5 Series E39 540i Touring (M62): 2 Repair Instructions

Also for this vehicle: 5 Series E39 520d (M47) SAL, 5 Series E39 520d (M47) TOUR, 5 Series E39 520i (M52) SAL, 5 Series E39 520i (M52) TOUR, 5 Series E39 520i (M52TU) SAL, 5 Series E39 520i (M52TU) TOUR, 5 Series E39 520i (M54) SAL, 5 Series E39 520i (M54) TOUR, 5 Series E39 523i (M52) SAL, 5 Series E39 523i (M52) TOUR, 5 Series E39 523i (M52TU) SAL, 5 Series E39 523i (M52TU) TOUR, 5 Series E39 525d (M57) SAL, 5 Series E39 525d (M57) TOUR, 5 Series E39 525i (M54) SAL, 5 Series E39 525i (M54) TOUR, 5 Series E39 525td (M51) SAL, 5 Series E39 525tds (M51) SAL, 5 Series E39 525tds (M51) TOUR, 5 Series E39 528i (M52) SAL, 5 Series E39 528i (M52) TOUR, 5 Series E39 528i (M52TU) SAL, 5 Series E39 528i (M52TU) TOUR, 5 Series E39 530d (M57) SAL, 5 Series E39 530d (M57) TOUR, 5 Series E39 530i (M54) SAL, 5 Series E39 530i (M54) TOUR, 5 Series E39 535i (M62) SAL, 5 Series E39 540i (M62) SAL, 5 Series E39 M5 (S62) SAL.

Choose Sections to see everything in a chapter, or a chapter title to start at its first page.

1. 011 Service Information1 Service Information: Sections
2. 022 Repair Instructions2 Repair Instructions: Sections
   • 0 Maintenance And General Data88 pages

     • 1 RA Danger Of Poisoning If Oil Is Ingested_absorbed Through The Skin
     • 2 RA Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
     • 3 RA Safety Instructions For Handling Oil
     • 4 RA BMW Service-inspection (petrol_gasoline Vehicles)2
     • 5 RA Pre-delivery Check2345
     • 6 RA Lifting Vehicle With A Lifting Platform
     • 7 RA Notes On Using Repair Instructions, Technical Data, Tightening Torques
     • 8 RA Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
     • 9 RA Symbols Used And Information In Repair Instructions2
     • 10 RA Checking Water Drain Under Brake Booster For Contamination, Cleaning If Necessar
     • 11 RA Air Cleaner_ Replacing Air Cleaner Element (shorten Replacement Interval Accordi
     • 12 RA Battery_ Check Display (magic Eye); If Necessary, Recharge Battery
     • 13 RA Battery_ Checking Acid Level, Topping Up With Distilled Water If Necessary
     • 14 RA Body And Underbody_ Checking For Corrosion And Damage
     • 15 RA Body And Underbody_ Checking For Corrosion And Damage - Except Cavities
     • 16 RA Brake And Clutch Hydraulic System_ Checking Fluid Level, Topping Up If Necessary
     • 17 RA Brake Lines And Connections_ Visual Inspection For Leaks, Damage And Correct Pos
     • 18 RA Changing Automatic Transmission Fluid
     • 19 RA Changing Brake Fluid
     • 20 RA Changing Coolant
     • 21 RA Changing Differential Oil
     • 22 RA Changing Engine Oil And Oil Filter
     • 23 RA Changing Manual Transmission (gear) Oil
     • 24 RA Checking Clutch Drive Plate For Wear
     • 25 RA Checking Coolant Level In Event Of Topping Up_ Checking Concentration
     • 26 RA Checking Handbrake Lever Travel, Adjusting According To Setting Specifications I
     • 27 RA Checking Horn, Headlight Flashers And Hazard Warning System
     • 28 RA Checking Instrument And Indication Field Lighting, Heater Blower
     • 29 RA Checking Lighting System
     • 30 RA Checking Roadworthiness
     • 31 RA Coolant Hoses_ Visual Inspection For Leaks
     • 32 RA Diagnostic Brief Test
     • 33 RA Exhaust System_ Checking Condition, Mounting And Inspecting For Leaks
     • 34 RA Fault Memory Interrogation
     • 35 RA Front And Rear Brake Linings_ Checking Lining Thickness With Measuring Gauge
     • 36 RA Fuel Lines, Fuel Tank And Fuel Hoses_ Visual Inspection For Routing, Condition A
     • 37 RA Heating_air Conditioning_ Replacing Microfilter_carbon Canister (shorten Replace
     • 38 RA Information_warning Labels23
     • 39 RA Locking Systems_ Checking Status And Function, Oiling Or Greasing If Necessary
     • 40 RA Microencapsulated Screws
     • 41 RA Oil Change In Manual Transmission
     • 42 RA Oil Change In Rear Differential
     • 43 RA Output Shafts_ Checking Gaiters For Leaks
     • 44 RA Parking Brake_ Checking Function, Adjusting_repairing As Prescribed
     • 45 RA Parking Brake_ Checking Lining Thickness
     • 46 RA Power Steering_ride-height Control_ Visual Inspection For Leaks, Checking Fluid
     • 47 RA Raising BMW Multi-trailer23
     • 48 RA Replacing Spark Plugs
     • 49 RA Resetting Service Interval Indicator According To Factory Specifications2
     • 50 RA Seat Belts_ Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
     • 51 RA Steering Components_ Checking For Zero Clearance, Leaks, Damage And Wear2
     • 52 RA Steering Fluid Reservoir_ Checking Fluid Level, Topping Up If Necessary
     • 53 RA Transmission (all Gears)_ Visual Inspection For Leaks
     • 54 RA Tyres_ Checking Inflation Pressure, Correcting If Necessary (incl
     • 55 RA Underbody Incl
     • 56 RA Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid23
     • 57 RA Windscreen Wash_wipe System_ Checking Washer Fluid Reservoir And Spray Nozzle Ad
     • 58 RA Windscreen Washer System And Intensive Cleaning System_ Checking Fluid Level, To
     • 59 RA BMW Engine Oil Service (M60 _ M62 _ M73)2
     • 60 RA Checking_topping Up Oil Level In Rear Differential
     • 61 RA Oil Change In Manual Transmission
     • 62 RA Oil Change In Automatic Transmission (A4S 310R _ 270R)23
     • 63 RA Oil Change In Rear Differential Incl2
     • 64 RA Checking Oil Level In Automatic Transmission And Topping Up If Necessary (A5S 56
     • 65 RA Checking_ Topping Up Oil Level In Automatic Transmission (A5S 300J)
     • 66 RA Checking_topping Up Fluid Level In Automatic Transmission (A5S 440Z)
     • 67 RA Notes On Handling Wiring Harnesses And Cables
     • 68 RA Positioning Of Multitrailer Hood For Maintenance And Repair Work2
   • 11 Engine (M62)336 pages

     • 0 Engine, General19 pages

       • 1 RA Danger Of Poisoning If Oil Is Ingested_absorbed Through The Skin
       • 2 RA Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
       • 3 RA Safety Instructions For Handling Oil
       • 4 RA BMW Engine Oil Service (M60 _ M62 _ M73)2
       • 5 RA Checking Compression Of All Cylinders (M60 _ M62 _ M73 _ S62 _ M54)2
       • 6 RA Checking Absolute Compression Of All Cylinders
       • 7 RA Removing And Installing Engine (M62)23456
       • 8 RA Engine Identification2345
     • 12 Cylinder Head With Cover59 pages

       • 1 RA Removing And Installing_sealing Both Cylinder Head Covers (M62)234
       • 2 RA Removing And Installing _ Sealing Left Cylinder Head Cover (M62)
       • 3 RA Removing And Installing _ Sealing Right Cylinder Head Cover (M62)
       • 4 RA Removing And Installing Left Cylinder Head (M62 VANOS From 9_98)234567
       • 5 RA Removing And Installing Left Cylinder Head (M62 Up To 9_98)234567891011
       • 6 RA Removing And Installing Right Cylinder Head (M62 VANOS From 9_98)23456
       • 7 RA Removing And Installing Right Cylinder Head (M62 Up To 9_98)2345678910
       • 8 RA Removing And Installing Right Cylinder Head (M62 Up To 9_98)2345678910
       • 9 RA Replacing Left Cylinder Head Gasket (M62 _ S62 _ N62)
       • 10 RA Replacing Right Cylinder Head Gasket (M62 _ S62 _ N62)
       • 11 RA Dismantling And Reassembling Cylinder Head (M62)2
       • 12 RA Remachining A Valve Seat (M62, S62)
       • 13 RA Checking A Valve Guide For Wear (M62, S62)
       • 14 RA Reaming A Valve Guide (M62, S62)
       • 15 RA Milling Down Cylinder Head Gasketing Face (M62)
       • 16 RA Checking Cylinder Head For Water Leaks (M62)
     • 13 Oil Sump10 pages

       • 1 RA Removing And Installing_replacing Upper Section Of Oil Pan (M62)23456
       • 2 RA Removing And Installing _ Replacing Lower Oil Pan Section (M60_M62)2
       • 3 RA Removing And Installing_replacing Upper Oil Sump Section (M60 _ M62)2
     • 14 Housing Cover22 pages

       • 1 RA Removing And Installing Timing Case Cover, Top Left (M62 VANOS From 9_98)234
       • 2 RA Removing And Installing Timing Case Cover, Top Left (M62 Up To 9_98)23
       • 3 RA Removing And Installing Timing Case Cover, Top Right (M62 VANOS From 9_98)2345
       • 4 RA Removing And Installing Timing Case Cover, Top Right (M62 Up To 9_98)23
       • 5 RA Removing And Installing Timing Case Cover, Bottom (M62 VANOS From 9_98)2
       • 6 RA Removing And Installing Timing Case Cover, Bottom (M62 Up To 9_98)2
       • 7 RA Replacing Radial Seal Below Timing Case Cover (M62)
       • 8 RA Replacing Crankshaft Radial Seal (M62_S62)2
     • 21 Crankshaft With Bearing11 pages

       • 1 RA Replacing Crankshaft (M62)23
       • 2 RA Replacing Main Crankshaft Bearing Shell (M62)234567
       • 3 RA Replacing Grooved Ball Bearing In Crankshaft (M62 _ S62)
     • 22 Flywheel4 pages

       • 1 RA Removing And Installing_replacing Flywheel (M62 _ S62)2
       • 2 RA Removing And Installing_replacing Flywheel (M62)2
     • 23 Vibration Damper3 pages

       • 1 RA Removing And Installing_replacing Vibration Damper (M62)
       • 2 RA Removing And Installing_replacing Hub For Vibration Damper (M62)2
     • 24 Connecting Rod With Bearing › 1 RA Replacing All Conrod Bearings (M62)2
     • 25 Piston With Rings And Pin8 pages

       • 1 RA Removing And Installing _ Replacing All Pistons (M62)23456
       • 2 RA Replacing Piston Rings On All Pistons (M62)2
     • 28 V-ribbed Belt W.tens.-deflect.elemt3 pages

       • 1 RA Replacing Alternator Drive Belt (M62)2
       • 2 RA Replacing Drive Belt For A_c Compressor (M60 _ M62 _ M73)
     • 31 Camshaft93 pages

       • 1 RA Adjusting Camshaft Timing (M62 VANOS From 9_98)2345678910111213141516
       • 2 RA Adjusting Camshaft Timing (M62 Up To 9_98)234567
       • 3 RA Replacing Left Camshaft (M62 Up To 9_98)234567891011
       • 4 RA Replacing Left Camshafts (M62 VANOS From 9_98)23456
       • 5 RA Replacing Right Camshaft (M62 VANOS From 9_98)23456
       • 6 RA Replacing Right Camshaft (M62 Up To 9_98)234567891011
       • 7 RA Replacing Timing Chain (M62 VANOS From 9_98)2345678910111213141516171819202122
       • 8 RA Replacing Timing Chain (M62 Up To 9_98)23456789101112
       • 9 RA Installing And Removing _ Replacing Piston For Chain Tensioner (M62)2
     • 34 Valves With Springs5 pages

       • 1 RA Removing And Installing _ Replacing All Valves (M62)
       • 2 RA Replacing All Valve Stem Seals (M62, S62)2
       • 3 RA Replacing All Valve Springs (M62)2
     • 36 Variable Camshaft Timing68 pages

       • 1 RA Adjusting Camshaft Timing (M62 VANOS From 9_98)2345678910111213141516
       • 2 RA Removing And Installing_replacing Solenoid Valve Of Camshaft Adjustment Unit, Le23
       • 3 RA Removing And Installing_replacing Solenoid Valve Of Camshaft Adjustment Unit, Ri2
       • 4 RA Removing And Installing_replacing Left Camshaft Adjustment Unit (M62 VANOS From2345678910111213141516171819
       • 5 RA Removing And Installing_replacing Right Camshaft Adjustment Unit (M62 VANOS From23456789101112131415161718
       • 6 RA Removing And Installing_replacing Distributor On Left Camshaft Adjustment Unit (2345
       • 7 RA Removing And Installing_replacing Distributor On Right Camshaft Adjustment Unit2345
     • 40 Oil Supply › 1 RA Checking Engine Oil Pressure2
     • 41 Oil Pump With Filter And Drive › 1 RA Removing And Installing_replacing Oil Pump (M62)234
     • 42 Oil Filter And Lines › 1 RA Completely Removing And Installing, Sealing_replacing Main Flow Oil Filter (M622
     • 51 Water Pump With Drive › 1 RA Removing And Installing_replacing Water Pump (M62 _ S62)
     • 52 Fan › 1 RA Removing And Installing Or Replacing Fan Coupling (M62)
     • 53 Thermostat And Connections3 pages

       • 1 RA Removing And Installing _ Replacing Coolant Thermostat (M62)
       • 2 RA Removing And Installing_replacing Coolant Manifold (M62)2
     • 61 Intake Manifold › 1 RA Removing And Installing Intake Air Manifold (M62)234
     • 62 Exhaust Manifold7 pages

       • 1 RA Removing And Installing_replacing Exhaust Manifold, Left (M62 VANOS From 9_98)2
       • 2 RA Removing And Installing_replacing Exhaust Manifold, Right (M62 VANOS From 9_98)
       • 3 RA Removing And Installing Or Replacing Both Exhaust Manifolds On Left (M62 To 9_9823
       • 4 RA Removing And Installing Or Replacing Both Exhaust Manifolds On Right (M62 To 9_9
     • 71 Exhaust Gas Recirculation › 1 RA Removing And Installing Or Replacing EGR Cooler (N47)2
     • 78 Emission Control, Oxygen Sensor3 pages

