1 Series 125i (N52K) Convertible: 2 Repair Instructions
Also for this vehicle: 1 Series 120i (N43) Convertible, 1 Series 120i (N46T) Convertible, 1 Series 128i (N52K) Convertible.
Maintenance
General
Diagnostics
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
00 Maintenance And General Data68 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Pre-delivery Check2345
- Lifting Vehicle With A Lifting Platform
- Notes On Using Repair Instructions, Technical Data, Tightening Torques
- Raising Vehicle With Trolley Jack
- Symbols Used And Information In Repair Instructions2
- Battery: Checking Display. If Necessary, Recharge Battery
- Body And Underbody: Checking For Corrosion And Damage
- Body: Check For Corrosion (except Cavities)
- Brake Lines And Connections: Visual Inspection For Leaks, Damage And Correct Pos
- CBS Reset2
- Check Windscreen Wash/wipe System
- Checking Coolant Level And Concentration, Correcting If Necessary
- Checking Horn, Headlight Flashers And Hazard Warning System
- Checking Instrument And Indication Field Lighting, Heater Blower
- Checking Lighting System
- Checking Roadworthiness (test Drive)
- Diagnostic Brief Test
- Information/warning Labels23
- Microencapsulated Screws
- Raising BMW Multi-trailer23
- Seat Belts: Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
- Steering Components: Checking For Zero Clearance, Leaks, Damage And Wear2
- Steering Fluid Reservoir: Check Oil Level2
- Tyres: Checking Inflation Pressure, Correcting If Necessary (incl
- Underbody Incl
- Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid23
- Windscreen Washer System: Checking Fluid Level, Topping Up If Necessary
- Interrogating Fault Memories In Diagnosis System
- Standard Scope Of Service
- CBS Reset23
- Service - Intake Muffler
- Engine Oil Service (N52K)23
- Service - Engine Oil (petrol/gasoline Vehicles From 03/2007)
- Service - Front Brakes
- Service - Rear Brakes
- Service - Microfilter
- Service - Brake Fluid
- Service - Spark Plugs
- Service - Vehicle Check
- Checking/topping Up Oil Level In Rear Differential
- Draining/topping Up Gear Oil In Manual Transmission
- Checking/topping Up Fluid Level In Automatic Transmission (GA6L45R)2
- Oil Change In Rear Differential Incl
- Notes On Handling Wiring Harnesses And Cables
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
11 Engine (N52K)114 pages
21 Crankshaft With Bearing11 pages
- 22 Flywheel › Removing And Installing/replacing Flywheel (N52K)2
- 23 Vibration Damper › Removing And Installing/replacing Vibration Damper (N52K)
- 24 Connecting Rod With Bearing › Replacing All Connecting Rod Bearing Shells (N52K)23
25 Piston With Rings And Pin10 pages
- 28 V-ribbed Belt W.tens.-deflect.elemt › Replacing Alternator Drive Belt (N52K)2
31 Camshaft21 pages
- 33 Rocker Arm With Bearing Mount › Removing And Installing/replacing All Cam Followers (N52K)2
41 Oil Pump With Filter And Drive6 pages
- 51 Water Pump With Drive › Removing And Installing/replacing Water Pump (N52K)2
- 53 Thermostat And Connections › Removing And Installing/replacing Coolant Thermostat (N52K)2
- 71 Exhaust Gas Recirculation › Removing And Installing Or Replacing EGR Cooler (N47)2
12 Engine Electrical System (N52K)66 pages
00 Troubleshooting8 pages
- 12 Ignition Wires, Spark Plugs › Replacing All Spark Plugs (N42, N40, N46, N45, N52, N52K, N51)
14 Electronic Switching Or Contr.units15 pages
- Replacing Crankshaft Pulse Generator (N52, N52K, N51, N53)2
- Replacing Inlet Camshaft Pulse Generator (N52, N52K, N51, N53)
- Replacing Exhaust Camshaft Pulse Generator (N52, N52K, N51, N53)
- Replacing Control Unit (DME)2
- Removing/replacing Knock Sensors (N52, N52K, N51)2
- Coding Control Module (DME / DDE)
- Programming Control Unit (DME / DDE)
- Removing And Installing/replacing Electronics Box234
- Replacing Fan For Electronics Box
- 32 Regulator › Replacing Voltage Regulator23
41 Starter With Mounting3 pages
61 Oil Pressure-oil Temperature-oil Gauge2 pages
90 Control Unit Box5 pages
13 Fuel System (N52K)23 pages
31 Fuel Pump With Drive And Line5 pages
53 Injection Nozzle And Lines6 pages
54 Throttle And Operation3 pages
- 71 Intake Silencer › Removing And Installing/replacing Intake Filter Housing (N52: N52K: N53)
- 72 Air Cleaner › Replacing Air Filter Element (N52: N52K: N53)
- 90 Carbon Canister Ventilation › Replacing Tank Vent Valve (N52 / N52K / N51 / N53)
16 Fuel Supply System (N52K)49 pages
00 Fuel Pick-up, Cleaning System14 pages
- General Function Description For Fuel Supply Systems
- Fuel Supply System (petrol/gasoline)234
- Draining And Filling Fuel Tank23
- Checking Fuel Tank And Tank Ventilation System For Leaks23
- Checking Fuel Tank And Tank Venting System For Leaks With Tank Leakage Diagnosis2
- Conducting Leak Test On Fuel Tank And Tank Venting System
11 Fuel Tank With Mounting11 pages
- Removing And Installing Or Replacing Fuel Tank (petrol/gasoline)234
- Removing And Installing Or Replacing Fuel Filler Pipe2
- Replacing Rubber Sleeve Between Fuel Filler Pipe And Fuel Tank
- Checking Filler Cap Pressure Relief Valve2
- Replacing Clamping Bands For Fuel Tank
- Removing And Installing/replacing Vent Hose With Strainer For Carbon Canister
12 Fuel Transfer, Sensor For Gauge13 pages
- Checking Repumping Function Of Suction-jet Pump With BMW Diagnosis System
- Removing And Installing Or Replacing Fuel Gauge Sensor (petrol/gasoline, Right)234
- Removing And Installing Or Replacing Fuel Gauge Sensor (petrol/gasoline, Left)23
- Removing And Installing Or Replacing Carbon Canister
- Removing And Installing/replacing Carbon Canister (DMTL)
- Removing And Installing / Replacing Fuel Filter With Pressure Regulator23
- 13 Fuel Ventilation › Removing And Installing/replacing Tank Leak Diagnosis Module (petrol/gasoline Ca
14 Fuel Pump10 pages
- Removing And Installing Or Replacing Fuel Pump (petrol/gasoline)234
- Removing And Installing / Replacing Fuel Filter With Pressure Regulator23
- Removing And Installing/replacing Dust Filter For Tank Leak Diagnosis Module (DM
- Removing And Installing/replacing Vent Hose With Strainer For Carbon Canister
- Removing And Installing Or Replacing Control Unit For Electric Fuel Pump
17 Cooling System (N52K)36 pages
- 10 Radiator, Expansion Tank, Pipes › Checking Cooling System For Water Leaks2
11 Engine Radiator With Attachment8 pages
- Removing And Installing Radiator (N43, N45, N46, N52, N52K, N53)
- Removing And Installing/replacing Fan Cowl With Electric Fan (N52: N52K: N53)
- Removing And Installing / Replacing Module Carrier2
- Removing And Installing/replacing Both Radiator Brackets (N54, N52, N52K, N51, N
- Removing And Installing/replacing Coolant Expansion Tank (N46, N45, N52, N52K, N
- Removing And Installing/replacing Cooling Loop For Power Steering2
21 Clutch27 pages
- 00 Maintenance And Inspections › Bleeding Clutch Hydraulics (plastic Slave Cylinder)
- 21 Clutch With Driving Disc › Removing And Installing Or Replacing Clutch (SAC 228)2345678910111213
- 51 Clutch Release Controller W. Lever › Removing And Installing Or Replacing Clutch Release Bearing/lever2345
52 Clutch Operation (hydraulic)5 pages
- 90 Troubleshooting › Troubleshooting The Clutch23
22 Engine And Gearbox Suspension12 pages
31 Transmission Suspension, Manual Transmis4 pages
32 Transmission Suspension, Autom. Transmis4 pages
23 Manual Transmission (MECH)20 pages
00 Complete Transmission18 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Draining/topping Up Gear Oil In Manual Transmission
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Overview Of Transmission Housing (GS6-17BG)
