7 Series E38 740d Saloon (M67): 2 Repair Instructions
Also for this vehicle: 7 Series E38 725tds (M51) SAL, 7 Series E38 728i (M52) SAL, 7 Series E38 728i (M52TU) SAL, 7 Series E38 728iL (M52) SAL, 7 Series E38 728iL (M52TU) SAL, 7 Series E38 730d (M57) SAL, 7 Series E38 730i (M60-1) SAL, 7 Series E38 730iL (M60-1) SAL, 7 Series E38 735i (M62) SAL, 7 Series E38 735iL (M62) SAL, 7 Series E38 740i (M60-2) SAL, 7 Series E38 740i (M62) SAL, 7 Series E38 740iL (M60-2) SAL, 7 Series E38 740iL (M62) SAL, 7 Series E38 750i (M73) SAL, 7 Series E38 750iL (M73) SAL, 7 Series E38 L7 (M73) SAL.
Maintenance
General
Diagnostics
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
0 Maintenance And General Data89 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Pre-delivery Check2345
- Lifting Vehicle With A Lifting Platform
- Notes On Using Repair Instructions, Technical Data, Tightening Torques
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Symbols Used And Information In Repair Instructions2
- Air Cleaner: Replacing Air Cleaner Element (shorten Replacement Interval Accordi
- Battery: Check Display (magic Eye); If Necessary, Recharge Battery
- Battery: Checking Acid Level, Topping Up With Distilled Water If Necessary
- Body And Underbody: Checking For Corrosion And Damage
- Body And Underbody: Checking For Corrosion And Damage - Except Cavities
- Brake And Clutch Hydraulic System: Checking Fluid Level, Topping Up If Necessary
- Brake Hydraulics: Checking Fluid Level, Topping Up If Necessary
- Brake Lines And Connections: Visual Inspection For Leaks, Damage And Correct Pos
- Changing Automatic Transmission Fluid
- Changing Brake Fluid
- Changing Coolant
- Changing Differential Oil
- Changing Engine Oil And Oil Filter
- Check Fuel Cooler For External Contamination, Clean If Necessary
- Checking Clutch Drive Plate For Wear
- Checking Coolant Level In Event Of Topping Up: Checking Concentration
- Checking Handbrake Lever Travel, Adjusting According To Setting Specifications I
- Checking Horn, Headlight Flashers And Hazard Warning System
- Checking Instrument And Indication Field Lighting
- Checking Instrument And Indication Field Lighting, Heater Blower
- Checking Lighting System
- Checking Roadworthiness
- Checking Steering For Zero Play Steering Tie Rods And Axle Joints, Steering Gear
- Coolant Hoses: Visual Inspection For Leaks
- Diagnostic Brief Test
- Exhaust System: Checking Condition, Mounting And Inspecting For Leaks
- Fault Memory Interrogation
- Front And (if Necessary) Rear Disk Brake Linings: Remove And Install, Check Tota
- Front And Rear Brake Linings: Checking Lining Thickness With Measuring Gauge
- Fuel Cooler: Checking For External Contamination, Cleaning If Necessary
- Fuel Lines, Fuel Tank And Fuel Hoses: Visual Inspection For Routing, Condition A
- Heating/air Conditioning: Replacing Microfilter/carbon Canister (shorten Replace
- Heating/air Conditioning: Replacing Recirculated Air Cleaner
- Information/warning Labels23
- Locking Systems: Checking Status And Function, Oiling Or Greasing If Necessary
- Microencapsulated Screws
- Oil Change In Manual Transmission
- Oil Change In Rear Differential
- Output Shafts: Checking Gaiters For Leaks
- Parking Brake: Checking Function, Adjusting/repairing As Prescribed
- Parking Brake: Checking Lining Thickness
- Power Steering/ride-height Control: Visual Inspection For Leaks, Checking Fluid
- Raising BMW Multi-trailer23
- Replacing Main Fuel Filter (if Quality Of Diesel Fuel Is Poor, Reducing Interval
- Replacing Main Fuel Filter (shortening Change Interval If Necessary In Event Of
- Resetting Service Interval Indicator According To Factory Specifications2
- Seat Belts: Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
- Steering Components: Checking For Zero Clearance, Leaks, Damage And Wear2