       • 1 RA Replacing Oxygen Sensor (M62 _ S62)
       • 2 RA Replacing Lambda Control Sensor, Left (M62)
       • 3 RA Replacing Lambda Control Sensor, Right (M62)
   • 12 Engine Electrical System (M62)88 pages

     • 0 Troubleshooting8 pages

       • 1 RA Contents Of Engine Electrical System General
       • 2 RA Instructions For Disconnecting And Connecting Battery23
       • 3 RA Instructions For Removing And Installing Electronic Control Units
       • 4 RA Instructions For Working On The Ignition System
       • 5 RA Notes On Checking Ignition System
       • 6 RA Notes On Handling Wiring Harnesses And Cables
     • 12 Ignition Wires, Spark Plugs › 1 RA Replacing All Spark Plugs (M60, M62)
     • 13 Ignition Coil15 pages

       • 1 RA Notes On Checking Ignition System
       • 2 RA Checking Secondary Signal For Stationary Ignition Distribution
       • 3 RA Normal Oscillogram (M, S, W Engines Only)2
       • 4 RA Checking Ignition Coils (M60, M62, S62)234
       • 5 RA Checking Ignition Coils (secondary Coil)23
       • 6 RA Replacing Ignition Coil (M60, M62)23
       • 7 RA Replacing A Spark Plug Connector (M60, M62, M54)
     • 14 Electronic Switching Or Contr.units15 pages

       • 1 RA Replacing Impulse Sensor (M62)2
       • 2 RA Replacing Sensor For Cylinder Recognition (camshaft Sensor) (M60, M62)2
       • 3 RA Replacing Control Unit (DME) (M52, M62, M54)2
       • 4 RA Replacing Right Knock Sensors (cylinder Bank 1 To 4) (M60, M62)2
       • 5 RA Replacing Left Knock Sensors (cylinder Bank 5 To 8) (M60, M62)2
       • 6 RA Coding Control Module (DME _ DDE)
       • 7 RA Programming Control Unit (DME _ DDE)
       • 8 RA Replacing Master Relay (M51, M52,M62)2
       • 9 RA Note On Replacing Codable_programmable Control Units
     • 31 Alternator With Drive And Mounting10 pages

       • 1 RA Replacing Alternator Belt Pulley
       • 2 RA Replacing Alternator Belt Pulley (with Overrunning Clutch)
       • 3 RA Checking Alternator And Regulator Switch23
       • 4 RA Removing And Installing_replacing Alternator (M60, M62)2345
     • 32 Regulator6 pages

       • 1 RA Replacing Voltage Regulator23
       • 2 RA Replacing Voltage Regulator (Valeo_Bosch)23
     • 41 Starter With Mounting4 pages

       • 1 RA Removing And Installing_replacing Starter (M60, M62)23
       • 2 RA Replacing Solenoid Switch
     • 42 Starter Lead14 pages

       • 1 RA Removing And Installing Or Replacing Battery Positive Lead (between Starter, Alt23456
       • 2 RA Removing And Installing_replacing Positive Battery Lead (between Alternator And23
       • 3 RA Replacing Safety Battery Terminal (SBK)2345
     • 51 Engine Wiring Loom › 1 RA Replacing Wiring Harness Section For Engine (M60, M62)23456789
     • 61 Oil Pressure-oil Temperature-oil Gauge › 1 RA Removing And Installing_replacing Oil Pressure Switch (M60, M62)
     • 63 Switches And Relays › 1 RA Replacing Master Relay (M51, M52,M62)2
     • 72 Sensor For Control Unit › 1 RA Removing And Installing _ Replacing Pedal Travel Sensor (M62)23
   • 13 Fuel System (M62)55 pages

     • 0 Checking-setting Engine-emission › 1 RA Checking Function Of Digital Engine Electronics (DME)
     • 31 Fuel Pump With Drive And Line11 pages

       • 1 RA Notes On Fuel Pressure Check (reference Pressure_ Environment)2
       • 2 RA Notes On Fuel Pressure Check (reference Pressure_ Intake Manifold Pressure)23
       • 3 RA Checking Delivery Pressure Of Fuel Pump (M62)234
       • 4 RA Removing And Installing_replacing 3_2-way Valve (M62, M73)2
     • 32 Fuel Filter › 1 RA Replacing Fuel Filter (M62)2
     • 41 Speed Governor › 1 RA Replacing Idle Speed Control Valve (M60, M62)23
     • 51 Inj.pump, Regulator, Mixt.regulator › 1 RA Replacing Fuel Pressure Regulator (M62)234
     • 53 Injection Nozzle And Lines4 pages

       • 1 RA Replacing Complete Injection Pipe (M60, M62)
       • 2 RA Replacing, Sealing Fuel Hoses23
     • 54 Throttle And Operation9 pages

       • 1 RA Removing And Installing_sealing Throttle Body (M60, M62)234
       • 2 RA Removing And Installing Or Replacing Throttle Body (ASC-T) (M60, M62)2
       • 3 RA Replacing Inlet Hose (between Mass Air Flow Sensor And Throttle Body)(M62)
       • 4 RA Additional Work With ASC-T (removing And Installing Connections On ASC-T Throttl
       • 5 RA Additional Work With ASC-T (removing And Installing Throttle Body ASC-T On Throt
     • 62 Sensor For Control Unit5 pages

       • 1 RA Replacing Temperature Sensor For Intake Air (M60, M62)2
       • 2 RA Replacing Coolant-temperature Sensor (M62)2
       • 3 RA Removing And Installing_replacing Mass Air Flow Sensor (M60, M62, M73)
     • 63 Throttle Potentiometer, Fuel Pump Relay5 pages

       • 1 RA Replacing Throttle Valve Potentiometer (M60, M62)2
       • 2 RA Replacing Throttle Valve Potentiometer (ASC-T) (M60, M62)2
       • 3 RA Replacing Fuel Pump Relay
     • 64 Start Valves7 pages

       • 1 RA Replacing All Injector Valves (M60, M62)23
       • 2 RA Checking Injector Valves For Leaks And Cleaning234
     • 71 Intake Silencer › 1 RA Removing And Installing Suction-filter Housing (M60, M62)2
     • 72 Air Cleaner › 1 RA Replacing Air Filter Insert (M60, M62)
     • 90 Carbon Canister Ventilation › 1 RA Replacing Tank Vent Valve (M62)
   • 16 Fuel Supply System (M62)42 pages

     • 0 Fuel Pick-up, Cleaning System18 pages

       • 1 RA Fuel Supply System E38 _ E39 (spark-ignition Engines)2345678
       • 2 RA General Function Description For Fuel Supply Systems
       • 3 RA Draining And Filling Fuel Tank2
       • 4 RA Checking Fuel Tank And Tank Ventilation System For Leak-tightness2
       • 5 RA Checking Fuel Tank And Tank Venting System For Leaks With Tank Leakage Diagnosis2
       • 6 RA Conducting Leak Test On Fuel Tank And Tank Ventilation System
       • 7 RA Checking Filler Cap Pressure Relief Valve2
     • 11 Fuel Tank With Mounting9 pages

       • 1 RA Removing And Installing Fuel Tank234
       • 2 RA Removing And Installing Or Replacing Fuel Filler Pipe
       • 3 RA Removing And Installing _ Replacing Expansion Tank For Tank Ventilation2
       • 4 RA Checking Filler Cap Pressure Relief Valve2
     • 12 Fuel Transfer, Sensor For Gauge10 pages

       • 1 RA Removing And Installing_replacing The Sensor For The Fuel Level Gauge (right)23
       • 2 RA Removing And Installing_replacing The Sensor For The Fuel Level Gauge (left)23
       • 3 RA Removing And Installing _ Replacing Activated-carbon Filter
       • 4 RA Removing And Installing_replacing Activated Carbon Filter With LDP (leak Diagnos
       • 5 RA Removing And Installing_replacing Carbon Canister (DM-TL)
       • 6 RA Removing And Installing_replacing Tank Leakage Diagnosis Module (DM-TL)
     • 13 Fuel Ventilation3 pages

       • 1 RA Removing And Installing_replacing Activated Carbon Filter With LDP (leak Diagnos
       • 2 RA Removing And Installing_replacing Carbon Canister (DM-TL)
       • 3 RA Removing And Installing_replacing Tank Leakage Diagnosis Module (DM-TL)
     • 14 Fuel Pump2 pages

       • 1 RA Removing And Installing_replacing Fuel Pump
       • 2 RA Replacing Sucking Jet Pump
   • 17 Cooling System (M62)40 pages

     • 0 Coolant, Checking Cooling System12 pages

       • 1 RA Instructions For Working On Cooling System23
       • 2 RA Draining And Topping Up Coolant234
       • 3 RA Checking Cooling System For Water Leaks2
       • 4 RA Checking For Leaks Between Cooling System And Combustion Chamber
       • 5 RA Bleeding Cooling System And Checking For Water Leaks2
     • 10 Radiator, Expansion Tank, Pipes › 1 RA Checking Cooling System For Water Leaks2
     • 11 Engine Radiator With Attachment14 pages

       • 1 RA Removing And Installing Radiator (M62)234
       • 2 RA Replacing Fan Cowl (M52, M62)2
       • 3 RA Removing And Installing Or Replacing Coolant Expansion Tank234
       • 4 RA Flushing Radiator
       • 5 RA Removing And Installing Cassette (condenser For Air Conditioner)23
     • 21 Oil Cooler › 1 RA Flushing Oil Cooler With Lines (automatic Transmission)2345
     • 22 Oil Cooler Lines › 1 RA Flushing Oil Cooler With Lines (automatic Transmission)2345
     • 40 Auxiliary Electrical Fan › 1 RA Removing And Installing_replacing Complete Supplementary Fan (with Fan Cowl)2
   • 18 Exhaust System (M62)8 pages

     • 0 Exhaust System, Complete4 pages

       • 1 RA Removing And Installing Complete Exhaust System (M62)23
       • 2 RA Replacing All Exhaust Suspension Elements (M62)
     • 12 Mufflers, Petrol › 1 RA Replacing Center Muffler23
     • 21 Exhaust Mounting Parts › 1 RA Replacing All Exhaust Suspension Elements (M62)
   • 21 Clutch29 pages

     • 0 Maintenance And Inspections5 pages

       • 1 RA Breaking In SAC Clutch
       • 2 RA Bleeding Clutch Hydraulic System
       • 3 RA Bleeding Clutch Hydraulic System23
     • 21 Clutch With Driving Disc › 1 T2 Only, 6,234567891011121314
     • 51 Clutch Release Controller W. Lever › 1 RA Removing And Installing Or Replacing Clutch Release Bearing_lever2
     • 52 Clutch Operation (hydraulic)5 pages

       • 1 RA Removing And Installing _ Replacing Clutch Master Cylinder23
       • 2 RA Removing And Installing_replacing Clutch Slave Cylinder2
     • 90 Troubleshooting › 1 RA Troubleshooting The Clutch23
   • 23 Manual Transmission (MECH)96 pages

     • 0 Complete Transmission29 pages

       • 1 RA Danger Of Poisoning If Oil Is Ingested_absorbed Through The Skin
       • 2 RA Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
       • 3 RA Safety Instructions For Handling Oil
       • 4 RA Oil Change In Manual Transmission
       • 5 RA Transmission Designations23
       • 6 RA Universal Transmission Bracket
       • 7 RA Universal Transmission Retaining Bridge
       • 8 RA Gear Train Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 9 RA Gear Train Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 10 RA Gear Train Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 11 RA Gear Train Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 12 RA Gear Train Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 13 RA Gearshift Component Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 14 RA Gearshift Component Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 15 RA Housing Arrangement, Front_rear Section (S5D 260Z _ 310Z _ 320Z)
       • 16 RA Transmission Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 17 RA Transmission Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 18 RA Transmission Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 19 RA Transmission Arrangement, Front Section (S5D 260Z _ 310Z _ 320Z)
       • 20 RA Transmission Arrangement, Rear Section (S5D 260Z _ 310Z _ 320Z)
       • 21 RA Removing And Installing Transmission (S6S 420G)234567
     • 11 Housing With Cover4 pages

       • 1 RA Replacing Guide Tube For Clutch Release Mechanism (S6S 420G)
       • 2 C- And F-transmissions)23
     • 12 Bearing In Housing, Sealing Ring13 pages

       • 1 RA Replacing Radial Seal For Output Flange (S6S 420G)2345
       • 2 RA Replacing Radial Seal On Selector Shaft (S6S 420G)23
       • 3 RA Replacing Radial Sealing Ring For Input Shaft (S5D 260Z_ 310Z)2
       • 4 RA Replacing Radial Seal On Input Shaft (S6S 420G)23
     • 21 Transmission Shafts31 pages

       • 1 RA Gear Train Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 2 RA Gear Train Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 3 RA Gear Train Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 4 RA Gear Train Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 5 RA Gear Train Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 6 RA Replacing Output Flange For Transmission (S5D 310Z _ S5D 320Z)
       • 7 RA Replacing Transmission Output Flange (S6S 420G)2
       • 8 RA Removing And Installing Complete Drive And Output Shafts (S5D 260Z _ 310Z _ 320Z23456789101112131415161718
       • 9 RA Replacing Bearings On All Transmission Shafts (S5D 260Z _ 310Z _ 320Z)2345
     • 23 Synchromesh › 1 RA Disassembling And Assembling All Synchronizing Mechanisms (S5D 260Z _ 310Z _ 32023456789101112
     • 30 Gearshift5 pages

       • 1 RA Gearshift Component Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 2 RA Gearshift Component Arrangement (S5D 260Z _ 310Z _ 320Z)
       • 3 C- And F-transmissions)23
     • 31 Inner Gearshift Components › 1 RA Replacing Arrester Balls On Shift Rods (S6S 420G)2
   • 24 Automatic Transmission (AUT)79 pages