- Removing And Installing Transmission (GS6-17BZ) N51/N52/N52K/N5323456
- Installing Replacement Transmission (GS6-17BG/DG)2
- 11 Housing With Cover › Replacing Reversing Light Switch
- 14 Electrical Add-on Parts › Replacing Reversing Light Switch
24 Automatic Transmission (AUT)43 pages
00 Transmission Assembly19 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Checking/topping Up Fluid Level In Automatic Transmission (GA6L45R)2
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Adjusting Selector Lever (GA6L45R)
- Removing And Installing Automatic Transmission (GA6L45R)23456
- Installing Replacement Transmission (GA6L45R)2
- 13 Extension Housing, Bearings, Seal › Replacing Output Flange Shaft Seal (GA6L45R)23
- 14 Mechanical Attachments › Replacing Selector Shaft Seal (GA6L45R)2
- 31 Oil Pump › Replacing Torque Converter Shaft Seal (GA6L45R)2
34 Shift Valves, Parking Lock6 pages
35 Wiring Harness, Shift Elements And Senso2 pages
- 40 Torque Converter › Removing And Installing/replacing Torque Converter (GA6L45R)2
25 Gear Shift Mechanism (AUT) › 16 Centre Shift, Automatic Transmission4 pages
25 Gear Shift Mechanism (MECH) › 11 Centre Shift, Manual Transmission17 pages
- Overview Of Gearshift Mechanism For Manual Transmission
- Replacing U-gaiter
- Removing And Installing Shift Lever2
- Replacing Complete Shift Lever
- Replacing Bearing Shell For Shift Lever
- Replacing Knob For Shift Lever2
- Replacing Gaiter (shift Lever Cover) For Shift Lever
- Replacing Shift Rod
- Replacing Shift Rod Joint2
- Replacing Shift Arm For Shift-lever Mount2
- Replacing Bearing Bushes For Shift Arm
- Replacing Shift Arm Support Bearing
- Removing And Installing/replacing Vibration Damper
26 Propeller Shaft16 pages
- 00 Propeller Shaft, General › Propeller Shaft Deflection Angles
11 Propeller Shaft Assembly9 pages
27 Transfer Box › 00 Transfer Case, General3 pages
31 Front Axle61 pages
00 General11 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Front Axle Overview
- Layout Of Spring Strut Shock Absorber
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Notes On Repairing Threads2
11 Front Sub-frame14 pages
- Replacing Front Axle Carrier2
- Lowering/raising Front Axle Carrier (special Tool SWZ00-2040)23
- Lowering/raising Front Axle Carrier (universal Lifter)23
- Removing And Installing/replacing Protective Skid
- Removing And Installing/replacing V-strut, Front Axle Carrier, Left Or Right
- Removing And Installing/replacing Diagonal Strut, Front End, Left2
- Removing And Installing/replacing Diagonal Strut, Front End, Right2
21 Wheel Bearings And Stub Axle4 pages
31 Spring Strut12 pages
90 Troubleshooting3 pages
32 Steering And Wheel Alignment113 pages
00 Electronic Chassis Alignment32 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Overview Of Steering
- Overview Of Steering Wheel/casing Components
- Chassis/wheel Alignment Check Procedure
- General Chassis And Suspension Definitions
- General Information And Definitions2
- Identification Of Suspension Without Label
- Identifying Suspension From Label On Front Axle
- Information On Replacing Steering Gear After Accident Damage2
- Moving Vehicle Into Design Position
- Moving Vehicle Into Normal Position
- Performing Rim Runout Compensation
- Test Conditions For Chassis/wheel Alignment Check
- KDS Chassis/wheel Alignment Check With Load Up To Design Position23
- KDS Chassis/wheel Alignment Check With Ride-height Measurement Without Load23
- Adjusting Toe-in And Camber On Front Axle23
- Adjusting Rear Axle
- Adjustment For Active Front Steering
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Carrying Out Steering Angle Sensor Adjustment
13 Steering Gear With Servo Unit14 pages
- Information On Replacing Steering Gear After Accident Damage2
- Teaching In End Stop Software For Electric Steering Gear (EPS)
- Replacing Gaiter For Electric Steering Gear (EPS) On Left Or Right2
- Bleeding Power Steering Unit2
- Removing And Installing/replacing Power Steering Gear2
- Removing And Installing/replacing Active Front Steering Power Steering Gear23
- Removing And Installing (replacing) Electric Steering Gear (EPS)2
21 Steering Arms, Tie Rods, Steer. Damper6 pages
31 Steering Column9 pages
- Removing And Installing/replacing Upper Section Of Steering Column Trim2
- Removing And Installing / Replacing Lower Section Of Steering Column Trim
- Removing And Installing / Replacing Lower Section Of Steering Spindle2
- Removing And Installing/replacing Steering Angle Sensor
- Removing And Installing/replacing Steering Column2
- Replacing Steering Spindle Sleeve
33 Steering Wheel3 pages
34 Steering Wheel For Airbag9 pages
41 Pump And Oil Supply27 pages
- Bleeding Power Steering Unit2
- Instructions For Removing And Installing Ear Clips2
- Instructions For Using Special Tool 32 4 0002
- Notes On Hydraulic Line With Quick-connect Coupling2
- Checking Function Of Power Steering Vane Pump2
- Removing And Installing (replacing) Power Steering Pump For Power Steering Gear
- Removing And Installing Or Replacing Power Steering Vane Pump (N51, N52, N53)23
- Removing And Installing/replacing Belt Pulley On Vane Pump For Power Steering
- Removing And Installing/replacing Fluid Reservoir For Power Steering2
- Removing And Installing / Replacing Fluid Reservoir For Power Steering With Acti2
- Replacing Intake Line For Power Steering (N51, N52, N53)2
- Replacing Delivery Line For Power Steering (N51, N52, N53)2
- Replacing Cooler Return Line For Power Steering2
- Replacing Return Line For Power Steering (N51, N52, N53)2
43 Electronic Power Steering3 pages
90 Troubleshooting3 pages
33 Rear Axle109 pages
00 General17 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Rear Axle Layout
- Information On Replacing Shock Absorbers
- Notes On Repairing Threads
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Overview Of Rear Differential/output Shafts
- Overview Of Rear Axle Carrier With Rubber Mounts
- Overview Of Steering Links
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
11 Final Drive With Cover11 pages
- Replacing Rear Cover Gasket On Rear Differential (168L)
- Replacing Rear Cover Gasket On Rear Differential (188L / 188LW)
- Replacing Shaft Seal For Input Flange On Rear Differential234
- Replacing Drive Flange On Left Or Right Of Rear Differential2
- Replacing Shaft Seal For Drive Flange Left Or Right2
- Replacing Rear Cover Gasket On Rear Differential
21 Output Shafts12 pages
- Pressing Output Shaft Out Of Drive Flange And Drawing In (output Shaft Removed F23
- Ribbed Teeth
- Removing And Installing Or Replacing Left Output Shaft
- Removing And Installing / Replacing Right Output Shaft2
- Replacing Gaiter On Left Output Shaft (altered Sealing Cover)234
- Replacing Gaiter On Right Output Shaft
32 Control Arms And Struts21 pages
- Replacing Left Or Right Trailing Arm
- Replacing Rubber Mount For Trailing Arm In Wheel Carrier2
- Replacing A Rubber Mount For Trailing Arm In Rear Axle Carrier23
- Replacing One Upper Control Arm2
- Replacing A Guide Arm2
- Replacing A Ball Joint In Lower Steering Knuckle/wheel Carrier2
- Removing And Installing / Replacing A Steering Knuckle / Wheel Carrier
- Removing And Installing/replacing Left Or Right Toe Arm2
- Removing And Installing/replacing Left Or Right Camber Arm2
- Replacing Rubber Mount For Camber Arm In Rear Axle Carrier23
- Removing And Installing/replacing Left Or Right Tension Strut (on Rear Axle)
53 Springs With Suspension5 pages
- 90 Troubleshooting › Rear Axle Troubleshooting
34 Brakes94 pages
00 Brake Testing And Bleeding13 pages
- General Information2
- General Information On Braking In New Brake Discs / Brake Pads