- Steering Fluid Reservoir: Checking Fluid Level, Topping Up If Necessary
- Transmission (all Gears): Visual Inspection For Leaks
- Tyres: Checking Inflation Pressure, Correcting If Necessary (incl
- Underbody Incl
- Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid23
- Windscreen Wash/wipe System: Checking Washer Fluid Reservoir And Spray Nozzle Ad
- Windscreen Washer System And Intensive Cleaning System: Checking Fluid Level, To
- BMW Engine Oil Service Incl2
- Checking/topping Up Oil Level In Rear Differential
- Oil Change In Automatic Transmission (A5S 310Z)2
- Oil Change In Rear Differential Incl2
- Checking Oil Level In Automatic Transmission And Topping Up If Necessary (A5S 56
- Checking/topping Up Oil Level In Automatic Transmission (A5S 310Z)
- Notes On Handling Wiring Harnesses And Cables
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
11 Engine (M67)236 pages
0 Engine, General23 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- BMW Engine Oil Service Incl2
- Checking Compression Of All Cylinders (M67)23
- Removing And Installing Engine (M67)2345678910
- Engine Identification2345
12 Cylinder Head With Cover34 pages
- Removing And Installing, Sealing Or Replacing Left Cylinder Head Cover (M67)234567
- Removing And Installing, Sealing Or Replacing Right Cylinder Head Cover (M67)2
- Removing And Installing Left Cylinder Head (M67)23456789
- Removing And Installing Right Cylinder Head (M67)234567
- Removing And Installing Both Cylinder Heads (M67)
- Replacing Left Cylinder Head Gasket (M67)
- Replacing Right Cylinder Head Gasket (M67)
- Disassembling And Assembling Left Cylinder Head (M67)23
- Disassembling And Assembling Right Cylinder Head (M67)
- Checking One Valve Guide For Wear (M67)
- Checking Cylinder Head For Water Leaks (M67)
13 Oil Sump13 pages
- Removing And Installing, Sealing Or Replacing Upper Oil Sump Section (M67)2345678
- Removing And Installing, Sealing Or Replacing Lower Oil Sump Section (M67)2
- Removing And Installing, Sealing Or Replacing Upper Oil Sump Section (M67)2
- Removing And Installing, Sealing Or Replacing Lower Oil Sump Section (M67)
- 15 Crankcase Ventilation › Replacing Oil Strainer For Engine Breather (M67)234567
21 Crankshaft With Bearing9 pages
- 22 Flywheel › Removing And Installing/replacing Flywheel (M67)2
- 23 Vibration Damper › Removing And Installing Or Replacing Vibration Damper (M67)2
- 24 Connecting Rod With Bearing › Replacing All Conrod Bearings (M67)23
25 Piston With Rings And Pin9 pages
31 Camshaft38 pages
- Layout Of Camshafts (M67)
- Checking/adjusting Timing Of Left And Right Camshafts (M67)
- Replacing Left Camshaft (M67)
- Replacing Both Camshafts On Left (M67)23456789101112
- Replacing Right Camshaft (M67)
- Replacing Both Camshafts On Right (M67)234567891011
- Replacing Both Timing Chains (M67)234
- Removing And Installing/replacing Hydraulic Chain Tensioner For Cylinders 1 - 4234
- Removing And Installing/replacing Hydraulic Chain Tensioner For Cylinders 5 - 82
- Replacing All Hydraulic Valve Compensation Elements (HVC Elements) (M67)
- 33 Rocker Arm With Bearing Mount › Replacing All Hydraulic Valve Compensation Elements (HVC Elements) (M67)
34 Valves With Springs2 pages
- 41 Oil Pump With Filter And Drive › Installing And Removing Or Replacing Oil Pump (M67)2
- 42 Oil Filter And Lines › Removing And Installing, Sealing Or Replacing Full Flow Oil Filter (M67)23456
- 43 Oil Filling, Dipstick › Removing And Installing/sealing Oil Dipstick Guide Tube (M67)2
- 51 Water Pump With Drive › Removing And Installing/replacing Water Pump (M67)2345
- 52 Fan › Removing And Installing / Replacing Fan Clutch (M67, M67TU)
- 53 Thermostat And Connections › Removing And Installing Or Replacing Coolant Thermostat (M67)23
61 Intake Manifold8 pages
62 Exhaust Manifold14 pages
- 66 Vacuum Pump › Removing And Installing/replacing Vacuum Pump (M67)2
