• Land Rover Defender TD5 Workshop Manual
• Page 2
• WORKSHOP MANUAL SUPPLEMENT
• Page 4
• CONTENTS
• Page 6
• CONTENTS
• INFORMATION
• Page 9
• INTRODUCTION
• GENERAL SPECIFICATION DATA
• ENGINE TUNING DATA
• GENERAL FITTING REMINDERS
• MAINTENANCE
• ENGINE
• TD5 ENGINE
• Page 157
• Page 158
• Page 159
• Page 160
• Page 161
• Page 162
• Page 163
• Page 164
• Page 165
• Page 166
• GENERAL
• CYLINDER BLOCK
• Page 169
• Page 170
• Page 171
• Page 172
• Page 173
• Page 174
• Page 175
• Page 176
• Page 177
• Page 178
• Page 179
• CYLINDER HEAD COMPONENTS
• Page 181
• Page 182
• Page 183
• Page 184
• CAMSHAFT COVER COMPONENTS
• CAMSHAFT TIMING CHAIN COMPONENTS
• Page 187
• CYLINDER BLOCK FLOW
• Page 189
• OIL COOLER / FILTER FLOW (THERMOSTAT OPEN)
• Page 191
• CYLINDER HEAD FLOW
• Page 193
• Page 194
• ENGINE OIL PRESSURE CHECK
• Page 196
• CAMSHAFT
• Page 198
• PULLEY - CRANKSHAFT
• OIL SEAL - CRANKSHAFT - REAR
• BEARING - SPIGOT - CRANKSHAFT
• GASKET - CYLINDER HEAD
• Page 203
• Page 204
• Page 205
• Page 206
• ROCKER SHAFT ASSEMBLY
• Page 208
• GASKET - COVER - CAMSHAFT
• ENGINE AND ANCILLARIES
• Page 211
• Page 212
• Page 213
• Page 214
• MOUNTING - FRONT - LH
• MOUNTING - FRONT - RH
• MOUNTING - GEARBOX - REAR - LH
• MOUNTING - GEARBOX - REAR - RH
• FLYWHEEL
• FILTER - OIL
• STRAINER - OIL PICK-UP
• PUMP - OIL
• Page 223
• GASKET - ENGINE TO SUMP
• Page 225
• SWITCH - OIL PRESSURE
• VALVE - RELIEF - OIL PRESSURE
• COOLER - ENGINE OIL
• CENTRIFUGE ASSEMBLY
• Page 230
• ROTOR - CENTRIFUGE
• OIL SEAL - TIMING COVER
• TIMING CHAIN AND SPROCKETS
• Page 234
• GASKET - INLET MANIFOLD
• GASKET - EXHAUST MANIFOLD
• GASKET - CYLINDER HEAD
• Page 238
• Page 239
• Page 240
• CYLINDER HEAD GASKET SELECTION
• CYLINDER HEAD - OVERHAUL
• Page 243
• Page 244
• Page 245
• Page 246
• Page 247
• Page 248
• Page 249
• Page 250
• Page 251
• Page 252
• Page 253
• GASKET - ENGINE SUMP
• SEAL - CRANKSHAFT - REAR
• STARTER RING GEAR
• PUMP - OIL
• Page 258
• Page 259
• TIMING CHAIN AND SPROCKETS
• Page 261
• Page 262
• Page 263
• BEARINGS - CONNECTING RODS
• Page 265
• Page 266
• Page 267
• Page 268
• Page 269
• CRANKSHAFT
• Page 271
• Page 272
• Page 273
• Page 274
• CONTENTS
• DESCRIPTION AND OPERATION
• REPAIR
• Page 278
• EMISSION CONTROL
• ENGINE MANAGEMENT SYSTEM
• FUEL SYSTEM
• COOLING SYSTEM
• MANIFOLD AND EXHAUST SYSTEM
• CLUTCH
• MANUAL GEARBOX
• TRANSFER GEARBOX
• PROPELLER SHAFTS
• STEERING
• FRONT SUSPENSION
• REAR SUSPENSION
• BRAKES
• CHASSIS AND BODY
• PANEL REPAIRS
• AIR CONDITIONING
• WIPERS AND WASHERS
• ELECTRICAL
• INSTRUMENTS