- Checking Brakes On Test Stand
- Checking Thickness Of Brake Pad
- Parking Brake Function Check2
- Replacing Fluid In ABS/ASC-T Brake System2
- Bleeding Brake System With DSC2
- Checking Parking Brake Setting (vehicle Check For Service)
- Checking Service Brake: High- And Low-pressure Tests
11 Front Brakes15 pages
- Overview Of Front Brakes
- Removing And Installing Or Replacing Brake Pads On Both Front Disc Brakes (Teves234
- Removing And Installing Or Replacing Front Left Or Right Brake Calliper (Teves)2
- Removing And Installing Or Replacing Both Front Brake Discs2
- Removing And Installing / Replacing A Brake Carrier / Brake Guard Plate At Front
- Overhauling Left Or Right Front Brake Caliper (brake Caliper Removed)2
- Precision-turning Both Front Brake Discs On Both Sides
- Overhauling Left Or Right Rear Brake Caliper (brake Caliper Removed)2
21 Rear Brakes14 pages
- Overview Of Rear Brake
- Replacing Rear Left (or Right) Brake Carrier
- Removing And Installing Or Replacing Brake Pads On Both Rear Disc Brakes (Teves234
- Removing And Installing/replacing Both Brake Disks2
- Removing And Installing Or Replacing Rear Left Or Right Brake Calliper (Teves)23
- Overhauling Left Or Right Rear Brake Caliper (brake Caliper Removed)2
- Precision-turning Both Rear Brake Discs On Both Sides
35 Electrical Components - Wear Indicator3 pages
41 Parking Brake20 pages
- General Information On Braking In New Brake Discs / Brake Pads
- Adjusting Handbrake234
- Overview Of Handbrake
- Removing And Installing Or Replacing Gaiter For Handbrake Lever
- Removing And Installing / Replacing Handbrake Lever23
- Replacing Handle For Handbrake Lever
- Removing And Installing Or Replacing Both Handbrake Bowden Cables23
- Removing And Installing Or Replacing Guide Tube For Handbrake Cables2
- Removing And Installing/replacing All Handbrake Shoes2
- Removing And Installing/replacing Expander Lock For Handbrake Shoes2
- 51 Mechanical-hydraulic Components › Removing And Installing Or Replacing DSC Hydraulic Unit2
- 90 Troubleshooting › Troubleshooting Brake System234
35 Pedals9 pages
21 Brake Pedal With Linkage2 pages
31 Clutch Pedal With Linkage3 pages
- 40 Accelerator Pedal Actuation › Removing And Installing Or Replacing Accelerator Pedal Module
36 Wheels With Tyres34 pages
11 Disc Wheels (rims)14 pages
- CBS Reset23
- General Information On Light Alloy Disc Wheels
- Initializing Run Flat Indicator (RPA)
- Removing And Installing (replacing) RDC Control Unit
- Removing And Installing/replacing RDC Receiving Aerial
- Removing And Installing/replacing An RDC Trigger Transmitter (front)
- Resetting RDC (Tyre Pressure Control)
- Removing And Installing/replacing An RDC Trigger Transmitter (rear)
- Removing And Installing / Replacing RDC Wheel Electronics234
12 Tyres6 pages
- 13 Mounting › Subsequent Installation Of Wheel-bolt Lock
37 Integrated Suspension Systems6 pages
14 Electrical Components3 pages
41 Body (CONVER)118 pages
00 Body54 pages
- Contents Of Body, General2
- Bonding Steel Parts2
- Corrosion Protection2
- General Cementing Instructions
- Grinding Steel Parts
- Handling Airbags And Restraint Systems
- Handling Electrical And Electronic Equipment
- Information / Warning Labels
- Information On Hazards
- Information On Vehicle Protection
- Installation Of A Cavity Seal With Cavity Foam2
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
- Materials Science23
- Notes On Repairing Threads
- Opening Adhesive Bonds
- Opening Weld Joints
- Position Of Shaped Parts For Cavity Acoustic Baffle
- Quality Standard
- Riveting Aluminium Parts2
- Riveting Steel Parts
- Safety At Work2
- Spot-weld Bonding Steel Parts
- Stamping Vehicle Identification Number23
- Straightening Steel Parts2
- Use Of Materials In Outer Shell2
- Vehicle Identification Number, General
- Welding And Soldering Steel Parts23
- Welding In Reinforcement Plate (steel Plate)2
- Workshop Equipment2
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
- Notes On Cavity Foam2
11 Support Members9 pages
- Replacing Left Engine Carrier (partial Replacement Before Front Axle)
- Replacing Cover For Left Or Right Frame Side Member (partial Replacement Between2
- Replacing Front Left Or Right Support Carrier (partial Replacement, Front Side P2
- Replacing Left Inner B-pillar Reinforcement (side Panel Removed)
- Replacing Rear Left Side Panel23
- 12 Luggage Compartment Floor › Replacing Complete Rear Luggage Compartment Floor (tail Panel Removed)2
21 Side Frame And Door Pillars3 pages
- 33 Front Trim Panel › Replacing Front Wall2
- 34 Rear Trim Panel › Replacing Complete Tail Panel2
51 Front Side Doors7 pages
52 Rear Side Doors7 pages
61 Front Lid3 pages
51 Body Equipment (CONVER)339 pages
00 General10 pages
- Notes On Bonding/attaching Components With Double-sided Adhesive Tape
- Notes On Fitting Window Guide Seals2
- Safety Instructions For Working On Cars With Airbag Systems
- Overview Of Front Bumper
- Overview Of Front Bumper (M Technic Aerodynamic Kit)
- Overview Of Rear Bumper
- Overview Of Rear Bumper (M Technic Aerodynamic Kit)
- Overview Of Front Door Locks
- Overview Of Instrument Panel
11 Front Bumper19 pages
- Installing/replacing Number/license Plate (without Base)
- Overview Of Front Bumper
- Overview Of Front Bumper (M Technic Aerodynamic Kit)
- Removing And Installing/replacing Front Cover For Headlight Washer System On Lef
- Removing And Installing/replacing Cover Cap On Spray Nozzle For Headlight Washer2
- Removing And Installing/replacing Carrier For Front Bumper Trim2
- Removing And Installing/replacing Left Or Right Spoiler On Bumper Trim (M Techni
- Removing And Installing/replacing Front Bumper Trim2
- Removing And Installing/replacing Front Bumper Trim (M Technic Aerodynamic Kit)23
- Replacing Baseplate For License Plate
- Removing And Installing / Replacing Trim Grille In Bumper Trim
- Removing And Installing/replacing Trim Grille In Bumper Trim (M Technic Aerodyna
- Removing And Installing/replacing Grille In Bumper Trim On Left Or Right
- Removing And Installing/replacing Left Or Right Trim Grille In Bumper Trim (M Te
12 Rear Bumper12 pages
- Overview Of Rear Bumper
- Overview Of Rear Bumper (M Technic Aerodynamic Kit)
- Removing And Installing/replacing Lower Cover On Rear Bumper
- Replacing Rear Bumper Trim (M Technic Aerodynamic Kit)
- Removing And Installing/replacing Carrier For Rear Bumper Trim
- Removing And Installing/replacing Rear Bumper Trim2
- Removing And Installing/replacing Rear Bumper Trim (M Technic Aerodynamic Kit)2
- Removing And Installing/replacing Rear Bumper Lower Trim (M Technic Aerodynamic
- Replacing Bracket For Rear Bumper At Left Or Right
- Removing And Installing/replacing Guide For Rear Centre Bumper
13 Trim, Covers, Handle Trim43 pages
- Removing And Installing/replacing Front Cover For Headlight Washer System On Lef
- Replacing Front Radiator Grill, Middle Left Or Right2
- Removing And Installing/replacing Front Radiator Grille, Middle Left Or Right
- Removing And Installing / Replacing Cowl Panel Cover2
- Removing And Installing/replacing Trim Strip On Roof Gutter At Left Or Right
- Removing And Installing/replacing Trim For Gearshift
- Removing And Installing/replacing Trim For Storage Compartment At Rear2
- Removing And Installing Center Armrest2
- Removing And Installing/replacing Cover For Centre Armrest2
- Removing And Installing/replacing Trim For Preselector Lever
- Replacing A Clip-mounted Trim (decorative Strip On Instrument Panel Trim)2
- Removing And Installing Or Replacing Trim Cover For Glove Compartment
- Removing Window Cavity Cover Strip With Special Tool 00 9 324 At Front Or Rear2
