
- Instructions For Handling Refrigerant Oil (for Refrigerant R 134a)2
- Leak Testing With Ultraviolet Additives (UV Additives) (BMW Leak-testing Case)23
- Leak-testing With Leak Tester Device2
- Safety Instructions For Handling Refrigerant R134a
- Safety Instructions For Handling Refrigerant Oil2
- Drawing Off, Evacuating And Filling A/C System (R 134a)2
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
51 AC Housing-evaporator, Switching Elemts14 pages
53 Condenser And Dryer With Lines15 pages
- Overview Of Heater - A/C System Components
- Leak-testing Condenser23
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
- Notes On Replacing Drier Bottle Or Drier Insert
- Replacing Valve Insert For Refrigerant Line2
- Removing And Installing / Replacing Drier Bottle For Air Conditioner2
- Replacing Safety Pressure Switch2
- Removing And Installing Or Replacing Condenser For A/C System2
65 Audio, Navigation And Information System44 pages
13 Speaker And Cover4 pages
20 Aerial-antenna8 pages
- Removing And Installing/replacing Antenna Rod
- Removing And Installing/replacing Antenna Base2
- Removing And Installing/replacing Antenna Amplifier (rod-type Antenna)
- Removing And Installing/replacing Antenna Amplifier (diversity)
- Removing And Installing/replacing Antenna Amplifier (FM)
- Removing And Installing/replacing TV Aerial
- Removing And Installing/replacing Bumper Antenna
50 Video And TV Equipment2 pages
77 Airbag Trigger Device, Diagnosis Unit14 pages
- Overview Of Control Units, Modules
- Notes On Scrapping BMW Vehicles With Gas Generators (central Airbag Control Unit2
- Overview Of Sensors For Airbag System
- Removing And Installing/replacing Airbag Control Unit2
- Removing And Installing/replacing Front Left Sensor2
- Removing And Installing/replacing Front Right Sensor
- Removing And Installing/replacing Control Electronics For Passenger Seat Occupan
- Removing And Installing (replacing) Left B-pillar Sensor
- Removing And Installing (replacing) Left Front Door Sensor2
- Removing And Installing/replacing Right Front Door Sensor
81 On-board Computer2 pages
66 Distance Systems, Cruise Control › 20 Park Distance Control3 pages
67 Electrical Drives17 pages
11 Central Locking Unit - Unlocking Units4 pages
- 13 Mirror Adjustment › Replacing Drive Unit For Electrically Operated Left Or Right Door Mirror
63 Drive Unit, Headlight Wipe-wash Unit2 pages
72 Parts - Accessories (Body)31 pages
12 Airbag Generator-airbag Unit For Pass20 pages
- Repairing Airbag Cables2
- Safety Precautions And General Information
- Safety Regulations For Handling Components With Gas Generators2
- Notes On Scrapping Vehicles With Gas Generators (airbag System)2
- Procedure After Airbag Triggering As Result Of An Accident23
- Unlocking/locking Airbag Plug Connections234
- Removing And Installing/replacing Airbag Module On Passenger Side2
- Removing And Installing/replacing Airbag Module For Driver's Knee Protection2
- Removing And Installing/replacing Airbag Module For Passenger's Knee Protection
- Removing And Installing/replacing Airbag Module On Left Or Right Front Door
84 Communication Systems10 pages
11 Transceiver, Handset-support, Card Reade4 pages
- 31 Hands-free System, Microphone, Speaker › Removing And Installing/replacing Hands-free Microphone On Steering Column
- 50 Antenna › Removing And Installing/replacing Bluetooth Aerial
86 Trailers107 pages
10 Loading Platform71 pages
- Body And Underbody: Checking For Corrosion And Damage
- Raising BMW Multi-trailer23
- Adjusting Brake System23
- Adjusting Spring Force Accumulator
- Disassembly Of Camlock Retaining Cam
- Disassembly Of Base Plate
- Disassembly Of Bracket On Platform Base
- Disassembly Of Front Apron
- Disassembly Of Front Protection Bar
- Disassembly Of Jockey Wheel Or Jockey Wheel Mount
- Disassembly Of Left And Right Aprons
- Disassembly Of Left And Right Lamp Housings
- Disassembly Of Left And Right Wheel Boxes
- Disassembly Of Licence Plate Mounting Plate
- Disassembly Of Loading Ramp Frame/disassembly Of Rail, Left/right
- Disassembly Of Rear Apron
- Disconnecting Plug Connection, Wiring Harness, Front/rear
- Installation Position Of BMW Lettering
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Removing Camlock Retaining Cam On Loading Ramp
- Removing Camlock Screw Cap
- Removing And Installing Or Replacing Left Or Right Coil Spring2
- Removing Bolt On Loading Ramp
- Removing Brake Shoes2345
- Removing Entry Profile Section On Loading Ramp, Left, Right And Center
- Removing Left Or Right Shock Absorber
- Removing Loading Ramp Lock2
- Removing Mounting Bracket Sealing Cap
- Removing Mounting Bracket, Center, Left And Right
- Removing Outer Pull Rod Mount, Left And Right
- Removing Overrunning Equipment/maintaining Or Replacing Guide Bush/installing Ov2345
- Removing Plastic Bush/metal Bush
- Removing Rear Supports And Bracket
- Removing Reflecting Rear Light
- Removing Rest On Loading Ramp, Left, Right And Center
- Removing Shock Absorber From Overrunning Equipment
- Removing Trailing Arm, Removing And Installing Or Replacing Mounting23
- Removing Wheel Bearing2
- Removing Wooden Rest On Loading Ramp, Left, Right And Center
- Repair Work On GFP Components With Gelcoat Surface
- Replacing 12 Volt Socket2
- Replacing Bar
- Replacing Drawbar Members, Left And Right2
- Replacing Gaiter
- Replacing Holder For Chock
- Replacing Lashing Plate And Lashing Eye
- Replacing License Plate Light
- Replacing Position Light
- Replacing Rear Light
- Troubleshooting On Multi-trailer2
21 Hood36 pages
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Adjusting Hood Pretension - Camloc Fastener With Spacers23
- Adjusting Rear Lid To Fit2
- Adjusting Rotary Striker Lock
- Adjusting Side Lid To Fit2
- Attaching/replacing BMW Badge2
- Fitting BMW Logo
- Installing Hood Seal
- Installing Rubber Roof Strip
- Installing Seal For Rear Lid And Side Lid
- Installing Sponge Rubber Seal
- Removing Ball Pivot
- Removing Centering Pin From Mounting Bracket
- Removing Gas Spring
- Removing Gas Spring Retaining Bracket
- Removing Hinge Bracket On Rear Lid
- Removing Lid
- Removing Lock Barrel
- Removing Lock Striker Fixture On Rear Lid
- Removing Plug For Inside Light2
- Removing Roof Railing
- Removing Roof Railing Adapter2
- Removing Rotary Striker Lock2
- Removing Side Lid Hinge
- Replacing Inside Light
- Replacing Inside Light Power Cable2
99 Paintwork2 pages