71 Exhaust Gas Recirculation5 pages
74 El.valve For Exh. Gas Recirculation5 pages
12 Engine Electrical System (M67)63 pages
- 21 Preheating Relay › Removing And Installing/replacing Glow Plug Relays (M67)2
23 Preheater Plugs6 pages
- 32 Regulator › Replacing Voltage Regulator23
61 Oil Pressure-oil Temperature-oil Gauge3 pages
- 63 Switches And Relays › Replacing Temperature Sensor For Electronics
13 Fuel System (M67)76 pages
31 Fuel Pump With Drive And Line5 pages
53 Injection Nozzle And Lines37 pages
- Removing And Installing/replacing High-pressure Pump (M67)234
- Checking High-pressure Pump And Pressure Regulator (M67)23
- Checking Injectors (M67)23
- Arrangement Of Common Rail System (M67)
- Cleaning Injector Ducts (M67 / M57 / M57TU / M47TU)23
- Removing And Installing/replacing Pressure Accumulator Of Injection System (M67)
- Replacing All Pressure Lines (between Pressure Accumulator And Injectors) (M67)
- Replacing Pressure Line (between H.P
- Removing And Installing/replacing All Injectors In Fuel Injection System (M67)2345
- Replacing All Leakage Oil Lines (M67)23
- Removing And Installing/replacing Pressure Sensor On Fuel Rail Of Injection Syst
- Replacing Pressure Regulator Of Injection System (M67)23
- Checking Injectors (without Piezo-technology) With Return Flow Quantity Meter23
- Removing And Installing/replacing Fuel Rail Of Injection System (M67)2
- Replacing Charge-air Pressure Sensor (M67)
- Troubleshooting On Common Rail System At Excessively Low Pressure2
- 61 Electronic Control Unit › Replacing Both DDE Control Units (M67)
62 Sensor For Control Unit9 pages
- 72 Air Cleaner › Replacing Air Cleaner Insert (M 67)
- 90 Carbon Canister Ventilation › Troubleshooting On Common Rail System At Excessively Low Pressure2
16 Fuel Supply System (M67)40 pages
0 Fuel Pick-up, Cleaning System16 pages
- Fuel Supply System E38 / E39 (spark-ignition Engines)2345678
- General Function Description For Fuel Supply Systems
- Draining And Filling Fuel Tank2
- Cleaning Complete Fuel System (in Event Of Incorrect Filling Of Diesel Cars With
- Checking Fuel Tank And Tank Ventilation System For Leak-tightness2
- Checking Filler Cap Pressure Relief Valve2
12 Fuel Transfer, Sensor For Gauge9 pages
- Removing And Installing / Replacing The Sensor For The Fuel Level Gauge (right)234
- Removing And Installing / Replacing The Sensor For The Fuel Level Gauge (left)23
- Removing And Installing / Replacing Activated-carbon Filter
- Removing And Installing/replacing Activated Carbon Filter With LDP (leak Diagnos
- 13 Fuel Ventilation › Removing And Installing/replacing Activated Carbon Filter With LDP (leak Diagnos
- 14 Fuel Pump › Removing And Installing Or Replacing Fuel Pump2
17 Cooling System (M67)43 pages
- 10 Radiator, Expansion Tank, Pipes › Checking Cooling System For Water Leaks2
- 22 Oil Cooler Lines › Flushing Oil Cooler With Lines (automatic Transmission)2345
- 40 Auxiliary Electrical Fan › Removing And Installing/replacing Complete Supplementary Fan (with Fan Cowl)
51 Charge Air Cooler With Mount4 pages
18 Exhaust System (M67)22 pages
22 Engine And Gearbox Suspension11 pages
32 Transmission Suspension, Autom. Transmis3 pages
24 Automatic Transmission (AUT)81 pages
0 Transmission Assembly43 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Oil Change In Automatic Transmission (A5S 310Z)2
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Adjusting Shift Lever (A5S 310Z: A5S 440Z: A5S 560Z)
- Removing And Installing Automatic Transmission (M67 With A5S 560Z)2345678
- Installing Replacement Transmission (A5S 310Z, A5S 560Z, A5S 440Z)
- Dismantling And Assembling Automatic Transmission (A5S560Z)234567891011121314151617181920212223
- 34 Shift Valves, Parking Lock › Programming/replacing Control Unit