     • 0 Transmission Assembly35 pages

       • 1 RA Danger Of Poisoning If Oil Is Ingested_absorbed Through The Skin
       • 2 RA Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
       • 3 RA Safety Instructions For Handling Oil
       • 4 RA Oil Change In Automatic Transmission (A4S 310R _ 270R)23
       • 5 RA Checking_topping Up Fluid Level In Automatic Transmission (A5S 440Z)
       • 6 RA Transmission Designations23
       • 7 RA Universal Transmission Bracket
       • 8 RA Universal Transmission Retaining Bridge
       • 9 RA Removing And Installing Sealing Cap On Working Piston (A4S 310R)234
       • 10 RA Adjust Shift Lever
       • 11 RA Adjusting Shift Lever (A5S 310Z_ A5S 440Z_ A5S 560Z)
       • 12 RA Removing And Installing Automatic Transmission (A5S 440Z)2345678
       • 13 RA Removing And Installing Automatic Transmission (A5S 560Z)2345678
       • 14 RA Installing Replacement Transmission (A5S 310Z, A5S 560Z, A5S 440Z)
     • 11 Transmission Case, Oil Sump6 pages

       • 1 RA Removing And Installing_sealing Or Replacing Transmission Sump (A5S 440Z)2
       • 2 RA Removing And Installing Transmission Extension (A5S 440Z)234
     • 12 Torque Converter Bearing, Seal11 pages

       • 1 RA Replacing Radial Seal For Output Flange (A5S 440Z)2
       • 2 RA Replacing Radial Seal For Manual Shift Valve Shaft (A5S 440Z)23
       • 3 RA Replacing Radial Seal On Manual Shift Valve Shaft (A5S 560Z)234
       • 4 RA Replacing Radial Seal For Torque Converter (A5S 440Z)2
     • 13 Extension Housing, Bearings, Seal › 1 RA Replacing Radial Seal For Output Flange (A5S 440Z)2
     • 15 Electrical Attachments › 1 RA Removing And Installing_replacing Position Switch (A5S 440Z)23
     • 30 Hydr-el Control Components-elements › 1 RA Removing And Installing_replacing Shift Unit (A5S 440Z)234
     • 34 Shift Valves, Parking Lock8 pages

       • 1 RA Replacing Solenoid Valves And_or Pressure Regulators (A5S 440Z)2
       • 2 RA Replacing Pulse Generator (A5S 440Z)2
       • 3 RA Removing And Installing_replacing Parking Lock (A5S 440Z)23
       • 4 RA Programming_replacing Control Unit
     • 35 Wiring Harness, Shift Elements And Senso6 pages

       • 1 RA Replacing Pulse Generator (A5S 440Z)2
       • 2 RA Replacing Wiring Harness In Automatic Transmission (A5S 440Z)23
       • 3 RA Programming_replacing Control Unit
     • 40 Torque Converter2 pages

       • 1 RA Removing And Installing Or Replacing Torque Converter
       • 2 RA Removing And Installing Or Replacing Torque Converter (A5S 440Z)
     • 61 Electronic Control Unit2 pages

       • 1 RA Programming_replacing Control Unit
       • 2 RA Note On Replacing Codable_programmable Control Units
   • 25 Gear Shift Mechanism (AUT) › 16 Centre Shift, Automatic Transmission19 pages

     • 1 RA Checking_adjusting Interlock_Shiftlock Function2
     • 2 RA Removing And Installing_replacing Shift Tower2345
     • 3 RA Removing And Installing_replacing Shift Tower (Steptronic)2
     • 4 RA Removing And Installing_replacing Shift Tower (Steptronic)23
     • 5 RA Replacing Handle For Selector Lever
     • 6 RA Removing And Installing_replacing Shiftlock Solenoid (Steptronic)234
     • 7 RA Replacing Cable For Gear Selector Lever
     • 8 RA Replacing Cable For Gear Selector Lever (Steptronic)
   • 25 Gear Shift Mechanism (MECH) › 11 Centre Shift, Manual Transmission14 pages

     • 1 RA Removing And Installing Shift Lever234
     • 2 RA Replacing Complete Shift Lever
     • 3 RA Replacing Bearing Shell For Shift Lever
     • 4 RA Replacing Knob For Shift Lever
     • 5 RA Replacing Shift Rod Joint2
     • 6 RA Replacing Shift Arm For Shift-lever Mount23
     • 7 RA Replacing Bearing Bushes For Shift Arm
     • 8 RA Replacing Shift Arm Support Bearing
   • 26 Propeller Shaft10 pages

     • 11 Propeller Shaft Assembly8 pages

       • 1 RA Removing And Installing Complete Propeller Shaft23
       • 2 RA Replacing Joint Disk For Propeller Shaft
       • 3 RA Removing And Installing Or Replacing Center Mount Of Propeller Shaft2
       • 4 RA Replacing Constant-velocity Joint For Propeller Shaft2
     • 12 Centre Console Assembly › 1 RA Replacing Complete Propeller Shaft Centre Bearing (constant-velocity Joint)2
   • 27 Transfer Box › 0 Transfer Case, General3 pages

     • 1 RA Danger Of Poisoning If Oil Is Ingested_absorbed Through The Skin
     • 2 RA Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
     • 3 RA Safety Instructions For Handling Oil
   • 31 Front Axle54 pages

     • 0 General13 pages

       • 1 RA Danger Of Poisoning If Oil Is Ingested_absorbed Through The Skin
       • 2 RA Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
       • 3 RA Safety Instructions For Handling Oil
       • 4 RA Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
       • 5 RA Arrangement, Front Axle (high)
       • 6 RA Components On Front Axle (high)
       • 7 RA Information On Replacing Shock Absorbers
       • 8 RA Instructions (chassis Components Made Of Aluminium)
       • 9 RA Instructions (damage To Suspension)2
       • 10 RA Notes
       • 11 RA Arrangement Of Spring Strut Shock Absorber (high)
     • 10 Front Axle Suspension › 1 RA Removing And Installing Complete Front (with Spring Strut Shock Absorber) (high)23
     • 11 Front Sub-frame › 1 RA Replacing Front Axle Support (high)23
     • 12 Struts W.rubber Mounts5 pages

       • 1 RA Replacing Left Or Right Control Arm (high)2
       • 2 RA Removing And Installing Or Replacing Both Traction Struts2
       • 3 RA Replacing Rubber Mounts On Both Traction Struts
     • 21 Wheel Bearings And Stub Axle4 pages

       • 1 RA Replacing Left Or Right Swivel Bearing (high)2
       • 2 RA Replacing Front Wheel Bearing (wheel Hub) (high)2
     • 31 Spring Strut15 pages

       • 1 RA Information On Replacing Shock Absorbers
       • 2 RA Arrangement Of Spring Strut Shock Absorber (high)
       • 3 RA Instructions On Handling The BMW Spring Tensioner2345
       • 4 RA Replacing Front Left Or Right Spring Strut Shock Absorber (high)2345678
     • 33 Spring With Suspension3 pages

       • 1 RA Replacing Front Left Or Right Thrust Bearings On Spring Strut Shock Absorbers
       • 2 RA Measuring Ride-level Height Of Vehicle
       • 3 RA Removing And Installing_replacing Coil Spring For Front Left Or Right Spring Str
     • 35 Stabiliser Bar5 pages

       • 1 RA Removing And Installing_replacing Front Stabilizer (high)234
       • 2 RA Removing And Installing_replacing Push Rod (stabilizer Link) For Left Or Right S
     • 90 Troubleshooting3 pages

       • 1 RA Troubleshooting On Front Axle2
       • 2 RA Troubleshooting On Shock Absorber
   • 32 Steering And Wheel Alignment112 pages

     • 0 Electronic Chassis Alignment27 pages

       • 1 RA Danger Of Poisoning If Oil Is Ingested_absorbed Through The Skin
       • 2 RA Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
       • 3 RA Safety Instructions For Handling Oil
       • 4 RA General Chassis And Suspension Definitions
       • 5 RA General Information And Definitions2
       • 6 RA Identification Of Suspension Without Label
       • 7 RA Identification On Volume Production Suspension, Sports Suspension Etc2
       • 8 RA Information On Replacing Steering Gear After Accident Damage2
       • 9 RA Moving Vehicle Into Design Position
       • 10 RA Moving Vehicle Into Normal Position
       • 11 RA Notes
       • 12 RA Notes
       • 13 RA Performing Rim Runout Compensation
       • 14 RA Test Conditions For Chassis_wheel Alignment Check
       • 15 RA Troubleshooting After Wheel_chassis Alignment Check On Front Axle_rear Axle23
       • 16 RA Standard Chassis _ Wheel Alignment With DIN Load23
       • 17 RA Adjusting Front Axle (with KDS) (high)
       • 18 RA Adjusting Rear Axle (with KDS)2
       • 19 RA Carrying Out Steering Angle Sensor Adjustment
     • 11 Mechanical Steering Gear › 1 RA Information On Replacing Steering Gear After Accident Damage2
     • 13 Steering Gear With Servo Unit11 pages

       • 1 RA Information On Replacing Steering Gear After Accident Damage2
       • 2 RA Design And Function Of Recirculating Ball Power Steering Unit23
       • 3 RA Bleeding Power Steering Unit2
       • 4 RA Removing And Installing Power Steering (high)23
       • 5 RA Replacing Power Steering (high)
     • 21 Steering Arms, Tie Rods, Steer. Damper10 pages

       • 1 RA Arrangement Of Track Rod (high)
       • 2 RA Removing And Installing Idler Arm
       • 3 RA Replacing Idler Arm Bushing For Idler Arm
       • 4 RA Replacing Left Or Right Track Rod (high)
       • 5 RA Replacing Center Tie Rod
       • 6 RA Removing And Installing Pitman Arm
       • 7 RA Adjusting Pitman Arm2
       • 8 RA Instructions For Removing And Installing Ear Clips2
     • 31 Steering Column18 pages

       • 1 RA Replacing Upper Section Of Steering Column Trim2
       • 2 RA Removing And Installing _ Replacing Lower Section Of Steering Column Trim
       • 3 RA Removing And Installing Or Replacing (lower) Steering Spindle
       • 4 RA Removing And Installing Or Replacing Steering Angle Sensor
       • 5 RA Removing And Installing Complete Steering Column23
       • 6 RA Replacing Upper Steering Spindle Bearing2
       • 7 RA Replacing Lower Steering Spindle Bearing
       • 8 RA Replacing Adjusting Lever For Steering Column2
       • 9 RA Dismantling And Assembling Complete Steering Column2345
     • 32 Steering Lock4 pages

       • 1 RA Replacing Complete Steering Lock2
       • 2 RA Removing And Installing Or Replacing Steering-lock Cylinder
       • 3 RA Removing And Installing_replacing Interlock Cable
     • 33 Steering Wheel5 pages

       • 1 RA Replacing Lower Cover For Sport Steering Wheel
       • 2 RA Removing And Installing Steering Wheel23
       • 3 RA Removing And Installing_replacing Steering Wheel
     • 34 Steering Wheel For Airbag16 pages

       • 1 RA Notes On Scrapping BMW Vehicles With Gas Generators (airbag System)234
       • 2 RA Removing And Installing Or Replacing Airbag Unit
       • 3 RA Removing And Installing_replacing Airbag Unit (plugged Airbag Unit)23
       • 4 RA Replacing Contact Ring (airbag)
       • 5 RA Safety Regulations For Handling Airbag System Components2
       • 6 RA Safety Regulations For Handling Components With Gas Generators2
       • 7 RA Procedure After Airbag Triggering As Result Of An Accident23
     • 41 Pump And Oil Supply16 pages

       • 1 RA Bleeding Power Steering Unit2
       • 2 RA Arrangement Of Power Steering Unit Components And Lines (high)
       • 3 RA Instructions For Removing And Installing Ear Clips2
       • 4 RA Instructions For Using Special Tool 32 4 0002
       • 5 RA Notes On Hydraulic Line With Quick-connect Coupling2
       • 6 RA Servotronic Troubleshooting
       • 7 RA Checking Function Of Power Steering Vane Pump (high)2
       • 8 RA Removing And Installing Vane Pump For Power Steering (535i - 540i)2
       • 9 RA Removing And Installing_replacing Belt Pulley On Vane Pump For Power Steering
       • 10 RA Removing And Installing Or Replacing Oil Cooler_cooling Coil For Power Steering
     • 90 Troubleshooting › 1 RA Troubleshooting After Wheel_chassis Alignment Check On Front Axle_rear Axle23
   • 33 Rear Axle85 pages

     • 0 General18 pages

       • 1 RA Danger Of Poisoning If Oil Is Ingested_absorbed Through The Skin
       • 2 RA Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
       • 3 RA Safety Instructions For Handling Oil
       • 4 RA Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
       • 5 RA Notes
       • 6 RA Information On Replacing Shock Absorbers
       • 7 RA Instructions (chassis Components Made Of Aluminium)
       • 8 RA Layout Of Rear Axle (touring)
       • 9 RA Notes
       • 10 RA Rear Axle Components
       • 11 RA Rear Differential_ Assignment To Model Series
       • 12 RA Installation Solution For Straight Shank_hexagon Rivet Nut23
       • 13 RA Repair Solution For Straight Shank_hexagon Rivet Nut23
     • 10 Final Drive7 pages

       • 1 RA Checking_topping Up Oil Level In Rear Differential
       • 2 RA Oil Change In Rear Differential Incl2
       • 3 RA Rear Differential_ Assignment To Model Series
       • 4 RA Removing And Installing Or Replacing Final Drive (HIGH)23
     • 11 Final Drive With Cover10 pages

       • 1 RA Rear Differential_ Assignment To Model Series
       • 2 RA Replacing Shaft Seal For Input Flange On Final Drive234
       • 3 RA Replacing Drive Flange On Left Or Right Of Final Drive2
       • 4 RA Replacing Shaft Seal For Drive Flange Left Or Right2
       • 5 RA Replacing Rear Cover Gasket On Final Drive
     • 17 Final Drive Mounting › 1 RA Replacing All Rubber Mounts For Final Drive Mount2
     • 21 Output Shafts7 pages

       • 1 RA Pressing Output Shaft Out Of Drive Flange And Drawing In (output Shaft Removed F23
       • 2 RA Ribbed Teeth
       • 3 RA Removing And Installing_replacing Both Output Shafts (Touring)
       • 4 RA Replacing Both Gaiters On Left And Right Of Output Shaft2
     • 31 Rear Sub-frame › 1 RA Removing And Installing Entire Rear Axle Carrier (touring)2
     • 32 Control Arms And Struts17 pages

       • 1 RA Replacing Left Or Right Push Rod_integral Link
       • 2 RA Removing And Installing Or Replacing Left Or Right Swinging Arm (touring)23
       • 3 RA Replacing One Control Arm At Top (touring)2
       • 4 RA Replacing One Traction Strut
       • 5 RA Replacing A Ball Joint In Lower Steering Knuckle_wheel Carrier2
       • 6 RA Removing And Installing A Steering Knuckle_wheel Carrier (touring)23
       • 7 RA Removing And Installing One Steering Knuckle_wheel Carrier23
       • 8 RA Replacing Ball Joint In Lower Steering Knuckle _ Wheel Carrier2
     • 33 Axle Mounting › 1 RA Replacing Two Rubber Mounts For Rear Axle Carrier (touring)23
     • 41 Wheel Bearings3 pages