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo2
- Removing And Installing/replacing Cover On Outside Handle
- Removing And Installing/replacing Cover On Outside Handle With Lock Cylinder
- Removing And Installing Or Replacing Window Cavity Cover Strip On Outside Of Lef2
- Removing And Installing/replacing Window Cavity Cover Strip On Inner Front Door2
- Removing And Installing/replacing Button For Rear Lid Actuation
- Removing And Installing/replacing Retaining Strip For Cowl Panel Cover
- Replacing Speaker Cover On Left Or Right Door Trim Panel
- Removing And Installing Or Replacing Cover On Door Handle, Front Left Or Right
- Removing And Installing/replacing Side Trim Panel, Footwell, On A-pillar, Left
- Removing And Installing Or Replacing Trim For Roof Pillar At Front (A-pillar), L
- Replacing Side Cover On Instrument Panel2
- Removing And Installing/replacing Upper Cross-member Cover
- Removing And Installing Or Replacing Front Air Outlet Trim Grille
- Removing And Installing / Replacing Finishing Strip At Front Left Or Right Entra
- Replacing Footrest For Front Passenger Compartment2
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover (rear Sec
- Removing And Installing/replacing Rear Left Or Right Wheel Arch Cover
16 Mirrors-covers-ashtrays-shelves-trays55 pages
- Calibrating Compass In Interior Rearview Mirror
- Cementing Of Mirror Base2
- Removing And Installing/replacing Inside Corner Trim On Front Door
- Removing And Installing/replacing Mounting For Cup Holder At Front
- Removing And Installing/replacing Trim For Gearshift
- Removing And Installing/replacing Trim For Storage Compartment At Rear2
- Removing And Installing Or Replacing Mirror On Left Or Right Front Door2
- Replacing Mirror Glass2
- Removing And Installing/replacing Housing On Left Or Right Door Mirror
- Removing And Installing Or Replacing Retaining Ring On Left Or Right Door Mirror2
- Removing And Installing/replacing Interior Rearview Mirror (overview)2
- Removing And Installing/replacing Interior Rearview Mirror (with Japanese Toll M23
- Removing And Installing/replacing Interior Rearview Mirror (with Mirror Arm End23
- Removing And Installing/replacing Interior Rearview Mirror (with Rain Sensor)23
- Removing And Installing Or Replacing Sun Visor And Left Or Right Counter-support
- Replacing Ashtray Insert
- Removing And Installing Center Armrest2
- Removing And Installing/replacing Cover For Centre Armrest2
- Removing And Installing Storage Compartment23
- Replacing Storage Compartment
- Removing And Installing/replacing Trim For Preselector Lever
- Replacing A Clip-mounted Trim (decorative Strip On Instrument Panel Trim)2
- Removing And Installing/replacing Glovebox Lock
- Removing And Installing/replacing Lock Cylinder For Glovebox2
- Removing And Installing/replacing Lock Cylinder For Passenger Airbag Deactivatio2
- Removing And Installing Or Replacing Trim Cover For Glove Compartment
- Replacing Right Glovebox
- Removing And Installing/replacing Glovebox Lid2
- Removing And Installing Right Glovebox With Housing2
- Removing And Installing/replacing Damper For Glovebox
- Removing And Installing/replacing Front Roofliner Trim2
- Removing And Installing (replacing) Centre Trim For Instrument Panel2
17 Lids17 pages
- Replacing Cover Bowl234
- Removing And Installing/replacing Trim Strip On Convertible Top Compartment Lid2
- Removing And Installing/replacing Bump Stop With Ejector For Filler Flap
- Adjusting Hood/bonnet Lock
- Removing And Installing/replacing Right Hood/bonnet Lock
- Adjusing/replacing Striker On Hood/bonnet
- Removing And Installing/replacing Arrester Hook On Engine Hood
- Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
- Adjusting Rear Lid Lock (lower Section Of Rear Lid Lock)2
- Removing And Installing/replacing Rear Lid Lock (upper Section)
- Removing And Installing/replacing Striker For Rear Lid Lock
- Removing And Installing Or Replacing Left Or Right Gas Strut For Rear Lid
- 20 Lock Cylinders, Assembly › Removing And Installing/replacing Lock Cylinder For Passenger Airbag Deactivatio2
21 Front Door Locks, Handles, Fittings27 pages
- Removing Window Cavity Cover Strip With Special Tool 00 9 324 At Front Or Rear2
- Overview Of Front Door Locks
- Replacing Door Detent (lock Striker), Front Left Or Right
- Adjusting Front Left Or Right Door Detent (lock Wedge)
- Removing And Installing/replacing Door Lock In Left Or Right Front Door23
- Removing And Installing/replacing Carrier For Left Or Right Outside Door Handle2
- Removing And Installing/replacing Carrier For Left Or Right Outside Door Handle
- Removing And Installing/replacing Complete Lock Cylinder In Left Or Right Front
- Replacing Locks For Simultaneous Closing With CAS Control Unit
- Blocking, If Necessary Initializing, Car Key In Immobilizer Control Module
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo2
- Removing And Installing/replacing Cover On Outside Handle
- Removing And Installing/replacing Cover On Outside Handle With Lock Cylinder
- Removing And Installing Or Replacing Inside Door Opener In Left Or Right Front D
- Removing And Installing/replacing Bowden Cable For Outside Door Handle On Left O
- Removing And Installing/replacing Bowden Cable For Inside Door Opener On Left Or
- Removing And Installing Or Replacing Door Brake On Left Or Right Front Door2
- Removing And Installing Or Replacing Window Cavity Cover Strip On Outside Of Lef2
- Removing And Installing/replacing Window Cavity Cover Strip On Inner Front Door2
23 Hood Latch, Locks11 pages
- Adjusting/replacing Bump Stops2
- Adjusting Hood/bonnet Lock
- Removing And Installing/replacing Right Hood/bonnet Lock
- Adjusing/replacing Striker On Hood/bonnet
- Removing And Installing/replacing Arrester Hook On Engine Hood
- Removing And Installing/replacing Cable For Hood/bonnet Lock (in Engine Compartm2
- Removing And Installing/replacing Cable For Hood/bonnet Lock (to Interior)2
- Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
24 Trunk Latch, Locks8 pages
- Adjusting Rear Lid Lock (lower Section Of Rear Lid Lock)2
- Removing And Installing/replacing Lock Element (lock Cylinder) For Rear Lid2
- Removing And Installing/replacing Rear Lid Lock (upper Section)
- Removing And Installing/replacing Striker For Rear Lid Lock
- Removing And Installing/replacing Button For Rear Lid Actuation
- Removing And Installing Or Replacing Left Or Right Gas Strut For Rear Lid
31 Front And Rear Window19 pages
- Instructions On Gluing Windscreen23456789
- Removing And Installing/replacing Retaining Strip For Cowl Panel Cover
- Removing Windscreen With /Roll Out 20002345
- Removing And Installing / Replacing Windscreen
- Repairing Damage To Windscreens Caused By Pitting (stone Chips) (clear And Tinte
- Removing And Installing/replacing Rubber Frame For Windscreen
- Removing And Installing/replacing Sound Insulation On Cowl Panel/windscreen
32 Front Manually Operated Windows3 pages
33 Front Electrically Operated Windows3 pages
37 Electrical Power Windows, Body7 pages
41 Front Door Trim Panel With Arm Rest13 pages
- Removing And Installing/replacing Window Cavity Cover Strip On Inner Front Door2
- Replacing Speaker Cover On Left Or Right Door Trim Panel
- Removing And Installing (replacing) Front Left Or Right Door Trim Panel23
- Removing And Installing Or Replacing Cover On Door Handle, Front Left Or Right
- Removing And Installing Or Replacing Door Handle On Door Trim Panel, Front Left2
- Removing And Installing (replacing) Armrest On Door Trim Panel, Front Left Or Ri2