- 35 Wiring Harness, Shift Elements And Senso › Programming/replacing Control Unit
- 40 Torque Converter › Removing And Installing Or Replacing Torque Converter
90 Troubleshooting6 pages
25 Gear Shift Mechanism (AUT) › 16 Centre Shift, Automatic Transmission13 pages
26 Propeller Shaft10 pages
27 Transfer Box › 0 Transfer Case, General3 pages
31 Front Axle47 pages
0 General9 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Layout Of Front Axle Suspension
- Layout Of Spring Strut Shock Absorber
- 10 Front Axle Suspension › Removing And Installing Complete Front Axle (with Spring Strut Shock Absorber)23
- 11 Front Sub-frame › Replacing Front-axle Carrier23
21 Wheel Bearings And Stub Axle5 pages
90 Troubleshooting2 pages
32 Steering And Wheel Alignment100 pages
0 Electronic Chassis Alignment26 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Measuring Ride-level Height Of Vehicle
- General Chassis And Suspension Definitions
- General Information And Definitions2
- Identification Of Sport Suspension
- Identification Of Suspension Without Label
- Information On Replacing Steering Gear After Accident Damage2
- Moving Vehicle Into Design Position
- Moving Vehicle Into Normal Position
- Notes
- Performing Rim Runout Compensation
- Test Conditions For Chassis/wheel Alignment Check
- Troubleshooting After Wheel/chassis Alignment Check On Front Axle/rear Axle23
- Standard Chassis / Wheel Alignment With DIN Load23
- Adjusting Front Wheel Alignment (with KDS)
- Adjusting Rear Axle2
- Carrying Out Steering Angle Sensor Adjustment
- 11 Mechanical Steering Gear › Information On Replacing Steering Gear After Accident Damage2
31 Steering Column19 pages
- Replacing Upper Section Of Steering Column Trim2
- Removing And Installing / Replacing Lower Section Of Steering Column Trim
- Removing And Installing Or Replacing (lower) Steering Spindle2
- Removing And Installing Or Replacing Steering Angle Sensor
- Removing And Installing Complete Steering Column23
- Replacing Upper Steering Spindle Bearing2
- Replacing Lower Steering Spindle Bearing
- Replacing Adjusting Lever For Steering Column2
- Dismantling And Assembling Complete Steering Column2345
- 33 Steering Wheel › Removing And Installing Steering Wheel23
34 Steering Wheel For Airbag13 pages
- Notes On Scrapping BMW Vehicles With Gas Generators (airbag System)234
- Removing And Installing Or Replacing Airbag Unit
- Replacing Contact Ring (airbag)
- Safety Regulations For Handling Airbag System Components2
- Safety Regulations For Handling Components With Gas Generators2
- Procedure After Airbag Triggering As Result Of An Accident23
41 Pump And Oil Supply11 pages
- Instructions For Removing And Installing Ear Clips2
- Instructions For Using Special Tool 32 4 0002
- Layout Of Power Steering Unit Components And Lines
- Notes On Hydraulic Line With Quick-connect Coupling2
- Servotronic Troubleshooting
- Checking Function Of Power-steering Pump2
- Removing And Installing Vane Pump For Power Steering (M67)
- 90 Troubleshooting › Troubleshooting After Wheel/chassis Alignment Check On Front Axle/rear Axle23
33 Rear Axle133 pages
0 General16 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Rear Axle Assembly2
- Rear Differential: Assignment To Model Series
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
11 Final Drive With Cover15 pages
- Rear Differential: Assignment To Model Series
- Replacing Shaft Seal And Input Flange On Final Drive (Type K / M / G)2345
- Replacing Shaft Seal For Input Flange On Final Drive234
- Replacing Drive Flange On Left Or Right Of Final Drive2
- Replacing Shaft Seal For Drive Flange Left Or Right2
- Replacing Rear Cover Gasket On Final Drive
- 17 Final Drive Mounting › Replacing All Rubber Mounts On Front And Rear Final Drive Mounts2
- 31 Rear Sub-frame › Removing And Installing Complete Rear Axle Carrier2
32 Control Arms And Struts12 pages