       • 1 RA Replacing Drive Flange On Left _ Right Rear Axle Shaft
       • 2 RA Replacing Left Or Right Wheel Bearing On Rear Axle Shaft2
     • 52 Shock Absorber7 pages

       • 1 RA Information On Replacing Shock Absorbers
       • 2 RA Layout Of Shock Absorbers (touring)
       • 3 RA Removing And Installing _ Replacing Rear Left Or Right Shock Absorber (Touring)2
       • 4 RA Replacing Support Bearing For Rear Left Or Right Shock Absorber (touring)
       • 5 RA Troubleshooting On Rear Axle (rear Axle Suspension, Wheel Bearings)
       • 6 RA Troubleshooting Shock Absorber
     • 53 Springs With Suspension4 pages

       • 1 RA Leaving Rear Coil Spring On Vehicle In Tensioned State2
       • 2 RA Measuring Ride-level Height Of Vehicle
       • 3 RA Removing And Installing _ Replacing Rear Left Or Right Coil Spring (touring)
     • 55 Stabiliser Bar2 pages

       • 1 RA Removing And Installing _ Replacing Rear Stabilizer
       • 2 RA Replacing Stabilizer Links For Stabilizer (touring)
     • 90 Troubleshooting3 pages

       • 1 RA Notes
       • 2 RA Troubleshooting On Rear Axle (rear Axle Suspension, Wheel Bearings)
       • 3 RA Troubleshooting Shock Absorber
   • 34 Brakes84 pages

     • 0 Brake Testing And Bleeding13 pages

       • 1 RA General Data23
       • 2 RA Checking Brakes On Test Stand
       • 3 RA Checking Thickness Of Brake Lining
       • 4 RA Parking Brake Function Check
       • 5 RA Checking Brake Booster (low-pressure Test)
       • 6 RA Bleeding Brake System With ABS_ASC-T2
       • 7 RA Bleeding Brake System With DSC32
       • 8 RA Checking Parking Brake Setting (for Inspection)
       • 9 RA Checking Service Brake_ High- And Low-pressure Tests
     • 11 Front Brakes13 pages

       • 1 RA Configuration Of Floating Caliper (front)
       • 2 RA Removing And Installing_replacing Brake Linings Of Both Front Disk Brakes234
       • 3 RA Removing And Installing_replacing Both Front Brake Disks2
       • 4 RA Removing And Installing_replacing Left Or Right Front Brake Caliper2
       • 5 RA Overhauling Left Or Right Front-brake Caliper (brake Caliper Removed)23
       • 6 RA Fine-grinding Both Sides Of Both Front Brake Disks (brake Disks Removed)
     • 21 Rear Brakes12 pages

       • 1 RA Layout Of Floating Caliper (rear)
       • 2 RA Removing And Installing Or Replacing Brake Linings On Both Rear Disk Brakes234
       • 3 RA Removing And Installing Or Replacing Both Rear Brake Disks
       • 4 RA Removing And Installing Or Replacing Left Or Right Rear Brake Caliper2
       • 5 RA Overhauling Left Or Right Rear Brake Caliper (brake Caliper Removed)23
       • 6 RA Fine-grinding Both Sides Of Both Rear Brake Disks (brake Disks Removed)
     • 31 Master Brake Cylinder2 pages

       • 1 RA Removing And Installing_replacing Expansion Tank For Hydraulic Brake Actuation
       • 2 RA Removing And Installing _ Replacing The Master Brake Cylinder
     • 32 Brake Lines4 pages

       • 1 RA Replacing All Brake Pipes
       • 2 RA Replacing Front Left Or Right Brake Hoses2
       • 3 RA Replacing Both Rear Brake Hoses
     • 33 Brake Booster7 pages

       • 1 RA Checking Brake Booster (low-pressure Test)
       • 2 RA Removing And Installing _ Replacing Non-return Valve For Brake Booster
       • 3 RA Replacing Vacuum Hose For Brake Booster
       • 4 RA Removing And Installing _ Replacing The Brake Unit234
     • 41 Parking Brake12 pages

       • 1 RA Adjusting Handbrake234
       • 2 RA Removing And Installing_replacing Handbrake Lever23
       • 3 RA Removing And Installing _ Replacing Both Handbrake Bowden Cables2
       • 4 RA Removing And Installing Or Replacing All Handbrake Pads2
       • 5 RA Removing And Installing_replacing Expander Lock For Handbrake Shoes
     • 50 Slip Control Systems (ABS, ASC) › 1 RA Removing And Installing_replacing Transversal-acceleration Sensor DSC3 Up To 09
     • 51 Mechanical-hydraulic Components7 pages

       • 1 RA Removing And Installing_replacing Hydraulic Unit ABS_ASC-T, DSC3 From 09_982
       • 2 RA Removing And Installing_replacing Hydraulic Unit ABS_ASC-T, DSC3 Up To 09_982
       • 3 RA Removing And Installing_replacing Pre-boost Pump DSC3 M622
       • 4 RA Removing And Installing_replacing Pressure Sensor For DSC
     • 52 Electronic Components9 pages

       • 1 RA Replacing ABS_ASC-T_DSC Control Module From 09_982
       • 2 RA Replacing ABS_ASC-T_DSC Control Module Up To 09_982
       • 3 RA Removing And Installing _ Replacing Front ABS Impulse Sensor
       • 4 RA Removing And Installing_replacing Rear ABS Pulse Generator (Touring)
       • 5 RA Removing And Installing_replacing Transversal-acceleration Sensor DSC3 Up To 09
       • 6 RA Removing And Installing_replacing Rotation Rate Sensor DSC3 From 09_98
       • 7 RA Removing And Installing_replacing Rotation Rate Sensor DSC3 Up To 09_98
     • 90 Troubleshooting › 1 RA Troubleshooting The Brake System234
   • 35 Pedals19 pages

     • 0 General › 1 RA Layout Of Brake And Clutch Pedals
     • 11 Pedal Mounting Block › 1 RA Removing And Installing Mounting Block For Pedals
     • 21 Brake Pedal With Linkage › 1 RA Removing And Installing Or Replacing Brake Pedal
     • 31 Clutch Pedal With Linkage4 pages

       • 1 RA Removing And Installing _ Replacing Clutch Pedal
       • 2 RA Removing And Installing_replacing Clutch Pedal (RHD)23
     • 40 Accelerator Pedal Actuation2 pages

       • 1 RA Removing And Installing_replacing Accelerator Pedal Module
       • 2 RA Replacing Adapter Plate
     • 41 Kick-down10 pages

       • 1 RA Removing And Installing_replacing Accelerator Pedal Module
       • 2 RA Replacing Adapter Plate
       • 3 RA Adjusting Bowden Cable For Throttle Valve Actuation2
       • 4 RA Removing And Installing Or Replacing Foot Pedal2
       • 5 RA Removing And Installing Or Replacing Accelerator Pedal
       • 6 RA Replacing Bowden Cable For Throttle Valve Actuation2
       • 7 RA Replacing Kick-down Switch
   • 36 Wheels With Tyres40 pages

     • 10 Wheels12 pages

       • 1 RA Checking Front And Rear Wheel For Face And Radial Runout2
       • 2 RA Removing Or Installing Front Or Rear Wheel23
       • 3 RA Stationary Wheel Balancing23
       • 4 RA Checking One Road Wheel On Balancing Machine For Face And Radial Runout (wheel R2
       • 5 RA Checking Rim For Face And Radial Runout2
     • 11 Disc Wheels (rims)8 pages

       • 1 RA General Information, Series Light Alloy Disk Wheel E 39
       • 2 RA RDC Resetting
       • 3 RA Removing And Installing_replacing RDC Control Module
       • 4 RA Removing And Installing_replacing Front Receiving Antenna For RDC
       • 5 RA Removing And Installing_replacing Rear Receiving Antenna For RDC
       • 6 RA Removing And Installing _ Replacing RDC Wheel Electronics23
     • 12 Tyres19 pages

       • 1 RA Changing A Tyre (on Front, Rear Or Spare Wheel)2345
       • 2 RA Replacing A Tire (removing And Installing Support Ring)234567891011121314
     • 13 Mounting › 1 RA Subsequent Installation Of Wheel-bolt Lock
   • 37 Integrated Suspension Systems36 pages

     • 0 General5 pages

       • 1 RA Danger Of Poisoning If Oil Is Ingested_absorbed Through The Skin
       • 2 RA Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
       • 3 RA Safety Instructions For Handling Oil
       • 4 RA Notes On Air Spring System
       • 5 RA Carrying Out Ride-height-calibration
     • 12 Rear Control And Suspension Elements10 pages

       • 1 RA Checking Function Of Level Control System
       • 2 RA Carrying Out Ride-height-calibration
       • 3 RA Removing And Installing_replacing Left Or Right Air Spring (touring)23
       • 4 RA Removing And Installing _ Replacing Left Or Right Air Reservoir (touring)2
       • 5 RA Removing And Installing_replacing Pipe (air Line) For Air Spring To Air Reservoi23
     • 13 Connecting Lines12 pages

       • 1 RA Removing And Installing_replacing Left Or Right Air Spring (touring)23
       • 2 RA Removing And Installing _ Replacing Left Or Right Air Reservoir (touring)2
       • 3 RA Removing And Installing_replacing Pipe (air Line) For Air Spring To Air Reservoi23
       • 4 RA Assembly Instructions For A New Tube (air Line) And New Screw Connection
       • 5 RA Routing Of Pipes (air Lines) (touring)2
       • 6 RA Removing And Installing _ Replacing Pipe (air Line) From Distributor Block To Le
     • 14 Electrical Components3 pages

       • 1 RA Replacing Front Ride-height Sensor
       • 2 RA Replacing Rear Left Or Right Ride-height Sensor
       • 3 RA Replacing Control Unit For Air Supply Unit
     • 22 Pump Assembly With Container2 pages

       • 1 RA Replacing Air Supply Unit
       • 2 RA Replacing Relay For Air Supply System
     • 90 Troubleshooting › 1 RA Troubleshooting On Level Control System234
   • 41 Body (TOUR)301 pages

     • 0 Body90 pages

       • 1 RA Contents Of Body, General2
       • 2 RA Arranging Shaped Parts For Cavity Bulkhead23
       • 3 RA Basic Comments On Handling Aluminium Components2
       • 4 RA Bonding Plastic Parts
       • 5 RA Bonding Steel Parts2
       • 6 RA Corrosion Protection2
       • 7 RA Embossing Chassis Number
       • 8 RA Frame Alignment Control Dimensions BMW 5 Series E3923456
       • 9 RA Gap Dimensions On Doors _engine Hood And Trunk Lid23
       • 10 RA General Cementing Instructions
       • 11 RA General Information About Body Repair2
       • 12 RA Gluing Of Body Components
       • 13 RA Grinding Steel Parts
       • 14 RA Handling Airbags And Restraint Systems
       • 15 RA Handling Electrical And Electronic Equipment
       • 16 RA Information _ Warning Labels
       • 17 RA Information On Hazards
       • 18 RA Information On Vehicle Protection
       • 19 RA Installation Of A Cavity Seal With Cavity Foam2
       • 20 RA Installation Of A Cavity Seal With Cavity Foam2
       • 21 RA Installing A Cavity Bulkhead (expanded)
       • 22 RA Installing A Cavity Bulkhead (not Expanded)
       • 23 RA Installing Cavity Bulkhead Cover For Side Member23
       • 24 RA Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
       • 25 RA Materials Science23
       • 26 RA Notes On Repairs Of Aluminium Parts2
       • 27 RA Opening Adhesive Bonds
       • 28 RA Opening Weld Joints
       • 29 RA Quality Standard
       • 30 RA Recommended Working Methods And Tools2
       • 31 RA Removal Of PVC Material In Repair Area
       • 32 RA Riveting Aluminium Parts2
       • 33 RA Riveting Steel Parts
       • 34 RA Safety At Work2
       • 35 RA Spot-weld Bonding Steel Parts
       • 36 RA Straightening Steel Parts2
       • 37 RA Use Of Materials In Outer Shell2
       • 38 RA Vehicle Identification Number, General
       • 39 RA Welding And Soldering Steel Parts23
       • 40 RA Welding In Reinforcement Plate (steel Plate)2
       • 41 RA Welding Of Galvanized Plates
       • 42 RA Window And Door Seams2
       • 43 RA Window And Door Seams E39 Touring23
       • 44 RA Workshop Equipment2
       • 45 RA Replacing Unfinished Body Shell
       • 46 RA Installation Solution For Straight Shank_hexagon Rivet Nut23
       • 47 RA Repair Solution For Straight Shank_hexagon Rivet Nut23
       • 48 RA Notes On Cavity Foam2
       • 49 RA General Instructions On Painting
     • 11 Support Members23 pages

       • 1 RA Arranging Shaped Parts For Cavity Bulkhead23
       • 2 RA Installing Cavity Bulkhead Cover For Side Member23
       • 3 RA Replacing Right Engine Carrier (partial Replacement In Front Of Front Axle)2
       • 4 RA Replacing Front Section Of Left Engine Support23456
       • 5 RA Replacing Left Or Right Side Member Cover (partial Replacement Of A-column And R23456789
     • 12 Luggage Compartment Floor › 1 RA Replacing Rear Luggage Compartment Floor Completely (rear Left Side Wall And Tai2345678910111213
     • 14 Wheel Wells41 pages

       • 1 RA Arranging Shaped Parts For Cavity Bulkhead23
       • 2 RA Installation Of A Cavity Seal With Cavity Foam2
       • 3 RA Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
       • 4 RA Vehicle Identification Number, General
       • 5 RA Replacing Front Left Wheel Arch23456
       • 6 RA Replacing Rear Left Or Right Wheel Arch Outer Section (side Wall Removed) (touri23456789
       • 7 RA Replacing Complete Rear Left Wheel Arch (side Wall Removed) (touring)2345678910111213141516
     • 21 Side Frame And Door Pillars24 pages