- Removing And Installing/replacing Sound Insulation In Left Or Right Front Door2
43 Side Covering With Armrests12 pages
- Removing And Installing (replacing) Rear Left Or Right Side Trim Panel
- Removing And Installing Rear Left Or Right Side Trim Panel Upper Section2
- Replacing Rear Left Or Right Side Trim Panel Upper Section2
- Removing And Installing/replacing Rear Left Or Right Lower Side Trim Section2
- Removing And Installing/replacing Armrest On Rear Left Or Right Side Trim Panel2
- Removing And Installing/replacing Side Trim Panel, Footwell, On A-pillar, Left
- Removing And Installing / Replacing Side Trim Panel, Footwell, On A-pillar, Righ
- Removing And Installing Or Replacing Trim For Roof Pillar At Front (A-pillar), L
45 Instrument Cluster Trim Panel15 pages
- Overview Of Instrument Panel
- Replacing Side Cover On Instrument Panel2
- Removing And Installing Instrument Panel Trim2
- Replacing Instrument Panel Trim2
- Removing And Installing Trim For Instrument Panel, Bottom Left2
- Removing And Installing/replacing Bottom Right Trim For Instrument Panel
- Removing And Installing/replacing Panel For Pedals
- Removing And Installing Or Replacing Outer Trim Cover On Lower Left Dashboard Tr
- Removing And Installing (replacing) Outer Trim On Right Glovebox
- Removing And Installing (replacing) Centre Trim For Instrument Panel2
46 Parcel Shelf Trim Pan.-roller Sun Blind5 pages
- Removing And Installing/replacing Upper Cross-member Cover
- Removing And Installing/replacing Trim On Air Outlet Grille
- Removing And Installing Or Replacing Front Air Outlet Trim Grille
- Removing And Installing/replacing Trim For Belt Guide On Left Or Right
- Removing And Installing/replacing Top Trim On Rear Apron
47 Floor-lugg.comp.-eng.comp.tr.panels19 pages
- Removing And Installing / Replacing Side Trim Panel, Footwell, On A-pillar, Righ
- Removing And Installing/replacing Left Or Right Underbody Panelling
- Removing And Installing/replacing Lip On Underbody Panelling On Left Or Right
- Removing And Installing/replacing Rear Left Or Right Ram-air Lip
- Removing And Installing/replacing Rear Left Or Right Underbody Panelling
- Removing And Installing/replacing Upper Luggage Compartment Trim Panel
- Removing And Installing/replacing Front (inside) Left Or Right Entrance Cover St
- Removing And Installing / Replacing Finishing Strip At Front Left Or Right Entra
- Removing And Installing/replacing Luggage Compartment Floor Trim Panel
- Removing And Installing/replacing Panel For Luggage Compartment Partition
- Removing And Installing/replacing Left Luggage Compartment Wheel Arch Trim
- Removing And Installing/replacing Right Luggage Compartment Wheel Arch Trim2
- Replacing Footrest For Front Passenger Compartment2
- Removing And Installing / Replacing Front Carpet For Passenger Compartment
- Removing And Installing Or Replacing Rear Carpet On Seat Pan
- Removing And Installing / Replacing Front Underbody Protection
- Removing And Installing/replacing Rear Underbody Protection
- 49 Rear Lid Trim Panel › Removing And Installing/replacing Panel For Rear Lid
61 Reinforcement, Body9 pages
- Removing And Installing/replacing Front Rollover Protection System Strut
- Removing And Installing/replacing Protective Skid
- Removing And Installing/replacing V-strut, Front Axle Carrier, Left Or Right
- Removing And Installing/replacing Diagonal Strut, Front End, Left2
- Removing And Installing/replacing Diagonal Strut, Front End, Right2
- Removing And Installing/replacing Tension Strut On Left Or Right Spring Strut Do2
71 Gaskets-seals, Loose Body Components17 pages
- Removing And Installing / Replacing Cowl Panel Cover2
- Replacing Front Left Or Right Rubber Guide For Left Or Right Door Window
- Removing And Installing/replacing Cover For Carbon Canister
- Removing And Installing/replacing Radiator Seal2
- Replacing Convertible Top Compartment Lid Seal
- Removing And Installing / Replacing Seal On Front Door, Left Or Right
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover (front Se
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover (rear Sec
- Removing And Installing/replacing Rear Left Or Right Wheel Arch Cover
- Removing And Installing/replacing Cowl Panel Seal
- Removing And Installing/replacing Tension Strut On Left Or Right Spring Strut Do2
- Removing And Installing Or Replacing Panel For Cover On Left Or Right Side Membe2
- Removing And Installing/replacing Left Or Right Tension Strut (on Rear Axle)
52 Seats150 pages
13 Front Seat, Normal, Manual26 pages
- Replacing Guide Sleeves For Front Left Or Right Head Restraint
- Removing And Installing Left Or Right Front Seat (normal / Manual)2
- Removing And Installing / Replacing Flexmat On Left Or Right Front Seat
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat2
- Removing And Installing/replacing Release Mechanism On Left Or Right Front Seat23
- Removing And Installing/replacing Outer Cover On Left Or Right Front Seat Backre2
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Head Restraint
- Replacing Seat Cover On Left Or Right Front Seat (normal/manual)234
- Replacing Backrest Cover For Left Or Right Front Seat (normal / Manual)23
- Replacing Left Or Right Support For Front Seat (normal / Manual)
- Replacing Left Or Right Support For Front Seat Backrest (normal / Manual)
- Replacing Heating Elements For Left Or Right Front Seat (basic)2
- Performing Function Check With Adapter Cable (for Seat Repairs)
14 Front Seat, Normal, Electric32 pages
- Replacing Guide Sleeves For Front Left Or Right Head Restraint
- Removing And Installing Left Or Right Front Seat (normal / Manual)2
- Removing And Installing / Replacing Flexmat On Left Or Right Front Seat
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat2
- Removing And Installing/replacing Release Mechanism On Left Or Right Front Seat23
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Head Restraint
- Replacing Seat Cover On Left Or Right Front Seat (normal/manual)234
- Replacing Backrest Cover For Left Or Right Front Seat (normal / Manual)23
- Replacing Left Or Right Support For Front Seat (normal / Manual)
- Replacing Left Or Right Support For Front Seat Backrest (normal / Manual)
- Replacing Heating Elements For Left Or Right Front Seat (basic)2
- Performing Function Check With Adapter Cable (for Seat Repairs)
- Removing And Installing Carrier For Outer Cover On Left Or Right Front Seat (ele
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (norma23
- Removing And Installing/replacing Lumbar Cushion On Front Seat2
- Removing And Installing/replacing Valve Housing For Lumbar Cushion2
15 Front Seat, Sports, Manual36 pages
- Replacing Guide Sleeves For Front Left Or Right Head Restraint
- Removing And Installing Left Or Right Front Seat (normal / Manual)2
- Removing And Installing / Replacing Flexmat On Left Or Right Front Seat
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat2
- Removing And Installing/replacing Release Mechanism On Left Or Right Front Seat23
- Removing And Installing/replacing Outer Cover On Left Or Right Front Seat Backre2
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Head Restraint
- Performing Function Check With Adapter Cable (for Seat Repairs)
- Removing And Installing/replacing Thigh Support On Left Or Right Front Seat (spo2
- Removing And Installing Or Replacing Lumbar Cushion On Front Seat2
- Removing And Installing / Replacing Valve Housing For Lumbar Support / Backrest2
- Replacing An Air Cushion For Left Or Right Backrest Width Adjustment2
- Removing And Installing/replacing Thigh Support Cover On Front Seat (sport/manua