- Replacing Left Or Right Push Rod/integral Link2
- Removing And Installing Or Replacing Left Or Right Swinging Arm2
- Replacing One Upper Control Arm2
- Replacing One Traction Strut
- Replacing A Ball Joint In Lower Steering Knuckle/wheel Carrier
- Removing And Installing One Steering Knuckle/wheel Carrier23
- Replacing Ball Joint In Lower Steering Knuckle/wheel Carrier (wheel Carrier Remo
- 33 Axle Mounting › Replacing Two Rubber Mounts For Rear Axle Carrier2
52 Shock Absorber8 pages
- Information On Replacing Shock Absorbers
- Arrangement Of Spring Strut Shock Absorber
- Removing And Installing Rear Left Or Right Spring Strut Shock Absorber
- Replacing Rear Left Or Right Spring Strut Shock Absorber
- Replacing Rear Left Or Right Thrust Bearing For Spring Strut / Shock Absorber
- Troubleshooting The Rear Axle And Shock Absorber23
53 Springs With Suspension5 pages
- 55 Stabiliser Bar › Removing And Installing / Replacing Rear Stabilizer
- 90 Troubleshooting › Troubleshooting The Rear Axle And Shock Absorber23
34 Brakes81 pages
0 Brake Testing And Bleeding16 pages
- General Data23
- Checking Brakes On Test Stand
- Checking Thickness Of Brake Lining
- Checking Thickness Of Brake Lining From Model Year '97
- Parking Brake Function Check
- Checking Brake Booster (low-pressure Test)
- Bleeding Brake System With ABS2
- Bleeding Brake System With ABS/ASC-T2
- Bleeding Brake System With DSC3 From 09/97, 750i/iL To 09/982
- Checking Parking Brake Setting (for Inspection)
- Checking Service Brake: High- And Low-pressure Tests
11 Front Brakes12 pages
- Removing And Installing/replacing Brake Linings On Both Front Disk Brakes234
- Removing And Installing/replacing Both Front Brake Disks2
- Removing And Installing Or Replacing Left Or Right Front Brake Caliper2
- Overhauling Left Or Right Front-brake Caliper (brake Caliper Removed)23
- Fine-grinding Both Sides Of Both Front Brake Disks (brake Disks Removed)
21 Rear Brakes10 pages
- Removing And Installing Or Replacing Brake Linings On Both Rear Disk Brakes234
- Removing And Installing Or Replacing Both Rear Brake Disks
- Removing And Installing Or Replacing Left Or Right Rear Brake Caliper2
- Overhauling Left Or Right Rear Brake Caliper (brake Caliper Removed)2
- Fine-grinding Both Sides Of Both Rear Brake Disks (brake Disks Removed)
- 50 Slip Control Systems (ABS, ASC) › Removing And Installing/replacing Transversal-acceleration Sensor DSC3 Up To 09
51 Mechanical-hydraulic Components11 pages
- Removing And Installing / Replacing ABS Hydraulic Control Unit2
- Removing And Installing Or Replacing ABS/ASC-T, DSC1, DSC2, DSC3 Hydraulic Unit23
- Removing And Installing/replacing Hydraulic Unit ABS/ASC-T, DSC3 From 09/982
- Removing And Installing Pre-boost Pump DSC32
- Removing And Installing/replacing DSC3 Precharging Pump (with Charging Piston Un
- Removing And Installing/replacing Pressure Sensor For DSC
52 Electronic Components8 pages
- Replacing Control Unit (for ABS)
- Replacing ABS/ASC-T/DSC Control Module From 09/982
- Replacing Control Module (ASC-T, DSC1, DSC2, DSC3) Up To 09/98
- Removing And Installing / Replacing Front ABS Impulse Sensor
- Removing And Installing/replacing Rear ABS Pulse Generator
- Removing And Installing/replacing Transversal-acceleration Sensor DSC3 Up To 09
- Removing And Installing/replacing Rotation Rate Sensor DSC3 From 09/98
- 90 Troubleshooting › Troubleshooting The Brake System234
35 Pedals21 pages
- 11 Pedal Mounting Block › Removing And Installing Mounting Block For Pedals
- 21 Brake Pedal With Linkage › Removing And Installing Or Replacing Brake Pedal
- 31 Clutch Pedal With Linkage › Removing And Installing / Replacing Clutch Pedal
40 Accelerator Pedal Actuation2 pages
41 Kick-down10 pages
- Removing And Installing/replacing Accelerator Pedal Module
- Replacing Adapter Plate