       • 1 RA Arranging Shaped Parts For Cavity Bulkhead23
       • 2 RA Installation Of A Cavity Seal With Cavity Foam2
       • 3 RA Installing Cavity Bulkhead Cover For Side Member23
       • 4 RA Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
       • 5 RA Replacing Front Left Door Column (partial Replacement) (front Side Panel Removed23456789101112
     • 22 Roof Frame9 pages

       • 1 RA Arranging Shaped Parts For Cavity Bulkhead23
       • 2 RA Installation Of A Cavity Seal With Cavity Foam2
       • 3 RA Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
     • 31 Roof Outer Skin9 pages

       • 1 RA Arranging Shaped Parts For Cavity Bulkhead23
       • 2 RA Installation Of A Cavity Seal With Cavity Foam2
       • 3 RA Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
     • 32 Dash Cowl9 pages

       • 1 RA Arranging Shaped Parts For Cavity Bulkhead23
       • 2 RA Installation Of A Cavity Seal With Cavity Foam2
       • 3 RA Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
     • 33 Front Trim Panel › 1 RA Replacing Front Wall23
     • 34 Rear Trim Panel › 1 RA Replacing Tail Panel (touring)234567891011
     • 35 Side Panels25 pages

       • 1 RA Arranging Shaped Parts For Cavity Bulkhead23
       • 2 RA Installation Of A Cavity Seal With Cavity Foam2
       • 3 RA Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
       • 4 RA Removing And Installing Or Replacing Left Or Right Front Side Panel2
       • 5 RA Replacing Rear Left Side Wall (part Replacement C- And D-pillar, Top) (touring)23456789101112
       • 6 RA Replacing Rear Left Side Wall (part Replacement C- And D-pillar, Top) (touring)2
     • 51 Front Side Doors11 pages

       • 1 RA Adjusting Left Or Right Front Door2345
       • 2 RA Removing And Installing Left Or Right Front Door23
       • 3 RA Removing And Installing_replacing Airbag Module On Left Or Right Front Door23
     • 52 Rear Side Doors9 pages

       • 1 RA Adjusting Left Or Right Rear Door2345
       • 2 RA Removing And Installing Left Or Right Rear Door23
       • 3 RA Removing And Installing_replacing Airbag Module On Left Or Right Rear Door
     • 61 Front Lid6 pages

       • 1 RA Removing And Installing Hood Lid
       • 2 RA Aligning Hood Lid2345
     • 62 Rear Lid18 pages

       • 1 RA Adjusting Trunk Lid To Fit (touring)2345678910111213141516
       • 2 RA Removing And Installing Luggage Compartment Lid, Rear Window Frame And Hinges Co2
   • 51 Body Equipment (TOUR)289 pages

     • 0 General3 pages

       • 1 RA Notes On Fitting Window Guide Seals2
       • 2 RA Safety Instructions For Working On Cars With Airbag Systems
     • 11 Front Bumper11 pages

       • 1 RA Removing And Installing Complete Front Bumper2
       • 2 RA Replacing Front Bumper2
       • 3 RA Replacing Front Center Section (carrier) Of Bumper
       • 4 RA Replacing Front Bumper Trim
       • 5 RA Replacing Baseplate For Licence Plate
       • 6 RA Replacing Body Molding For Left Or Right Bumper
       • 7 RA Replacing Left Or Right Bracket For Front Bumper
       • 8 RA Replacing Shock Absorber For Front Left Bumper
       • 9 RA Replacing Shock Absorber For Front Right Bumper
     • 12 Rear Bumper11 pages

       • 1 RA Removing And Installing Entire Rear Bumper (touring)2
       • 2 RA Replacing Rear Bumper (touring)
       • 3 RA Replace Center Section Of Rear Bumper (support Beam)
       • 4 RA Replace Rear Bumper Trim
       • 5 RA Replacing Body Molding For Center Rear Bumper (touring)
       • 6 RA Replacing Body Molding For Rear Bumper On Left Or Right Side (touring)
       • 7 RA Replacing One Shock Absorber For Rear Bumper (touring)23
       • 8 RA Replacing Bracket For Rear Bumper At Left Or Right
     • 13 Trim, Covers, Handle Trim9 pages

       • 1 RA Removing And Installing Or Replacing Finisher On Left Or Right Headlight Housing
       • 2 RA Removing And Installing Trim Strip On Left Or Right Roof Frame (touring)
       • 3 RA Replacing Bracket For Roof Luggage Rack On Left Or Right2
       • 4 RA Removing And Installing_replacing Left Or Right Roof Railing (touring)23
       • 5 RA Removing And Installing Handle Strip (on Trunk Lid)
       • 6 RA Removing And Installing Or Replacing Front Grab Handle
     • 14 BMW Emblems, Model Emblems › 1 RA Removing And Installing _ Replacing Rear Model Emblem2
     • 16 Mirrors-covers-ashtrays-shelves-trays42 pages

       • 1 RA Cementing Of Mirror Base2
       • 2 RA Outside Survey Mirror Can Be Folded In
       • 3 RA Removing And Installing_replacing Center Armrest2
       • 4 RA Replacing Left Or Right Outside Mirror Housing
       • 5 RA Removing And Installing Mirror On Left Or Right Front Door
       • 6 RA Replacing Mirror Glass23
       • 7 RA Removing And Installing_replacing Interior Rearview Mirror (overview)2
       • 8 RA Removing And Installing_replacing Interior Rearview Mirror (with _X_ Cable And P2
       • 9 RA Removing And Installing_replacing Interior Rearview Mirror (with Full Foot)
       • 10 RA Removing And Installing_replacing Interior Rearview Mirror (with Mirror Arm End23
       • 11 RA Removing And Installing_replacing Interior Rearview Mirror (with Rain Sensor)23
       • 12 RA Removing And Installing _ Replacing Interior Rearview Mirror (with Remote Contro
       • 13 RA Removing And Installing Or Replacing Sun Visor And Left Or Right Counter Support
       • 14 RA Removing And Installing Oddments Tray234
       • 15 RA Replacing Oddments Tray23
       • 16 RA Removing And Installing_replacing Can Holder (front)
       • 17 RA Removing And Installing_replacing Rear Can Holder
       • 18 RA Removing And Installing _ Replacing Finisher For Preselector Lever
       • 19 RA Removing And Installing_replacing Center Armrest Sliding Unit
       • 20 RA Replacing Wooden Finishers For Oddments Tray (center Console)2
       • 21 RA Removing And Installing_replacing Glovebox Lock
       • 22 RA Removing And Installing Right Glove Box
       • 23 RA Replace Right Glovebox
       • 24 RA Removing And Installing _ Removing Sun Roller Blind From Fixed Side Window On Le
       • 25 RA Removing And Installing_replacing Rear Left_right Grab Handle
       • 26 RA Removing And Installing Or Replacing Front Grab Handle
     • 17 Lids › 1 RA Removing And Installing_replacing Left Or Right Gas Strut For Engine Bonnet_hood
     • 21 Front Door Locks, Handles, Fittings15 pages

       • 1 RA Adjusting Front Left Or Right Door Detent (lock Wedge)
       • 2 RA Removing And Installing_replacing Door Lock On Left Or Right Front Door234
       • 3 RA Removing And Installing Or Replacing Lock On Left Or Right Front Door2
       • 4 RA Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo2
       • 5 RA Removing And Installing_replacing Inside Door Handle In Left Or Right Front Door
       • 6 RA Removing And Installing Or Replacing Window Recess Cover Strip On Outside Of Lef
       • 7 RA Removing And Installing Or Replacing Chrome Strip From Left Or Right Window Rece
       • 8 RA Removing And Installing_replacing Window Cavity Cover Strip On Inner Front Door2
       • 9 RA Replacing Window Recess Cover On Left Or Right Front Door
     • 22 Rear Door Locks, Handles, Fittings13 pages

       • 1 RA Adjusting Rear Left Or Right Door Detent (lock Wedges)
       • 2 RA Removing And Installing _ Replacing Door Lock On Left Or Right Rear Door2
       • 3 RA Removing And Installing _ Replacing Outside Handle On Left Or Right Back Door2
       • 4 RA Removing And Installing _ Replacing Outside Handle And Lock Control On Left Or R2
       • 5 RA Removing And Installing_replacing Inside Door Handle Of Rear Left Or Right Door
       • 6 RA Removing And Installing_replacing Window Cavity Cover Strip On Rear Door, Outsid2
       • 7 RA Removing And Installing_replacing Chrome Strip For Window Cavity Cover Strip, Re
       • 8 RA Removing And Installing_replacing Window Cavity Cover Strip On Inside Rear Door
       • 9 RA Replacing Window Cavity Gasket On Inner Left Or Right Rear Door
     • 23 Hood Latch, Locks3 pages

       • 1 RA Adjusting_replacing Bump Stops2
       • 2 RA Removing And Installing_replacing Left Or Right Gas Strut For Engine Bonnet_hood
     • 24 Trunk Latch, Locks25 pages

       • 1 RA Instructions For Automatic Rear Lid Actuation (electrohydraulic_fully Automatic)2345
       • 2 RA Removing And Installing_replacing Trunk Lid Lock (upper Section Of Trunk Lid Loc2
       • 3 RA Removing And Installing_replacing Trunk Lid Button (touring)
       • 4 RA Removing And Installing_replacing Hydraulic Unit For Rear Lid Actuation (electro2
       • 5 RA Removing And Installing_replacing Hydraulic Cylinder For Rear Lid (electrohydrau23
       • 6 RA Removing And Installing_replacing Hydraulic Cylinder For Rear Lid (with Slide_ti
       • 7 RA Removing And Installing _ Replacing Gas Spring Strut From Left Or Right Trunk Li23456
       • 8 RA Removing And Installing _ Replacing Gas Spring Strut For Left Or Right Rear Wind2345
     • 31 Front And Rear Window36 pages

       • 1 RA Instructions On Gluing Windscreen23456789
       • 2 RA Removing Windscreen With _Roll Out 20002345
       • 3 RA Removing And Installing Front Windscreen2345678910
       • 4 RA Replacing Windscreen (complete Windscreen)
       • 5 RA Repairing Damage To Windscreens Caused By Pitting (stone Chips) (clear And Tinte
       • 6 RA Removing And Installing Rear Window (touring)2345678
       • 7 RA Replacing Rear Window (rear Window Broken)
       • 8 RA Replacing Rear Window (complete Rear Window)
     • 32 Front Manually Operated Windows3 pages

       • 1 RA Adjusting Left Or Right Front Door Window2
       • 2 RA Removing And Installing _ Replacing Front Left Or Right Door Window
     • 33 Front Electrically Operated Windows › 1 RA Removing And Installing Electric Window Regulator In Left Or Right Front Door2
     • 34 Rear Manually Operated Windows15 pages

       • 1 RA Removing And Installing_replacing Cover On Fixed Door Window Of Rear Door, Insid
       • 2 RA Removing And Installing_replacing Cover (trapping Protection) On Door Window Fra
       • 3 RA Replacing Rear Left Or Right Door Window2
       • 4 RA Replacing Fixed Door Window In Rear Left Or Right Window Frame (touring)234567
       • 5 RA Replacing Rubber Guide For Rear Left Or Right Door Window
       • 6 RA Removing And Installing_replacing Decorative Strip Of Rear Door (top), Left Or R
       • 7 RA Removing And Installing_replacing Trim On Window Frame Of Rear Door (front), Lef
       • 8 RA Removing And Installing_replacing Trim On Window Frame Of Rear Door, Rear Left O
     • 35 Rear Electrically Operated Windows3 pages

       • 1 RA Removing And Installing Complete Electrical Window Regulator From Rear Left And
       • 2 RA Removing And Installing Complete Power Window Lifter From Rear Left And Right Si2
     • 36 Hinged Window14 pages

       • 1 RA Firmly Tensioning Rear Left Or Right Side Window
       • 2 RA Removing And Installing _ Replacing Finisher On Left Or Right C-pillar (outside2
       • 3 RA Removing And Installing _ Replacing Finisher On Rear Side Window At Top Left Or
       • 4 RA Removing And Installing _ Replacing Strip On Rear Side Window At Bottom Left Or
       • 5 RA Removing And Installing Left Or Right Rear Side Window (touring)23456789
     • 37 Electrical Power Windows, Body6 pages

       • 1 RA Removing And Installing Complete Electrical Window Regulator From Rear Left And
       • 2 RA Removing And Installing Complete Power Window Lifter From Rear Left And Right Si2
       • 3 RA Removing And Installing _ Replacing Inner Window Cavity Cover Strip For Rear Lef23
     • 41 Front Door Trim Panel With Arm Rest10 pages

       • 1 RA Removing And Installing Left Or Right Front Door Trim Panel23
       • 2 RA Replacing Front Left Or Right Door Trim234
       • 3 RA Removing And Installing_replacing Sound Insulation In Front Door, Left Or Right23
     • 42 Rear Door Trim Panel With Arm Rest6 pages

       • 1 RA Removing And Installing Rear Left Or Right Door Trim Panel23
       • 2 RA Replacing Left Or Right Rear Door Trim
       • 3 RA Removing And Installing_replacing Sound Insulation In Rear Door, Left Or Right2
     • 43 Side Covering With Armrests7 pages

       • 1 RA Removing And Installing Or Replacing Trim On Left Or Right Door Column (top)2
       • 2 RA Removing And Installing Or Replacing Trim For Left Or Right Door Column (bottom)
       • 3 RA Removing And Installing Or Replacing Trim For Front Left Or Right Roof2
       • 4 RA Removing And Installing _ Replacing Trim Panel For Left Or Right Rear Roof Pilla
       • 5 RA Removing And Installing _ Replacing Trim Panel For Rear Left Or Right Roof Pilla
     • 44 Roof Trim Panel4 pages

       • 1 RA Removing And Installing_replacing Headliner (without Slide_tilt Sunroof)
       • 2 RA Removing And Installing_replacing Roofliner (with Slide_tilt Sunroof) (Touring)23
     • 45 Instrument Cluster Trim Panel12 pages

       • 1 RA Removing And Installing Trim For Instrument Panel (lower Section)23
       • 2 RA Replace Trim For Instrument Panel (lower Section)
       • 3 RA Removing And Installing Trim For Upper Section Of Instrument Panel23
       • 4 RA Replace Trim For Upper Section Of Instrument Panel23
       • 5 RA Removing And Installing_replacing Function Carrier On Instrument Panel Trim
       • 6 RA Removing And Installing_replacing Trim For Pedal Assembly
     • 46 Parcel Shelf Trim Pan.-roller Sun Blind › 1 RA Removing And Installing _ Replacing Finisher For Rear Apron At Top (touring)2
     • 47 Floor-lugg.comp.-eng.comp.tr.panels25 pages