- Replacing Padding For Left Or Right Front Seat (sport/manual)
- Replacing Padding For Left Or Right Thigh Support (sport/manual)
- Replacing Padding For Left Or Right Front Seat Backrest (sport/manual)
- Replacing Heating Elements For Left Or Right Front Seat (sport / Manual)2
- Replacing Seat Cover For Left Or Right Front Seat (sports/electric)234
- Replacing Backrest Cover On Front Left Or Right Seat (sports/electric)23
16 Front Seat, Sports, Electric40 pages
- Replacing Guide Sleeves For Front Left Or Right Head Restraint
- Removing And Installing Left Or Right Front Seat (normal / Manual)2
- Removing And Installing / Replacing Flexmat On Left Or Right Front Seat
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat2
- Removing And Installing/replacing Release Mechanism On Left Or Right Front Seat23
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Head Restraint
- Performing Function Check With Adapter Cable (for Seat Repairs)
- Removing And Installing Carrier For Outer Cover On Left Or Right Front Seat (ele
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (norma23
- Removing And Installing/replacing Lumbar Cushion On Front Seat2
- Removing And Installing / Replacing Valve Housing For Lumbar Support / Backrest2
- Removing And Installing/replacing Thigh Support Cover On Front Seat (sport/manua
- Replacing Padding For Left Or Right Front Seat (sport/manual)
- Replacing Padding For Left Or Right Thigh Support (sport/manual)
- Replacing Padding For Left Or Right Front Seat Backrest (sport/manual)
- Replacing Heating Elements For Left Or Right Front Seat (sport / Manual)2
- Removing And Installing Thigh Support On Left Or Right Front Seat (sport/electri2
- Replacing An Air Cushion For Left Or Right Backrest Width Adjustment2
- Removing And Installing/replacing Valve Housing For Lumbar Cushion2
- Replacing Seat Cover For Left Or Right Front Seat (sports/electric)234
- Replacing Backrest Cover On Front Left Or Right Seat (sports/electric)23
24 Rear Seat, Normal16 pages
- Removing And Installing/replacing Ski Bag With Casing On Rear Seat
- Removing And Installing / Replacing Rear Seat
- Removing And Installing/replacing Rear Seat Backrest
- Removing And Installing Or Replacing Backrest Frame
- Removing And Installing Or Replacing Left Or Right Rear Head Restraint
- Replacing Seat Cover For Rear Seat2
- Replacing Backrest Cover For Rear Seat Backrest2
- Replacing Padding For Rear Seat
- Removing And Installing Filler Element
- Replacing Filler Element Cover23
- Replacing Left Or Right Guide Sleeves2
54 Slide-tilt Sunroof And Convertible Top (CONVER)14 pages
61 General Electrical System214 pages
00 Troubleshooting20 pages
- Instructions On Starting Aid
- Battery
- Diagnosis For Condition Based Service234
- Notes On Handling Optical Fibers
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- General Information On Intelligent Battery Sensor (IBS)
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Treating Cables And Fibre-optic Cables
- Performing Battery /power Reset: (for Programming/coding Control Unit(s))
- 11 Wiring Harness › Notes On Handling Wiring Harnesses And Cables
12 Auxiliary Cable14 pages
- General Information On Intelligent Battery Sensor (IBS)
- Replacing Battery Positive Lead
- Replacing Battery Positive Lead (from Luggage Compartment Connector To Engine Bu23
- Replacing Battery Negative Lead
- Replacing Wiring Harness In Left Or Right Front Door2
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
13 Plug Connection, Terminal, Fuse Box56 pages
- Notes On Handling Optical Fibers
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Butt Connector For Repairing A Plug Connection234
- Crimping Stop Parts234
- DME Master Relay Connector
- Installing Fan Connector For Retrofitting/repairs2345
- Special Tools For Wiring Harness Repairs23
- Unlocking And Disconnecting Different Plug Connections23
- Base Of Tab Connector Housings
- Crimping Micro Power Quadlock Contacts (MPQ)
- Crimping Micro Quadlock System Contacts (MQS)2
- Crimping Annular Contacts
- Crimping Optical Fibres2
- Cutting Off, Stripping Insulation And Cutting Optical Fibres To Length23
- Cutting To Length And Stripping Insulation From Cables
- In-line Plugs, 30-pin, Hybrid System MQS/MPQ2
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Plug Housing, LCC Contact (load Current Contact)2
- Relay Carrier
- Removing And Installing/replacing OBD-II Socket2
- Removing And Installing/replacing Fibre-optic Cable Connector2
- Repairing Ribbon Cables
- Retaining Bracket
- Socket Housing (radio Plug), Hybrid System MQS/MPQ23
- Treating Cables And Fibre-optic Cables
- Removing And Installing Or Replacing Fuse Box In Passenger Compartment (built Af2
- Removing And Installing/replacing USB/audio Interface Connecting Socket
14 Distribution Box, Power Support Points4 pages
20 Battery19 pages
- Instructions For Disconnecting And Connecting Battery23
- Instructions On Starting Aid
- Battery
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- General Information On Intelligent Battery Sensor (IBS)
- Threshold Values For Battery Inspection Of All Battery (telephone Except For Tel
- AGM Battery234
- Battery Charging
- Battery Open-circuit Current Test
- Disconnecting And Connecting Battery Negative Lead2
- Performing Battery /power Reset: (for Programming/coding Control Unit(s))
21 Battery-vapour Separator3 pages
31 Switch38 pages
- Overview Of Switches
- Removing And Installing/replacing Fixture For Steering Column Stalk2
- Removing And Installing/replacing Volute Spring Cassette2
- Removing And Installing/replacing Start/Stop Switch
- Removing And Installing/replacing Light Control Unit2
- Removing And Installing (replacing) Switch For Passenger Airbag Deactivation
- Removing And Installing Or Replacing Roof Switch Centre2
- Removing And Installing (or Replacing Version Without CCC) Centre Console Switch
- Removing And Installing (or Replacing Version With CCC) Centre Console Switch Cl
- Removing And Installing/replacing Switch For Hazard Warning Flashers/central Loc
- Removing And Installing/replacing Switch For Unlocking Rear Lid
- Removing And Installing/replacing Switch For Longitudinal Seat Adjustment
- Removing And Installing/replacing Switch For Backrest Width Adjustment
- Removing And Installing/replacing Both Shift Paddles For Automatic Transmission
- Replacing (removing And Installing) Rocker Switch For Side Window Operation (fro2
- Replacing Front Passenger Power Window Switch
- Removing And Installing/replacing AV Connection Socket
- Removing And Installing/replacing USB/audio Interface Connecting Socket
- Replacing Knob For Controller
- Removing And Installing (replacing) Front Controller23
- Replacing Switch Combination For Seat Adjustment
- Removing And Installing/replacing Switch For Front Lumbar Support
- Removing And Installing/replacing Both Switches On Sport Steering Wheel
- Removing And Installing/replacing Engine Hood Contact Switch
- Replacing Switch For Door Mirror
- Replacing Switch For Reversing Light
- Removing And Installing/replacing Clutch Switch Module
- Replacing Brake Light Switch
- Replacing Coolant Level Switch
- Replacing Level Switch For Windscreen Washer System
- Carrying Out Steering Angle Sensor Adjustment
- 33 Horn › Removing And Installing/replacing A Fanfare Horn
- 34 Insert Holder For Cigarette Lighter › Removing And Installing Or Replacing Socket Outlet In Luggage Compartment2
35 ECUs, Modules31 pages
- Removing And Installing/replacing Control Unit For Active Front Steering2
- Notes On ESD Protection (Electro Static Discharge)23
- Overview Of Control Units