- Adjusting Bowden Cable For Throttle Valve Actuation
- Removing And Installing Or Replacing Foot Pedal2
- Removing And Installing Or Replacing Accelerator Pedal
- Replacing Bowden Cable For Throttle Valve Actuation23
- Replacing Kick-down Switch
51 Foot-oper. Parking Br. With Conn.comp6 pages
36 Wheels With Tyres24 pages
37 Integrated Suspension Systems19 pages
12 Rear Control And Suspension Elements4 pages
- 15 Electronic Damping Force Adjustment › Removing And Installing/replacing The Control Unit (EDC)
- 90 Troubleshooting › Troubleshooting On Level Control System2
41 Body (SAL)254 pages
0 Body90 pages
- Contents Of Body, General2
- Arrangement Of Shaped Parts On Cavity Sealing2
- Basic Comments On Handling Aluminium Components2
- Bonding Plastic Parts
- Bonding Steel Parts2
- Corrosion Protection2
- Door Joint Sizes/engine Hood And Trunk Lid23
- Embossing Chassis Number
- Frame Alignment Control Dimensions BMW 7 Series E38234567
- General Cementing Instructions
- General Information About Body Repair2
- Gluing Of Body Components
- Grinding Aluminum Parts
- Grinding Steel Parts
- Handling Airbags And Restraint Systems
- Handling Electrical And Electronic Equipment
- Information / Warning Labels
- Information On Hazards
- Information On Vehicle Protection
- Installation Of A Cavity Seal With Cavity Foam2
- Installation Of A Cavity Seal With Cavity Foam2
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
- Installing Cavity Bulkhead Cover For Side Member23
- Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
- Materials Science23
- Notes On Repairs Of Aluminium Parts2
- Opening Adhesive Bonds
- Opening Weld Joints
- Quality Standard
- Recommended Working Methods And Tools2
- Removal Of PVC Material In Repair Area
- Riveting Aluminium Parts2
- Riveting Steel Parts
- Safety At Work2
- Spot-weld Bonding Steel Parts
- Straightening Aluminium Parts2
- Straightening Steel Parts2
- Use Of Materials In Outer Shell2
- Vehicle Identification Number, General
- Welding And Soldering Steel Parts23
- Welding In Reinforcement Plate (steel Plate)2
- Welding Of Galvanized Plates
- Window And Door Seams2
- Workshop Equipment2
- Replacing Unfinished Body Shell
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
- Notes On Cavity Foam2
- General Instructions On Painting
11 Support Members33 pages
- Installing Cavity Bulkhead Cover For Side Member23
- Replacing Front Section Of Engine Support To Left Wheel Arch2345678910
- Replacing Right Engine Carrier (partial Replacement In Front Of Front Axle)23
- Replacing Front Section Of Left Engine Support2345678
- Replacing Left Or Right Side Member Cover (partial Replacement Of A-column And R23456789
- 12 Luggage Compartment Floor › Replacing Complete Rear Trunk Floor (rear Left Side Panel And Tail Panel Removed234
14 Wheel Wells29 pages
- Installation Of A Cavity Seal With Cavity Foam2
- Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
- Vehicle Identification Number, General
- Replacing Front Left Wheel Arch23456
- Replacing Outer Section Of Left Or Right Rear Wheel Housing (side Panel Removed)234567
- Replacing Complete Rear Left Wheel Arch23456789
- 33 Front Trim Panel › Replacing Front Wall234
- 34 Rear Trim Panel › Replacing Outer Section Of Rear Apron (partial Replacement)2345
35 Side Panels20 pages
61 Front Lid9 pages
51 Body Equipment (SAL)238 pages
11 Front Bumper14 pages
- Repair Solution For Replacing Lateral Insert On Bumper
- Removing And Installing Complete Front Bumper2
- Replacing Front Bumper2345
- Replacing Front Center Section (carrier) Of Bumper
- Replacing Front Bumper Trim
- Replacing Baseplate For Licence Plate
- Replacing Body Molding For Left Or Right Bumper
- Replacing Left Or Right Bracket For Front Bumper
- Replacing One Impact Absorber For Front Bumper
12 Rear Bumper9 pages