       • 1 RA Troubleshooting On Pull-out Luggage Compartment Loading Floor (touring)2
       • 2 RA Romoving And Installing _ Replacing The Front (inside) Left Or Right Rocker Pane
       • 3 RA Removing And Installing _ Replacing The Rear (inside) Left Or Right Entrance Cov
       • 4 RA Removing And Installing_replacing Luggage Compartment Floor Trim Panel
       • 5 RA Removing And Installing Luggage Compartment Floor Trim Panel (rear) (touring)
       • 6 RA Replacing Luggage Compartment Floor Trim Panel (rear) (touring)
       • 7 RA Adjusting Luggage Compartment Loading Floor (pull-out) (touring)23456789
       • 8 RA Removing And Installing_replacing Luggage Compartment Loading Floor (pull-out) (2
       • 9 RA Removing And Installing_replacing Left Or Right Rail For Loading Floor (pull-out
       • 10 RA Removing And Installing Roller Block For Loading Floor (pull-out), Left Or Right
       • 11 RA Removing And Installing_replacing Middle Roller Block For Loading Floor (pull-ou
       • 12 RA Removing And Installing_replacing Panel For Front Luggage Compartment Floor Pane23
       • 13 RA Removing And Installing _ Replacing Left Trunk Wheel Housing Trim (touring)
     • 48 Front Lid Insulation Lining5 pages

       • 1 RA Removing And Installing_replacing Sound Insulation In Front Door, Left Or Right23
       • 2 RA Removing And Installing_replacing Sound Insulation In Rear Door, Left Or Right2
     • 49 Rear Lid Trim Panel › 1 RA Removing And Installing _ Replacing Trim Panel For Trunk Lid (touring)23
     • 71 Gaskets-seals, Loose Body Components › 1 RA Removing And Installing_replacing Front Left Or Right Wheel Arch Cover
   • 52 Seats113 pages

     • 13 Front Seat, Normal, Manual32 pages

       • 1 RA Removing And Installing Left Or Right Front Seat (normal _ Manual)23
       • 2 RA Removing And Installing _ Replacing Both Seat Rails On Left Or Right Front Seat23
       • 3 RA Adjusting Bowden Cable For Longitudinal Adjustment Of Left Or Right Front Seat (
       • 4 RA Replacing Bowden Cable For Longitudinal Adjustment On Left Or Right Front Seat (
       • 5 RA Removing And Installing _ Replacing Controls On Left _ Right Front Seat (normal2
       • 6 RA Removing And Installing _ Replacing Seat Frame On Left_right Front Seat (normal2
       • 7 RA Removing And Installing _ Replacing Backrest Frame On Left Or Right Front Seat (
       • 8 RA Removing And Installing _ Replacing Outer Cover On Left Or Right Front Seat Back2
       • 9 RA Removing And Installing _ Replacing Inner Cover On Left Or Right Front Seat Back
       • 10 RA Replacing Left Or Right Lumbar Supports On Front Seat (normal_ Manual)2
       • 11 RA Removing And Installing _ Replacing Rear Panel On Left Or Right Front Seat Backr
       • 12 RA Removing And Installing _ Replacing Front Headrest (normal_ Manual)
       • 13 RA Replacing Seat Cover On Left Or Right Front Seat (normal_ Manual)234
       • 14 RA Replacing Backrest Cover For Front Seat (normal_manual), Left Or Right2345
       • 15 RA Replacing Left Or Right Support For Front Seat (normal _ Manual)
       • 16 RA Replacing Left Or Right Support For Front Seat Back-rest (normal _ Manual)
       • 17 RA Removing And Installing_replacing Valve Housing For From Left Or Right Lumbar Su
     • 14 Front Seat, Normal, Electric7 pages

       • 1 RA Removing And Installing Left Or Right Front Seat (normal _ Electric)23
       • 2 RA Removing And Installing_replacing Head Restraint Support On Front Seat (normal_e
       • 3 RA Removing And Installing Or Replacing Front Left Or Right Head Restraints (standa
       • 4 RA Additional Work (normal_ Electric) With Defective Drive For Longitudinal Adjustm2
     • 15 Front Seat, Sports, Manual2 pages

       • 1 RA Removing And Installing Front Seat (sports_manual), Left Or Right
       • 2 RA Removing And Installing_replacing Front Left Or Right Head Restraints (sports_ma
     • 16 Front Seat, Sports, Electric2 pages

       • 1 RA Removing And Installing Front Seat (sports_electric), Left Or Right
       • 2 RA Removing And Installing Or Replacing Front Left Or Right Head Restraints (sport
     • 17 Front Seat, Comfort39 pages

       • 1 RA Removing And Installing Front Seat (comfort)
       • 2 RA Removing And Installing Or Replacing Both Seat Rails On Left Or Right Front Seat23
       • 3 RA Removing And Installing _ Replacing Seat Frame On Left Or Right Front Seat (comf
       • 4 RA Removing And Installing_replacing Drive For Active Seat, Left Or Right2345
       • 5 RA Removing And Installing _ Replacing Backrest Frame On Left Or Right Front Seat (
       • 6 RA Removing And Installing _ Replacing Cover On Left Or Right Front Seat (comfort)2
       • 7 RA Removing And Installing _ Replacing Inside Cover From Left Or Right Front Seat (
       • 8 RA Replacing Lumbar Support Cushion On Left Or Right Front Seat (comfort)2
       • 9 RA Removing And Installing_replacing Top Rear Panel On Front Seat Backrest (luxury2
       • 10 RA Removing And Installing_replacing Top Rear Panel On Front Seat Backrest (luxury23456
       • 11 RA Removing And Installing_replacing Bottom Rear Panel On Front Seat Backrest (luxu
       • 12 RA Removing And Installing_replacing Rear Panel On Front Seat Backrest (luxury Seat
       • 13 RA Removing And Installing _ Replacing Headrest Support On Left Or Right Front Seat2
       • 14 RA Removing And Installing Or Replacing Front Left Or Right Head Restraints (comfor
       • 15 RA Replacing Seat Cover On Left Or Right Front Seat (comfort)23
       • 16 RA Replacing Back-rest Cover For Front Seat (comfort) On Left Or Right Sides2345
       • 17 RA Replacing Padding For Left Or Right Front Seat (comfort Seat)
       • 18 RA Replacing Support For Left Or Right Front Seat Backrest (comfort)
     • 23 Child's Seat5 pages

       • 1 RA Repair Solution For Left Or Right Child's Seat Mechanism2
       • 2 RA Replacing Cover For Left Or Right Child's Seat2
       • 3 RA Additional Work With Integrated Child's Seats (touring)
     • 24 Rear Seat, Normal4 pages

       • 1 RA Removing And Installing _ Replacing Rear Seat (normal)
       • 2 RA Removing And Installing_replacing Rear Headrest
       • 3 RA Removing And Installing Or Replacing Left Or Right Rear Headrest
       • 4 RA Replacing Seat Cover For Rear Seat (normal)
     • 26 Rear Seat, Through-loading22 pages

       • 1 RA Removing And Installing _ Replacing Rear Seat (load Through System) (touring)2
       • 2 RA Removing And Installing _ Replacing Armrest Side Section On Left Or Right Rear-s
       • 3 RA Removing And Installing _ Replacing Left Or Right Backrest For Rear Seat (load T
       • 4 RA Removing And Installing _ Replacing Armrest For Rear-seat Backrest (load Through
       • 5 RA Removing And Installing_replacing Back-rest Frame For Rear Seat (through-loader)
       • 6 RA Removing And Installing _ Replacing Rear Panel On Left Rear-seat Backrest (load2345
       • 7 RA Removing And Installing_replacing Actuating Device For Left Rear Seat Back-rest23
       • 8 RA Removing And Installing_replacing Lock Cylinder For Left_right Rear Seat Backres2
       • 9 RA Removing And Installing_replacing Lock For Left Rear Seat Back-rest (through-loa2
       • 10 RA Replacing Seat Cover For Rear Seat (through-loading System)
       • 11 RA Replacing Backrest Cover For Left Rear Seat (load Through System)23
   • 54 Slide-tilt Sunroof And Convertible Top (TOUR)47 pages

     • 10 Sunroof › 1 RA Repair Instructions For Bonded Seals23
     • 12 Mechanical Sun Roof Components41 pages

       • 1 RA Notes On Steel And Glass Slide_tilt Sunroofs (initialization_normalization_learn23
       • 2 RA Adjusting Glass Sliding_tilting Sunroof Lid23
       • 3 RA Adjusting Sun Roof23
       • 4 RA Replacing Left Or Right Rubber Gaiters For Glass Slide_tilt Sunroof
       • 5 RA Removing And Installing Sun Roof Lid234
       • 6 RA Removing And Installing Glass Sliding_tilting Sunroof Lid234
       • 7 RA Replacing Glass Sliding_tilting Sunroof Lid
       • 8 RA Replacing Seal For Glass Sliding_tilting Sunroof Lid
       • 9 RA Replacing Seal For Slide_tilt Sunroof Lid
       • 10 RA Removing And Installing _ Replacing Headliner Mechanism For Glass Slide_tilt Sun23
       • 11 RA Removing And Installing_replacing Headliner For Sun-roof Lid2
       • 12 RA Removing And Installing _ Replacing Headliner For Glass Slide_tilt Sunroof Cover2
       • 13 RA Removing And Installing _ Replacing Water Channel For Glass Sliding_tilting Sunr
       • 14 RA Removing And Installing Complete Slide_tilt Sunroof (frame)2
       • 15 RA Removing And Installing Complete Glass Sliding_tilting Sunroof
       • 16 RA Replacing Control Rail For Left_right Glass Slide_tilt Sunroof23
       • 17 RA Adjusting Both Drive Cables For Actuation Of Glass Slide_tilt Sunroof2
       • 18 RA Removing And Installing Or Replacing Wind Deflector
       • 19 RA Removing And Installing _ Replacing Wind Deflector For Glass Sliding_tilting Sun
       • 20 RA Replacing Sliding_tilting Sunroof Frame
       • 21 RA Replacing Glass Sliding_tilting Sunroof Frame
     • 13 Electrical Sun Roof Components › 1 RA Notes On Steel And Glass Slide_tilt Sunroofs (initialization_normalization_learn23
   • 61 General Electrical System155 pages

     • 0 Troubleshooting13 pages

       • 1 RA Instructions On Starting Aid
       • 2 RA Battery
       • 3 RA Notes On Handling Wiring Harnesses And Cables
       • 4 RA Repairing Airbag Cables2
       • 5 RA Safety Instructions For Handling Vehicle Battery
       • 6 RA Unlocking And Disconnecting Different Plug Connections23
       • 7 RA Opening Plug Housings And Removing Contacts Of Different Plug Systems23
       • 8 RA Treating Cables And Fibre-optic Cables
     • 11 Wiring Harness › 1 RA Notes On Handling Wiring Harnesses And Cables
     • 12 Auxiliary Cable6 pages

       • 1 RA Unlocking And Disconnecting Different Plug Connections23
       • 2 RA Opening Plug Housings And Removing Contacts Of Different Plug Systems23
     • 13 Plug Connection, Terminal, Fuse Box46 pages

       • 1 RA Notes On Handling Wiring Harnesses And Cables
       • 2 RA Repairing Airbag Cables2
       • 3 RA Butt Connector For Repairing A Plug Connection234
       • 4 RA Crimping Stop Parts234
       • 5 RA DME Master Relay Connector
       • 6 RA Installing Fan Connector For Retrofitting_repairs2345
       • 7 RA Special Tools For Wiring Harness Repairs23
       • 8 RA Unlocking And Disconnecting Different Plug Connections23
       • 9 RA Base Of Tab Connector Housings
       • 10 RA Crimping Micro Power Quadlock Contacts (MPQ)
       • 11 RA Crimping Micro Quadlock System Contacts (MQS)2
       • 12 RA Crimping Annular Contacts
       • 13 RA Crimping Optical Fibres2
       • 14 RA Cutting Off, Stripping Insulation And Cutting Optical Fibres To Length23
       • 15 RA Cutting To Length And Stripping Insulation From Cables
       • 16 RA In-line Plugs, 30-pin, Hybrid System MQS_MPQ2
       • 17 RA Opening Plug Housings And Removing Contacts Of Different Plug Systems23
       • 18 RA Relay Carrier
       • 19 RA Repairing Ribbon Cables
       • 20 RA Retaining Bracket
       • 21 RA Socket Housing (radio Plug), Hybrid System MQS_MPQ23
       • 22 RA Treating Cables And Fibre-optic Cables
     • 20 Battery15 pages

       • 1 RA Instructions For Disconnecting And Connecting Battery23
       • 2 RA Instructions On Starting Aid
       • 3 RA Battery
       • 4 RA Repairing Airbag Cables2
       • 5 RA Safety Instructions For Handling Vehicle Battery
       • 6 RA Threshold Values For Battery Inspection Of All Battery (telephone Except For Tel
       • 7 RA AGM Battery234
       • 8 RA Battery Charging
       • 9 RA Battery Open-circuit Current Test
     • 21 Battery-vapour Separator › 1 RA Removing And Installing Battery2
     • 31 Switch35 pages