- Removing And Installing (replacing) Trailer Module2
- Removing And Installing (replacing) Control Unit For Car Access System2
- Removing And Installing/replacing Control Unit/module For Left Or Right Seat Adj2
- Removing And Installing/replacing Control Unit/module For Seat Heating
- Removing And Installing Or Replacing Junction Box Electronics
- Removing And Installing/replacing Footwell Module
- Removing And Installing/replacing Convertible Top Module
- Removing And Installing (replacing) Rain/light Sensor2
- Initializing Rain/light Sensor
- Removing And Installing (replacing) Control Unit For Comfort Access System
- Removing And Installing/replacing Interior Antenna For Comfort Access System (fr
- Removing And Installing/replacing Interior Antenna For Comfort Access System (re
- Removing And Installing/replacing Rear Luggage Compartment Antenna For Comfort A
- Removing And Installing/replacing Bumper Antenna For Comfort Access System
- Replacing Fogging Sensor2
- Removing And Installing (replacing) Rollover Controller
- Removing And Installing (replacing) USB Hub
- Removing And Installing (replacing) Hands-free Charging Electronics (High)2
- Vehicle Programming And Coding
36 Relays2 pages
61 Windscreen Wipers10 pages
- Adjusting Left Or Right Windscreen Wiper23
- Overview Of Windscreen Wiper And Washer System
- Checking/adjusting Contact Angle Of Windscreen Wiper Arms On Windscreen2
- Replacing Both Windscreen Wiper Blades
- Removing And Installing/replacing Both Windscreen Wiper Arms2
- Removing And Installing Or Replacing Bracket For Windscreen Wiper System Complet
- 62 Rear Window Wiper › Overview Of Windscreen Wiper And Washer System
67 Headlight Washer System7 pages
- Overview Of Windscreen Wiper And Washer System
- Removing And Installing/replacing Washer Pump Of Headlight Washer System
- Removing And Installing/replacing Spray Nozzles For Left Or Right Headlight Clea2
- Removing And Installing/replacing Spray Nozzles (nozzle Heads) Of Headlight Wash
- Removing And Installing/replacing High-pressure Nozzle (housing) Of Headlight Wa2
- 62 Instruments › 11 Instrument Cluster › Removing And Installing (replacing) Instrument Cluster
63 Lights61 pages
12 Headlights19 pages
- Removing And Installing/replacing Left Headlight
- Removing And Installing/replacing Right Headlight
- Removing And Installing Or Replacing Left Headlight (xenon Headlight)2
- Removing And Installing Right Headlight (xenon Headlight)
- Removing And Installing Or Replacing Left Headlight (adaptive Headlight)
- Removing And Installing/replacing Right Headlight (adaptive Headlight)
- Replacing Control Unit For Left Xenon Headlight (from 03/2007)
- Replacing Control Unit For Right Xenon Headlight
- Replacing Ignition Unit For Left Xenon Headlight (with Xenon Bulb) (from 03/20072
- Replacing Ignition Unit For Right Xenon Headlight (with Xenon Bulb) (from 03/2002
- Replacing Drive Unit For Left Adaptive Headlight (after 03/2007)2
- Replacing Drive Unit For Right Adaptive Headlight (from 03/2007)2
- Removing And Installing/replacing Left Headlight Vertical Aim Adjuster
- Removing And Installing/replacing Right Headlight Vertical Aim Adjuster
- 13 Turn Signal Indicator Lights › Removing And Installing/replacing Front Left Or Right Auxiliary Direction Indica
17 Fog Lights, Auxiliary Lights2 pages
- 25 Brake Lights › Removing And Installing/replacing Auxiliary Brake Light
- 26 Licence Plate Lights › Removing And Installing/replacing Left Or Right Number/license Plate Light
31 Interior Lights7 pages
- Overview Of Interior Lights
- Removing And Installing/replacing Footwell Light (footwell)
- Removing And Installing/replacing Mirror Light
- Removing And Installing/replacing Luggage Compartment Light
- Removing And Installing/replacing Glovebox Light
- Removing And Installing/replacing Door Handle Light On Left Or Right Front Door2
99 Light Bulbs21 pages
- Instructions For Handling Light Bulbs (exterior Lights)
- Instructions For Replacing Light Bulbs (interior Lights)
- Replacing Halogen Bulb For Left (or Right) High-beam Headlight
- Replacing Halogen Bulb For Left (or Right) Headlight
- Replacing Bulb For Left (or Right) Xenon Headlight (with Ignition Unit)
- Replacing Bulb For Front Left (or Right) Side Light (after 03/2007)
- Replacing Bulb For Front Left (or Right) Side Lights (xenon) (from 03/2007)
- Replacing Bulb For Front Left (or Right) Turning Lights
- Replacing Halogen Bulb For Left Or Right Front Fog Lamp
- Replacing Halogen Bulb For Left Or Right Fog Light (M-package/aerodynamics Packa
- Replacing Bulb For Turn Indicator, Front Left
- Replacing Bulb For Turn Indicator, Front Right
- Replacing Bulb For Auxiliary Direction Indicator, Front Left Or Right
- Replacing Light Bulb(s) For Left Or Right Rear Light2
- Replacing Bulb(s) For Ceiling Light (roof Switch Centre)
- Replacing Light Bulb For Footwell Light2
- Replacing Bulb(s) For Mirror Light
- Replacing Light Bulb For Luggage Compartment Lighting
- Replacing Bulb For Glovebox Light
64 Heating And Air Conditioning99 pages
11 Heater With Operation37 pages
- Installing Servodrive
- Removing And Installing/replacing Heater2345
- Replacing Heater Core2
- Removing And Installing/replacing Heater/air Conditioner Fan
- Replacing Controller For Heater/air Conditioner Fan
- Removing And Installing/replacing Auxiliary Water Pump2
- Removing And Installing Or Replacing Heater/air Conditioner Operator Unit (versi23
- Removing And Installing Or Replacing Heater/air Conditioner Operator Unit (versi23
- Removing And Installing/replacing Servodrive For Fresh-/recirculated-air Flap
- Replacing Servodrive For Ventilation Flaps (automatic A/C)
- Replacing Servodrive For Footwell Flap (automatic A / C)2
- Removing And Installing / Replacing Servodrive For Central Kinematics (heater -2
- Removing And Installing/replacing Servodrive For Blending Flap (left)2
- Removing And Installing/replacing Servodrive For Blending Flap (left)2
- Removing And Installing/replacing Servodrive For Blending Flap (right, Automatic2
- Removing And Installing/replacing Ventilation Temperature Sensor
- Removing And Installing/replacing Footwell Temperature Sensor
- Replacing Evaporator Temperature Sensor
- Replacing Fogging Sensor2
- Removing And Installing/replacing Sensor For Automatic Recirculated Air Control
- Removing And Installing Or Replacing Solar Sensor
50 Air Conditioning System14 pages
- Air Conditioner Test (R 134a)
- Instructions For Handling Refrigerant R 134a
- Instructions For Handling Refrigerant Oil (for Refrigerant R 134a)2
- Leak Testing With Ultraviolet Additives (UV Additives) (BMW Leak-testing Case)23
- Safety Instructions For Handling Refrigerant R134a
- Safety Instructions For Handling Refrigerant Oil2
- Drawing Off, Evacuating And Filling A/C System (R 134a)2
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
53 Condenser And Dryer With Lines18 pages
- Leak-testing Condenser23
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
- Notes On Replacing Drier Bottle Or Drier Insert
- Replacing Desiccant Insert For A/C System2
- Replacing Safety Pressure Switch2
- Removing And Installing Or Replacing Condenser For A/C System2
- Replacing Line From Compressor To Condenser (N52K)2
- Replacing Line From Evaporator To Compressor (N52K)2
- Replacing Line From Evaporator To Condenser (N52K)2
65 Audio, Navigation And Information System56 pages
13 Speaker And Cover4 pages
- Removing And Installing/replacing Speaker (tweeter In Quarterlight Mirror)
- Removing And Installing/replacing Speaker (mid-range Speaker In Door Trim Panel
- Removing And Installing/replacing Speaker (tweeter In Rear Side Trim Panel)