- 14 BMW Emblems, Model Emblems › Removing And Installing / Replacing Rear Model Emblem
16 Mirrors-covers-ashtrays-shelves-trays46 pages
- Cementing Of Mirror Base2
- Outside Survey Mirror Can Be Folded In
- Removing And Installing/replacing Wooden Finisher And Front Section On Cup Holde234
- Replacing Left Or Right Outside Mirror Housing
- Removing And Installing Mirror On Left Or Right Front Door
- Replacing Mirror Glass2
- Removing And Installing/replacing Interior Rearview Mirror (overview)2
- Removing And Installing/replacing Interior Rearview Mirror (with /X: Cable And P2
- Removing And Installing/replacing Interior Rearview Mirror (with Full Foot)
- Removing And Installing/replacing Interior Rearview Mirror (with Mirror Arm End23
- Removing And Installing/replacing Interior Rearview Mirror (with Rain Sensor)23
- Removing And Installing / Replacing Interior Rearview Mirror (with Remote Contro
- Removing And Installing Or Replacing Sun Visor And Left Or Right Counter Support
- Removing And Installing Center Console2345
- Replacing Oddments Tray2
- Removing And Installing/replacing Front Cup Holder23
- Removing And Installing/replacing Rear Can Holder
- Removing And Installing / Replacing Finisher For Preselector Lever
- Replacing Wooden Finishers For Storage Tray (centre Console)234
- Removing And Installing Right Glove Box2
- Removing And Installing / Removing Sun Roller Blind From Fixed Side Window On Le
- Removing And Installing Or Replacing Blind At Side Window Of Left Or Right Rear
- Removing And Installing/replacing Rear Left/right Grab Handle
- Removing And Installing Or Replacing Front Grab Handle
- 17 Lids › Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
21 Front Door Locks, Handles, Fittings16 pages
- Adjusting Front Left Or Right Door Detent (lock Wedge)
- Removing And Installing / Replacing Door Lock On Left Or Right Front Door2345
- Removing And Installing Or Replacing Lock On Left Or Right Front Door
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo23
- Removing And Installing Or Replacing Inside Door Opener In Left Or Right Front D
- Removing And Installing Or Replacing Window Recess Cover Strip On Outside Of Lef
- Removing And Installing Or Replacing Chrome Strip From Left Or Right Window Rece
- Replacing Window Recess Cover On Left Or Right Front Door
- Replacing Bulb For Outside Door Handle Light, Front Left Or Right
- Replacing Bulb For Inside Door Handle Light, Front Left Or Right
22 Rear Door Locks, Handles, Fittings8 pages
- Adjusting Rear Left Or Right Door Detent (lock Wedges)
- Removing And Installing / Replacing Outside Handle On Left Or Right Back Door23
- Removing And Installing/replacing Inside Door Opener Of Rear Left Or Right Door
- Removing And Installing/replacing Window Cavity Cover Strip On Rear Door On Left
- Replacing Bulb For Outside Door Handle Light, Rear Left Or Right
- Replacing Bulb For Inside Door Handle Light, Rear Left Or Right
24 Trunk Latch, Locks15 pages
- Information On Automatic Trunk Lid Controls (electrohydraulic)23
- Adjusting Trunk Lid Lock (upper/lower Section Of Trunk Lid Lock)
- Removing And Installing/replacing Lock (locking Cylinder) For Trunk Lid Set2
- Removing And Installing/replacing Trunk Lid Lock (upper Section Of Trunk Lid Loc2
- Removing And Installing/replacing Hydraulic Control Unit For Operating Trunk Lid23
- Removing And Installing/replacing Hydraulic Cylinder For Trunk Lid (electrohydra2
- Removing And Installing Or Replacing Left Or Right Gas Strut For Trunk Lid
- Replacing Rubber Mount On Rear Lid Lid Support
31 Front And Rear Window39 pages
- Instructions On Gluing Windscreen23456789
- Removing Windscreen With /Roll Out 20002345
- Removing And Installing Front Windscreen234567891011
- Replacing Windscreen (complete Windscreen)
- Repairing Damage To Windscreens Caused By Pitting (stone Chips) (clear And Tinte