       • 1 RA Removing And Installing_replacing Fixture For Steering Column Stalk23
       • 2 RA Removing And Installing_replacing Turn Indicator_headlight Dip Lever
       • 3 RA Removing And Installing The Ignition Switch
       • 4 RA Removing And Installing_replacing Light Switch
       • 5 RA Removing And Installing_replacing Steering Column Adjustment Lever2
       • 6 RA Removing And Installing_replacing Windshield Wiper Lever
       • 7 RA Removing And Installing_replacing Dimmer Switch For Instrument Panel Lighting
       • 8 RA Removing And Installing Switch Unit In Center Console
       • 9 RA Replacing Switch Unit In Center Console
       • 10 RA Removing And Installing_replacing Switch For Foglights And Rear Foglights
       • 11 RA Removing And Installing_replacing Switch For Vertical Aim Control
       • 12 RA Removing And Installing _ Replacing Switch From Hazard Warning Lights
       • 13 RA Removing And Installing _ Replacing Switch For Central Locking System
       • 14 RA Removing And Installing_replacing Switch For Automatic Rear Lid Actuation
       • 15 RA Removing And Installing _ Replacing Switch For Left Or Right Seat Heating
       • 16 RA Replacing Rocker Switch For Side-window Operation
       • 17 RA Replacing Switch Combination For Seat Adjustment
       • 18 RA Removing And Installing_replacing Switch For Front Lumbar Support
       • 19 RA Removing And Installing _ Replacing Switch For Automatic Stability Control
       • 20 RA Removing And Installing _ Replacing Switch For Electronic Damper Control
       • 21 RA Removing And Installing _ Replacing Switch For Rear Window Roller Blind
       • 22 RA Replacing Switch On Impact Cushion For Left Or Right Airbag
       • 23 RA Replacing Switch On Sports Steering Wheel On Left Or Right
       • 24 RA Replacing Switch On Sport Steering Wheel (with Connected Airbag Unit)
       • 25 RA Removing And Installing _ Replacing Rear Window Button
       • 26 RA Replacing Clutch Switch For Cruise Control System
       • 27 RA Removing And Installing_replacing Clutch Switch Module
       • 28 RA Replacing Brake-light Switch2
       • 29 RA Removing And Installing_replacing Tilt Sensor For Automatic Rear Lid Actuation
       • 30 RA Replacing Relay For Air Supply System
       • 31 RA Carrying Out Steering Angle Sensor Adjustment
     • 35 ECUs, Modules12 pages

       • 1 RA Control Units, Switches, Relays
       • 2 RA Note On Replacing Codable_programmable Control Units
       • 3 RA Notes On ESD Protection (Electro Static Discharge)23
       • 4 RA Removing And Installing_replacing Rain Sensor23
       • 5 RA Initializing Rain Sensor
       • 6 RA Removing And Installing_replacing Ringantenna Of Electronic Immobiliser2
       • 7 RA Vehicle Programming And Coding
     • 36 Relays2 pages

       • 1 RA DME Master Relay Connector
       • 2 RA Relay Carrier
     • 61 Windscreen Wipers8 pages

       • 1 RA Checking_adjusting Approach Angle Of Windshield Wiper Arms On Front Windscreen
       • 2 RA Replacing Both Windshield Wiper Blades
       • 3 RA Removing And Installing_replacing Both Windshield Wiper Arms23
       • 4 RA Removing And Installing Complete Wiper Console23
     • 62 Rear Window Wiper8 pages

       • 1 RA Replacing Wiper Arm For Rear Window Wiper
       • 2 RA Removing And Installing _ Replacing Rear Window Wiper Motor
       • 3 RA Removing And Installing _ Replacing Axis Bearing For Rear Window Wiper23
       • 4 RA Adjusting Spray Nozzle On Rear Window Washer Unit
       • 5 RA Removing And Installing _ Replacing Spray Nozzle For Rear Window Washer Unit2
     • 67 Headlight Washer System3 pages

       • 1 RA Removing And Installing_replacing Washer Pump Of Headlight Cleaning System
       • 2 RA Adjusting Spray Nozzles For Headlight-cleaning System
       • 3 RA Removing And Installing_replacing Spray Nozzles For Left Or Right Headlight Clea
     • 71 Window Washer System4 pages

       • 1 RA Adjusting Windshield Washer Spray Nozzles
       • 2 RA Replacing Fluid Tank For Windshield Washer System2
       • 3 RA Removing And Installing_replacing Window Washer Pump (windshield_rear Window)
   • 62 Instruments4 pages

     • 11 Instrument Cluster2 pages

       • 1 RA Replacing Instrument Cluster Display System
       • 2 RA Replacing Instrument Cluster Electronics
     • 21 Instrument Carrier › 1 RA Removing And Installing Complete Instrument Carrier2
   • 63 Lights73 pages

     • 10 Lamp Settings5 pages

       • 1 RA Adjusting Headlight For RHD_LHD Vehicles
       • 2 RA Test Requirements For Headlight Vertical Aim Adjustment2
       • 3 RA Adjusting Headlights
       • 4 RA Adjusting Fog Lamps
     • 12 Headlights31 pages

       • 1 RA Removing And Installing_replacing Left Headlight2
       • 2 RA Removing And Installing_replacing Right Headlight
       • 3 RA Removing And Installing_replacing Left Headlight (xenon Headlight)
       • 4 RA Removing And Installing_replacing Right Headlight (xenon Headlight)
       • 5 RA Removing And Installing_replacing Lens_reflector For Left Headlight (up To 09_20
       • 6 RA Removing And Installing_replacing Lens_reflector For Right Headlight (up To 09_2
       • 7 RA Removing And Installing_replacing Lens_reflector For Left Headlight (xenon Headl
       • 8 RA Removing And Installing_replacing Lens_reflector For Right Headlight (xenon Head
       • 9 RA Replacing Adjusting Elements For Left Headlight (up To 09_2000)
       • 10 RA Replacing Adjusting Elements For Right Headlight (up To 09_2000)
       • 11 RA Replacing Adjusting Elements For Left Xenon Headlight (up To 09_2000)
       • 12 RA Replacing Adjusting Elements For Right Xenon Headlight (up To 09_2000)
       • 13 RA Replacing Headlamp Housing With Insert On Left (up To 09_2000)
       • 14 RA Replacing Headlamp Housing With Insert On Right (up To 09_2000)
       • 15 RA Replacing Headlamp Housing With Insert For Xenon Headlamp On Left (up To 09_2000
       • 16 RA Replacing Headlamp Housing With Insert For Xenon Headlamp On Right (up To 09_200
       • 17 RA Replacing Control Unit For Left Xenon Headlamp2
       • 18 RA Replacing Control Unit For Right Xenon Headlamp
       • 19 RA Replace One Bracket For Headlight Mount
       • 20 RA Removing And Installing_replacing Left Headlight Vertical Aim Adjuster (from 092
       • 21 RA Removing And Installing_replacing Left Headlight Vertical Aim Adjuster (up To 092
       • 22 RA Removing And Installing_replacing Left Headlight Vertical Aim Adjuster (xenon He2
       • 23 RA Removing And Installing_replacing Left Headlight Vertical Aim Adjuster (xenon He2
       • 24 RA Removing And Installing_replacing Right Headlight Vertical Aim Adjuster
       • 25 RA Removing And Installing_replacing Right Headlight Vertical Aim Adjuster (xenon H
     • 17 Fog Lights, Auxiliary Lights4 pages

       • 1 RA Removing And Installing_replacing Left Or Right Fog Lamp Insert (complete)2
       • 2 RA Replace Reflector For Foglights
       • 3 RA Removing And Installing_replacing Left Or Right Fog Lamp Insert (M Aerodynamics
     • 21 Rear Light Cluster3 pages

       • 1 RA Replacing A Socket Housing For Rear Light On Left Or Right (touring)
       • 2 RA Removing And Installing_replacing Left Or Right Rear Light (touring, Side Panel)
       • 3 RA Removing And Installing_replacing Left Or Right Rear Light (touring, Rear Lid)
     • 25 Brake Lights › 1 RA Removing And Installing _ Replacing Auxiliary Brake Light (touring)2
     • 26 Licence Plate Lights › 1 RA Removing And Installing_replacing Both License Plate Lights
     • 31 Interior Lights5 pages

       • 1 RA Removing And Installing_replacing Complete Interior Light
       • 2 RA Removing And Installing_replacing Left Or Right Interior Light
       • 3 RA Removing And Installing_replacing Footwell Light
       • 4 RA Removing And Installing_replacing Mirror Light
       • 5 RA Removing And Installing _ Replacing Luggage Compartment Light (touring)
     • 99 Light Bulbs22 pages

       • 1 RA Instructions For Handling Light Bulbs (exterior Lights)
       • 2 RA Instructions For Replacing Light Bulbs (interior Lights)
       • 3 RA Replacing Halogen Bulb For Left Or Right High-beam Headlight
       • 4 RA Replacing Halogen-light Bulb For Left Or Right Headlight
       • 5 RA Replacing Bulb For Left Xenon Headlight2
       • 6 RA Replacing Right Lamp For Xenon Light
       • 7 RA Replacing Bulb For Left Or Right Front Parking Light2
       • 8 RA Replacing Halogen Bulb For Left Or Right Front Fog Lamp2
       • 9 RA Replacing Halogen Bulb For Left Or Right Fog Lamp (M Aerodynamics Package)
       • 10 RA Replacing Light Bulb For Front Left Or Right Turn Indicator
       • 11 RA Replacing Bulb(s) For Left Or Right Rear Light (touring)2
       • 12 RA Replacing Bulb For Left Or Right License-plate Light
       • 13 RA Replace Light Bulb For Interior Light
       • 14 RA Replacing Bulb(s) For Left Or Right Interior Light2
       • 15 RA Replacing Bulb(s) For Mirror Light
       • 16 RA Replacing Light Bulb For Luggage Compartment Lighting2
   • 64 Heating And Air Conditioning153 pages

     • 11 Heater With Operation46 pages

       • 1 RA Installing Servodrive
       • 2 RA Removing And Installing _ Replacing Heater (heater)23
       • 3 RA Removing And Installing _ Replacing Heater (automatic Air Conditioner)2
       • 4 RA Removing And Installing_replacing Heater (A_C Control)
       • 5 RA Replacing Heater Core (heating)
       • 6 RA Replacing Heater Core (automatic A_C)2345
       • 7 Replacing Heater Blower2
       • 8 RA Replacing Heater Core (air Conditioner Control)23
       • 9 RA Replacing Limit Switch For Fan Of Heater_air Conditioner
       • 10 RA Removing And Installing _ Replacing Auxiliary Water Pump
       • 11 RA Replacing Water Valve For Heater23
       • 12 RA Replacing Front Plate (air Conditioner Controls)
       • 13 RA Replacing Front Plate (air Conditioner Control)
       • 14 RA Replacing Pushbutton Covers For Heater Controls
       • 15 RA Removing And Installing Heater Controls (A_C Control)
       • 16 RA Removing And Installing _ Replacing Heater Controls (automatic Air Conditioner)
       • 17 RA Removing And Installing _ Replacing The Rear Fan Completely2
       • 18 RA Removing And Installing _ Replacing The Controller For The Rear Fan
       • 19 RA Replacing Servodrive Of Fresh Air Flaps (automatic A_C, Up To 03_2000)
       • 20 RA Replacing Servodrive Of Recirculated Air Flaps (automatic A_C)2
       • 21 RA Replacing Servodrive Of Ventilation Flaps (automatic A_C)
       • 22 RA Replacing Servodrive Of Footwell Flap (automatic A_C)
       • 23 RA Replacing Servodrive Of Defrosting Flaps (automatic A_C)2
       • 24 RA Replacing Servodrive Of Dynamic Air Flap (automatic A_C, From 03_2000)
       • 25 RA Replacing Servodrive Of Rear Compartment Flap (automatic A_C, From 09_97)
       • 26 RA Replacing Evaporator Temperature Sensor (A_C Control)2
       • 27 RA Replacing Evaporator Temperature Sensor (climate Control, From 03_2000))2
       • 28 RA Replacing Temperature Sensor For Heater
       • 29 RA Removing And Installing_replacing Solar Sensor
     • 12 Auxil. Heater With Control Elements38 pages

       • 1 RA Venting Latent Heat Accumulator (LWS)23456
       • 2 RA Bleeding Independant Heating (Thermo Top S)
       • 3 RA Flushing Cooling System When Replacing Latent Heat Accumulator Due To Salt Leaks
       • 4 RA Checking Function Of Independant Heating (Thermo Top S)
       • 5 RA Removing And Installing Complete Heater (Thermo Top Z_C)2
       • 6 RA Replacing Complete Heater (Thermo Top Z_C)
       • 7 RA Removing And Installing _ Replacing Complete Heater (Thermo Top S)2
       • 8 RA Removing And Installing _ Replacing Glow Element (Thermo Top S)2
       • 9 RA Removing And Installing _ Replacing Flame Detector (Thermo Top S)
       • 10 RA Removing And Installing _ Replacing Control Unit With Heat Exchanger (Thermo Top2
       • 11 RA Removing And Installing _ Replacing Combustion Air Blower (Thermo Top S)
       • 12 RA Removing And Installing _ Replacing Burner Insert (Thermo Top S)
       • 13 RA Removing And Installing _ Replacing Circulation Pump (Thermo Top S)
       • 14 RA Removing And Installing Or Replacing Muffler
       • 15 RA Removing And Installing Or Replacing Fuel Pump
       • 16 RA Removing And Installing _ Replacing Receiver_Telestart Of Independent Heating2
       • 17 RA Removing And Installing_replacing Latent Heat Accumulator2
       • 18 RA Removing And Installing_replacing Temperature Sensor For Latent Heat Accumulator
       • 19 RA Removing And Installing_replacing Auxiliary Water Pump For Latent Heat Accumulat2
       • 20 RA Removing And Installing_replacing Non-return Valve For Latent Heat Accumulator23
       • 21 RA Removing And Installing_replacing Changeover Valve For Latent Heat Accumulator23
       • 22 RA Overview Of Defects For Independent Heating Thermo Top S
     • 22 Nozzles And Outlets4 pages

       • 1 RA Removing And Installing _ Replacing Fresh-air Grill On Front Door Trim Panel
       • 2 RA Removing And Installing _ Replacing Center Fresh-air Grill2
       • 3 RA Removing And Installing _ Replacing Fresh-air Grill In Rear Of Car
     • 31 Microfilter3 pages

       • 1 RA Checking Water Drain Under Brake Booster For Contamination, Cleaning If Necessar
       • 2 RA Removing And Installing_replacing Air Duct For Microfilter On Left Or Right
       • 3 RA Replacing Microfilter For Interior Ventilation
     • 50 Air Conditioning System16 pages

       • 1 RA Air Conditioner Test (R 134a)
       • 2 RA Instructions For Handling Refrigerant R 134a
       • 3 RA Instructions For Handling Refrigerant Oil (for Refrigerant R 134a)2
       • 4 RA Leak Testing With Ultraviolet Additives (UV Additives) (BMW Leak-testing Case)23
       • 5 RA Leak-testing With Leak Tester Device2
       • 6 RA Safety Instructions For Handling Refrigerant R134a
       • 7 RA Safety Instructions For Handling Refrigerant Oil2
       • 8 RA Drawing Off, Evacuating And Filling A_C System (R 134a)2
       • 9 RA Instructions For Opening And Replacing Parts In Refrigerant Circuit2
     • 51 AC Housing-evaporator, Switching Elemts17 pages