- Removing And Installing/replacing Speaker (mid-range Speaker, Rear Side Trim Pan
20 Aerial-antenna9 pages
- Removing And Installing/replacing Aerial Rod
- Removing And Installing/replacing Aerial Base2
- Removing And Installing/replacing Aerial Amplifier (rod Aerial)
- Removing And Installing/replacing Aerial Amplifier (diversity)
- Removing And Installing/replacing Back-up Aerial
- Removing And Installing/replacing Rear Telephone Aerial
- Removing And Installing/replacing Bumper Aerial (FM)2
- 50 Video And TV Equipment › Removing And Installing/replacing Central Information Display
77 Airbag Trigger Device, Diagnosis Unit17 pages
- Overview Of Control Units
- Notes On Scrapping BMW Vehicles With Gas Generators (central Airbag Control Unit2
- Overview Of Sensors For Airbag System
- Removing And Installing/replacing Airbag Control Unit2
- Removing And Installing Seat Position Sensor For Left Or Right Front Seat
- Replacing Sensor Mat For Front Passenger Seat Occupancy Detector2
- Replacing Sensor Mat For Front Passenger Seat Occupancy Detector (sport Seat)2
- Removing And Installing (replacing) Left B-pillar Sensor
- Removing And Installing/replacing Right B-pillar Sensor
- Removing And Installing (replacing) Left Front Door Sensor2
- Removing And Installing (replacing) Rollover Controller
- Overview Of Airbag Modules, Airbag Control Unit, Belt Tensioners
83 Car Communication Computer (CCC)13 pages
- Removing And Installing/replacing Car Communication Computer2
- Removing And Installing/replacing Fan For Car Communication Computer
- Removing And Installing/replacing Front Trim For Car Communication Computer
- Removing And Installing/replacing CD Drive For Car Communication Computer2
- Removing And Installing/replacing DVD Drive For Car Communication Computer23
- Removing And Installing/replacing Gyro Sensor Drive For Car Communication Comput2
- Replacing HIP Module For Car Communication Computer2
- 90 Navigation Systems › Removing And Installing/replacing Aerial Of Global Positioning System (GPS)
66 Distance Systems, Cruise Control12 pages
- 12 Radio-controlled Locking System › Removing And Installing/replacing Slide-in Unit For Radio Control Key
20 Park Distance Control11 pages
- Overview Of Control Units
- Removing And Installing (replacing) Control Unit (Park Distance Control)2
- Removing And Installing/replacing A Front Side Ultrasonic Transducer
- Removing And Installing/replacing An Ultrasonic Transducer At Front (inside) (Pa2
- Removing And Installing/replacing Rear Left Ultrasonic Transducer
- Removing And Installing/replacing Rear Right Ultrasonic Transducer
- Removing And Installing/replacing Rear Middle Left Ultrasonic Transducer
- Removing And Installing/replacing Rear Middle Right Ultrasonic Transducer
- Removing And Installing/replacing Front Signal Sensor (Park Distance Control)
67 Electrical Drives12 pages
11 Central Locking Unit - Unlocking Units4 pages
- 13 Mirror Adjustment › Replacing Drive Unit For Electrically Operated Left Or Right Door Mirror
- 63 Drive Unit, Headlight Wipe-wash Unit › Replacing Wiper Motor
72 Parts - Accessories (Body)41 pages
11 Seat Belts11 pages
- Safety Precautions And General Information
- Checking Automatic Safety Belt23
- Removing And Installing Or Replacing Front Seat Belt2
- Removing And Installing/replacing Front Left Or Right Lower Belt Fitting (seat B2
- Removing And Installing Or Replacing Rear Left Or Right Seat Belts2
- Overview Of Airbag Modules, Airbag Control Unit, Belt Tensioners
12 Airbag Generator-airbag Unit For Pass26 pages
- Repairing Airbag Cables2
- Safety Precautions And General Information
- Safety Regulations For Handling Components With Gas Generators2
- Deactivating Front Passenger Airbags With Key-operated Switch2
- Notes On Scrapping Vehicles With Gas Generators (airbag System)2
- Overview Of Airbag Modules, Airbag Control Unit, Belt Tensioners
- Procedure After Airbag Triggering As Result Of An Accident23
- Unlocking/locking Airbag Plug Connections234
- Removing And Installing Or Replacing Airbag Module On Passenger Side
- Removing And Installing/replacing Knee Airbag Module For Driver Protection
- Removing And Installing/replacing Knee Airbag Module For Front Passenger Protect2
- Removing And Installing Side Airbag (basic Seat)23
- Removing And Installing Side Airbag (sport Seat)2
84 Communication Systems14 pages
- 10 Cellular Telephone › Removing And Installing (replacing) USB Hub
31 Hands-free System, Microphone, Speaker2 pages
- 50 Antenna › Removing And Installing Or Replacing Bluetooth Aerial
86 Trailers107 pages
10 Loading Platform71 pages
- Body And Underbody: Checking For Corrosion And Damage
- Raising BMW Multi-trailer23
- Adjusting Brake System23
- Adjusting Spring Force Accumulator
- Disassembly Of Camlock Retaining Cam
- Disassembly Of Base Plate
- Disassembly Of Bracket On Platform Base
- Disassembly Of Front Apron
- Disassembly Of Front Protection Bar
- Disassembly Of Jockey Wheel Or Jockey Wheel Mount
- Disassembly Of Left And Right Aprons
- Disassembly Of Left And Right Lamp Housings
- Disassembly Of Left And Right Wheel Boxes
- Disassembly Of Licence Plate Mounting Plate
- Disassembly Of Loading Ramp Frame/disassembly Of Rail, Left/right
- Disassembly Of Rear Apron
- Disconnecting Plug Connection, Wiring Harness, Front/rear
- Installation Position Of BMW Lettering
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Removing Camlock Retaining Cam On Loading Ramp
- Removing Camlock Screw Cap
- Removing And Installing Or Replacing Left Or Right Coil Spring2
- Removing Bolt On Loading Ramp
- Removing Brake Shoes2345
- Removing Entry Profile Section On Loading Ramp, Left, Right And Center
- Removing Left Or Right Shock Absorber
- Removing Loading Ramp Lock2
- Removing Mounting Bracket Sealing Cap
- Removing Mounting Bracket, Center, Left And Right
- Removing Outer Pull Rod Mount, Left And Right
- Removing Overrunning Equipment/maintaining Or Replacing Guide Bush/installing Ov2345
- Removing Plastic Bush/metal Bush
- Removing Rear Supports And Bracket
- Removing Reflecting Rear Light
- Removing Rest On Loading Ramp, Left, Right And Center
- Removing Shock Absorber From Overrunning Equipment
- Removing Trailing Arm, Removing And Installing Or Replacing Mounting23
- Removing Wheel Bearing2
- Removing Wooden Rest On Loading Ramp, Left, Right And Center
- Repair Work On GFP Components With Gelcoat Surface
- Replacing 12 Volt Socket2
- Replacing Bar
- Replacing Drawbar Members, Left And Right2
- Replacing Gaiter
- Replacing Holder For Chock
- Replacing Lashing Plate And Lashing Eye
- Replacing License Plate Light
- Replacing Position Light
- Replacing Rear Light
- Troubleshooting On Multi-trailer2
21 Hood36 pages
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Adjusting Hood Pretension - Camloc Fastener With Spacers23
- Adjusting Rear Lid To Fit2
- Adjusting Rotary Striker Lock
- Adjusting Side Lid To Fit2
- Attaching/replacing BMW Badge2
- Fitting BMW Logo
- Installing Hood Seal
- Installing Rubber Roof Strip
- Installing Seal For Rear Lid And Side Lid
- Installing Sponge Rubber Seal
- Removing Ball Pivot
- Removing Centering Pin From Mounting Bracket
- Removing Gas Spring
- Removing Gas Spring Retaining Bracket
- Removing Hinge Bracket On Rear Lid
- Removing Lid
- Removing Lock Barrel
- Removing Lock Striker Fixture On Rear Lid
- Removing Plug For Inside Light2
- Removing Roof Railing
- Removing Roof Railing Adapter2
- Removing Rotary Striker Lock2
- Removing Side Lid Hinge
- Replacing Inside Light
- Replacing Inside Light Power Cable2
99 Paintwork7 pages