Seicento Factory Service Manual (1998-2010): Diagnosis
General
Engine
Transmission
Steering & suspension
Electrical
Body & interior
Diagnostics
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
Starting21 pages
- Starting
- B01 The ignition switch does not work (the vehicle does not respond at all)2
- B02 The starter motor does not work
- B10 The engine does not start in any condition23
- B11 The engine does not start easily when warm2
- B12 The engine does not start easily when cold2
- B20 The engine starts and stops immediately23
- B03 The starter motor does not work2345
- B30 The vehicle does not start2
Engine20 pages
- Engine
- D01 Engine running irregularly (hesitant)23
- D02 Engine running irregularly (missing strokes)2
- D03 Engine running irregularly (sawing)2
- D05 Engine fails to reach peak performance2
- D10 Irregular engine idle speed2
- D21 Engine stops on the move2
- D30 High engine temperature with the fan operating2
- D31 High engine temperature, without fan operation
- D35 Low engine oil pressure2
- D40 The engine stops when the vehicle is stopped
Clutch16 pages
- Clutch
- E01 Clutch does not disengage correctly
- E02 Clutch slips2
- E03 Clutch vibrates or jerks
- E04 Clutch pedal stiff2
- E10 The clutch only engages at high engine rating2
- E11 The clutch does not engage when the vehicle is pushed or coasted downhill.
- E12 The clutch does not disengage when the vehicle is moving2
- E13 The clutch does not engage when the vehicle is moving234
Handbrake3 pages
Lights14 pages
- Symptom - condition contents
- I01 Side/tailights - number plate light do not work
- I05 Dipped headlights do not work
- Diagnosis table
- I10 Direction indicators/hazard lights do not work2
- I11 Direction indicators/hazard lights do not flash
- Diagnosis table
- I16 Central brake light ("third brake light") does not work
- Reverse light does not work
- I20 Foglights do not work
- I21 Rear foglight does not work
- I50 Inside lights do not work
- I80 Headlight beam adjuster does not work
Windscreen wipers8 pages
On-board instruments19 pages
- Symptoms - conditions contents
- K01 Rev counter does not work
- K15 Clock does not work
- K20 Fuel gauge does not work
- K21 Fuel reserve warning light does not work
- Diagnosis table
- K30 Engine oil pressure gauge does not work
- Diagnosis table
- K50 E.I. fault warning light on
- K51 E.I. fault and Code warning lights both on
- Diagnosis table K52
- Diagnosis table
- K55 Code warning light off - does not run initial test
- K60 ABS fault warning light on
- K61 ABS fault warning light off - does not run initial test
- K80 Airbag fault warning light on
- K81 Airbag fault warning light off - does not run initial test
- K82 Passenger airbag warning light on
- K90 Instrument lights do not work
Window risers3 pages
- Seats › Seats
- Air bag › Symptoms - conditions contents
Noise and vibration33 pages
- Symptoms - conditions - contents
- Diagnosis table23
- S02 Engine pinging - when warm
- S05 Engine hissing
- S10 Engine whistle / utility belt noise
- S11 Engine roar
- S12 Cyclic engine roar
- S13 Engine bellowing
- S20 Gearbox / differential noise - generic
- S22 Gearbox noise - in neutral2
- S24 Gearbox noise - when cornering
- S25 Clutch noise
- S30 Brake noise - whistling, squeaking
- S40 Front noise driving on straight, smooth road
- S41 Front noise driving on rough road23
- S43 Rear noise driving on rough road2
- S45 Front noise when cornering
- Front noise at pickup23
- S55 Heater/climate control noise (passenger compartment)
- S60 Rear creaking
- S61 Dashboard creaking2
- S62 Front door creaking2
- S65 Seat creaking