       • 1 RA Cleaning Evaporator23
       • 2 RA Cleaning Evaporator (automatic Climate Control)234
       • 3 RA Removing And Installing _ Replacing Expansion Valve (air-conditioning)2
       • 4 RA Removing And Installing _ Replacing Evaporator23
       • 5 RA Removing And Installing_replacing Evaporator (A_C Control)23
       • 6 RA Instructions For Opening And Replacing Parts In Refrigerant Circuit2
     • 52 Compressor7 pages

       • 1 RA Instructions For Compressor Replacement23
       • 2 RA Instructions For Opening And Replacing Parts In Refrigerant Circuit2
       • 3 RA Removing And Installing_replacing Complete A_C Compressor2
     • 53 Condenser And Dryer With Lines8 pages

       • 1 RA Removing And Installing Cassette (condenser For Air Conditioner)23
       • 2 RA Instructions For Opening And Replacing Parts In Refrigerant Circuit2
       • 3 RA Notes On Replacing Drier Bottle Or Drier Insert
       • 4 RA Removing And Installing _ Replacing Drier Flask For Air Conditioner
       • 5 RA Removing And Installing Or Replacing Condenser For Air Conditioner
     • 99 Troubleshooting14 pages

       • 1 RA Fault 01 Combustion Air Blower
       • 2 RA Fault 02 Flame Detector
       • 3 RA Fault 03 Glow Plug
       • 4 RA Fault 04 Circulation Pump
       • 5 RA Fault 05 Temperature Sensor
       • 6 RA Fault 06 Park Heating Metering Pump
       • 7 RA Fault 07 Overheating Protection
       • 8 RA Fault 08 Burner Insert
       • 9 RA Fault 1
       • 10 RA Fault 4
       • 11 RA Fault 6
       • 12 RA Fault 6
       • 13 RA Overview Of Defects For Independent Heating Thermo Top S
       • 14 RA Reading Out Flashcode
   • 65 Audio, Navigation And Information System38 pages

     • 11 Mono Radio4 pages

       • 1 RA Removing And Installing _ Replacing Radio Receiver2
       • 2 RA Removing And Installing _ Replacing Radio Receiver (with On-board Monitor, Touri2
     • 12 Stereo Radio, Amplifier › 1 RA Removing And Installing_replacing Rear Loudspeaker
     • 13 Speaker And Cover › 1 RA Removing And Installing _ Replacing Entire Subwoofer Speaker For Top-HiFi System
     • 24 Rear Window Aerial-antenna3 pages

       • 1 RA Removing And Installing_replacing Antenna Amplifier (touring)2
       • 2 RA Removing And Installing _ Replacing TV Amplifier (touring C-pillar)
     • 50 Video And TV Equipment › 1 RA Removing And Installing _ Replacing Video Module For On-board Monitor (touring)
     • 52 Video Monitor11 pages

       • 1 RA Removing And Installing_replacing Cassette Drive2
       • 2 RA Removing And Installing Complete On-board Monitor (widescreen)
       • 3 RA Replacing Panel For On-board Monitor (control Panel, Widescreen)2
       • 4 RA Removing And Installing_replacing Housing With Drive For On-board Monitor (wides
       • 5 RA Removing And Installing On-board Monitor2
       • 6 RA Replacing Trim Panel For On-board Monitor (control Panel)
       • 7 RA Removing And Installing_replacing LC Display For On-board Monitor2
     • 75 Anti-theft Alarm System › 1 RA Removing And Installing_replacing Control Unit For Radio Interior Protection
     • 77 Airbag Trigger Device, Diagnosis Unit8 pages

       • 1 RA Removing And Installing Airbag Control Unit2
       • 2 RA Replacing Airbag Control Unit
       • 3 RA Removing And Installing_replacing Collision Sensor For Left Or Right Side Airbag2
       • 4 RA Removing And Installing Impact Sensor For Left Or Right Side Airbag (multiple Re2
       • 5 RA Replacing Impact Sensor For Left Or Right Side Airbag (multiple Restraint System
     • 81 On-board Computer › 1 RA Removing And Installing _ Replacing Multi-information Display (MID Or IRIS)2
     • 83 Car Communication Computer (CCC) › 1 RA Removing And Installing_replacing Cassette Drive2
     • 90 Navigation Systems4 pages

       • 1 RA Notes On Handling Navigation Computers
       • 2 RA Calibrating Wheels For Navigation System 1 (up To 9_97, Measured With Distance T
       • 3 RA Removing And Installing _ Replacing Receiver Module Of Global Positioning System
       • 4 RA Removing And Installing _ Replacing Antenna Of Global Positioning System (GPS) (
   • 66 Distance Systems, Cruise Control › 20 Park Distance Control2 pages

     • 1 RA Removing And Installing_replacing An Ultrasonic Transducer At Front (Park Distan
     • 2 RA Removing And Installing _ Replacing A Rear Ultrasonic Converter (center)
   • 67 Electrical Drives23 pages

     • 11 Central Locking Unit - Unlocking Units › 1 RA Replacing Actuator Drive For Trunk Lid Lock (touring)
     • 13 Mirror Adjustment2 pages

       • 1 RA Replacing Drive Unit For Electrically Operated Left Or Right Door Mirror
       • 2 RA Replacing Drive Unit For Electrically Operated Left Or Right Door Mirror (with M
     • 16 Servo-positioning Drives10 pages

       • 1 RA Removing And Installing_replacing Left Headlight Vertical Aim Adjuster (from 092
       • 2 RA Removing And Installing_replacing Left Headlight Vertical Aim Adjuster (up To 092
       • 3 RA Removing And Installing_replacing Left Headlight Vertical Aim Adjuster (xenon He2
       • 4 RA Removing And Installing_replacing Left Headlight Vertical Aim Adjuster (xenon He2
       • 5 RA Removing And Installing_replacing Right Headlight Vertical Aim Adjuster
       • 6 RA Removing And Installing_replacing Right Headlight Vertical Aim Adjuster (xenon H
     • 31 Drive, Seat Adjustment › 1 RA Removing And Installing_replacing Drive Unit For Head Restraint Adjustment (comf23
     • 61 Drive, Slide-tilt Sunroof-conv. Top › 1 RA Removing And Installing Or Replacing Drive With Gear For Actuating Slide_tilt Su2
     • 62 Drive, Window Regulator › 1 RA Removing And Installing_replacing Flat Motor For Rear Left Or Right Power Window2
     • 63 Drive Unit, Headlight Wipe-wash Unit › 1 RA Removing And Installing _ Replacing Wiper Motor
     • 66 Drive, Seat Adjustment › 1 RA Removing And Installing_replacing Lumbar Support Drive Mechanism On Front Seat,2
   • 72 Parts - Accessories (Body)66 pages

     • 0 General6 pages

       • 1 RA Safety Precautions And General Information
       • 2 RA Safety Regulations For Handling Airbag System Components2
       • 3 RA Safety Regulations For Handling Components With Gas Generators2
       • 4 RA Safety Regulations For Handling Airbag Modules, Airbag Components And Pyrotechni
     • 11 Seat Belts16 pages

       • 1 RA Safety Precautions And General Information
       • 2 RA Checking Automatic Safety Belt23
       • 3 RA Inspection List For Automatic Seat Belt2
       • 4 RA Removing And Installing Or Replacing Front Left Or Right Safety Belt (complete U2
       • 5 RA Removing And Installing_replacing Left Or Right Rear Safety Belt234
       • 6 RA Removing And Installing _ Replacing Rear Center Safety Belt234
     • 12 Airbag Generator-airbag Unit For Pass44 pages

       • 1 RA Repairing Airbag Cables2
       • 2 RA Safety Precautions And General Information
       • 3 RA Safety Regulations For Handling Airbag System Components2
       • 4 RA Safety Regulations For Handling Components With Gas Generators2
       • 5 RA Airbag System
       • 6 RA Deactivation Of Airbags234
       • 7 RA Procedure After Airbag Triggering As Result Of An Accident23
       • 8 RA Safety Regulations For Handling Airbag Modules, Airbag Components And Pyrotechni
       • 9 RA Scrapping Vehicles With Passenger Airbag And Pyrotechnic Belt Tensioners
       • 10 RA Unlocking_locking Airbag Plug Connections234
       • 11 RA Removing And Installing Or Replacing Airbag Module On Passenger Side23456
       • 12 RA Removing And Installing_replacing Airbag Module On Left Or Right Front Door23
       • 13 RA Removing And Installing_replacing Airbag Module On Left Or Right Rear Door
       • 14 RA Removing And Installing _ Replacing Left Or Right ITS Head Airbag (model Without23456789101112
       • 15 RA Removing And Installing Left Or Right ITS Head Airbag (model Fitted With Sliding
   • 84 Communication Systems7 pages

     • 11 Transceiver, Handset-support, Card Reade5 pages

       • 1 RA Removing And Installing_replacing Eject Box2
       • 2 RA Removing And Installing_replacing Transceiver (fixed Mounting)
       • 3 RA Removing And Installing_replacing Interface For D-Network Car Phone
       • 4 RA Replacing Cordless Keypad Handset
     • 21 Handheld Computer2 pages

       • 1 RA Removing And Installing_replacing Hands-free Charging Electronics
       • 2 RA Removing And Installing_replacing Hands-free Charging Electronics
   • 86 Trailers107 pages

     • 10 Loading Platform71 pages

       • 1 RA Body And Underbody_ Checking For Corrosion And Damage
       • 2 RA Raising BMW Multi-trailer23
       • 3 RA Adjusting Brake System23
       • 4 RA Adjusting Spring Force Accumulator
       • 5 RA Disassembly Of Camlock Retaining Cam
       • 6 RA Disassembly Of Base Plate
       • 7 RA Disassembly Of Bracket On Platform Base
       • 8 RA Disassembly Of Front Apron
       • 9 RA Disassembly Of Front Protection Bar
       • 10 RA Disassembly Of Jockey Wheel Or Jockey Wheel Mount
       • 11 RA Disassembly Of Left And Right Aprons
       • 12 RA Disassembly Of Left And Right Lamp Housings
       • 13 RA Disassembly Of Left And Right Wheel Boxes
       • 14 RA Disassembly Of Licence Plate Mounting Plate
       • 15 RA Disassembly Of Loading Ramp Frame_disassembly Of Rail, Left_right
       • 16 RA Disassembly Of Rear Apron
       • 17 RA Disconnecting Plug Connection, Wiring Harness, Front_rear
       • 18 RA Installation Position Of BMW Lettering
       • 19 RA Positioning Of Multitrailer Hood For Maintenance And Repair Work2
       • 20 RA Removing Camlock Retaining Cam On Loading Ramp
       • 21 RA Removing Camlock Screw Cap
       • 22 RA Removing And Installing Or Replacing Left Or Right Coil Spring2
       • 23 RA Removing Bolt On Loading Ramp
       • 24 RA Removing Brake Shoes2345
       • 25 RA Removing Entry Profile Section On Loading Ramp, Left, Right And Center
       • 26 RA Removing Left Or Right Shock Absorber
       • 27 RA Removing Loading Ramp Lock2
       • 28 RA Removing Mounting Bracket Sealing Cap
       • 29 RA Removing Mounting Bracket, Center, Left And Right
       • 30 RA Removing Outer Pull Rod Mount, Left And Right
       • 31 RA Removing Overrunning Equipment_maintaining Or Replacing Guide Bush_installing Ov2345
       • 32 RA Removing Plastic Bush_metal Bush
       • 33 RA Removing Rear Supports And Bracket
       • 34 RA Removing Reflecting Rear Light
       • 35 RA Removing Rest On Loading Ramp, Left, Right And Center
       • 36 RA Removing Shock Absorber From Overrunning Equipment
       • 37 RA Removing Trailing Arm, Removing And Installing Or Replacing Mounting23
       • 38 RA Removing Wheel Bearing2
       • 39 RA Removing Wooden Rest On Loading Ramp, Left, Right And Center
       • 40 RA Repair Work On GFP Components With Gelcoat Surface
       • 41 RA Replacing 12 Volt Socket2
       • 42 RA Replacing Bar
       • 43 RA Replacing Drawbar Members, Left And Right2
       • 44 RA Replacing Gaiter
       • 45 RA Replacing Holder For Chock
       • 46 RA Replacing Lashing Plate And Lashing Eye
       • 47 RA Replacing License Plate Light
       • 48 RA Replacing Position Light
       • 49 RA Replacing Rear Light
       • 50 RA Troubleshooting On Multi-trailer2
     • 21 Hood36 pages

       • 1 RA Positioning Of Multitrailer Hood For Maintenance And Repair Work2
       • 2 RA Adjusting Hood Pretension - Camloc Fastener With Spacers23
       • 3 RA Adjusting Rear Lid To Fit2
       • 4 RA Adjusting Rotary Striker Lock
       • 5 RA Adjusting Side Lid To Fit2
       • 6 RA Attaching_replacing BMW Badge2
       • 7 RA Fitting BMW Logo
       • 8 RA Installing Hood Seal
       • 9 RA Installing Rubber Roof Strip
       • 10 RA Installing Seal For Rear Lid And Side Lid
       • 11 RA Installing Sponge Rubber Seal
       • 12 RA Removing Ball Pivot
       • 13 RA Removing Centering Pin From Mounting Bracket
       • 14 RA Removing Gas Spring
       • 15 RA Removing Gas Spring Retaining Bracket
       • 16 RA Removing Hinge Bracket On Rear Lid
       • 17 RA Removing Lid
       • 18 RA Removing Lock Barrel
       • 19 RA Removing Lock Striker Fixture On Rear Lid
       • 20 RA Removing Plug For Inside Light2
       • 21 RA Removing Roof Railing
       • 22 RA Removing Roof Railing Adapter2
       • 23 RA Removing Rotary Striker Lock2
       • 24 RA Removing Side Lid Hinge
       • 25 RA Replacing Inside Light
       • 26 RA Replacing Inside Light Power Cable2
   • 99 Paintwork2 pages

     • 1 RA Information _ Warning Labels
     • 2 RA General Instructions On Painting
3. 033 Technical Data3 Technical Data: Sections
4. 044 Tightening Torques4 Tightening Torques: Sections
5. 056 SI Operating Fluids6 SI Operating Fluids: Sections
6. 067 SI Techniques7 SI Techniques: Sections
7. 078 SI Diagnosis Encoding8 SI Diagnosis Encoding: Sections
8. 089 SI Special Tools-appliances9 SI Special Tools-appliances: Sections
9. 0910 Special Tool10 Special Tool: Sections