- Removing And Installing Or Replacing Left Or Right Gutter Along Windshield
- Removing And Installing Rear Window23456789
- Replacing Rear Window (rear Window Broken)
- Replacing Rear Window (complete Rear Window)
32 Front Manually Operated Windows3 pages
- 33 Front Electrically Operated Windows › Removing And Installing Electric Window Regulator In Left Or Right Front Door23
34 Rear Manually Operated Windows9 pages
- 35 Rear Electrically Operated Windows › Removing And Installing Complete Electrical Window Regulator From Rear Left And
- 37 Electrical Power Windows, Body › Removing And Installing Complete Electrical Window Regulator From Rear Left And
42 Rear Door Trim Panel With Arm Rest8 pages
43 Side Covering With Armrests8 pages
- Removing And Installing Or Replacing Trim On Left Or Right Door Pillar (top)2
- Removing And Installing Or Replacing Trim For Left Or Right Door Pillar (bottom)2
- Removing And Installing Or Replacing Trim For Front Left Or Right Roof Pillar2
- Removing And Installing Or Replacing Trim From Rear Left Or Right Roof Pillar2
- 45 Instrument Cluster Trim Panel › Removing And Installing Dashboard Trim Panel2345
46 Parcel Shelf Trim Pan.-roller Sun Blind11 pages
- Removing And Installing/replacing Trim For Rear Parcel Shelf23
- Removing And Installing Trim For Oddments Tray (back Shelf With Rear Window Roll
- Replacing Trim For Oddments Tray (back Shelf With Rear Window Roller Blind)
- Removing And Installing Trim For Oddments Tray (back Shelf With Electric Rear Se
- Replacing Trim For Oddments Tray (back Shelf With Rear Window Roller Blind And E
- Removing And Installing Trim For Oddments Tray (back Shelf With Rear Window Roll
- Removing And Installing/replacing Rear Window Roller Blind
- Removing And Installing/replacing Rear Window Roller Blind (with Electric Rear S
- 9 Replacing Finisher For Top Of Rear Apron
47 Floor-lugg.comp.-eng.comp.tr.panels7 pages
- Romoving And Installing / Replacing The Front (inside) Left Or Right Rocker Pane
- Removing And Installing/replacing The Rear (inside) Left Or Right Rocker Panel S
- Removing And Installing/replacing Luggage Compartment Floor Trim Panel
- Removing And Installing/replacing Trunk Wheel Housing Trim, Left2
- Removing And Installing/replacing Flap In Luggage Compartment Trim, Left Or Righ2
- 49 Rear Lid Trim Panel › Removing And Installing Or Replacing Trim For Trunk Lid2
52 Seats100 pages
13 Front Seat, Normal, Manual32 pages
- Removing And Installing Left Or Right Front Seat (normal / Manual)23
- Removing And Installing / Replacing Both Seat Rails On Left Or Right Front Seat23
- Adjusting Bowden Cable For Longitudinal Adjustment Of Left Or Right Front Seat (
- Replacing Bowden Cable For Longitudinal Adjustment On Left Or Right Front Seat (
- Removing And Installing / Replacing Controls On Left / Right Front Seat (normal2
- Removing And Installing / Replacing Seat Frame On Left/right Front Seat (normal2
- Removing And Installing / Replacing Backrest Frame On Left Or Right Front Seat (
- Removing And Installing / Replacing Outer Cover On Left Or Right Front Seat Back2
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Replacing Left Or Right Lumbar Supports On Front Seat (normal: Manual)2
- Removing And Installing / Replacing Rear Panel On Left Or Right Front Seat Backr
- Removing And Installing / Replacing Front Headrest (normal: Manual)
- Replacing Seat Cover On Left Or Right Front Seat (normal: Manual)234
- Replacing Backrest Cover For Front Seat (normal/manual), Left Or Right2345
- Replacing Left Or Right Support For Front Seat (normal / Manual)
- Replacing Left Or Right Support For Front Seat Back-rest (normal / Manual)
- Removing And Installing/replacing Valve Housing For From Left Or Right Lumbar Su
14 Front Seat, Normal, Electric7 pages
- Removing And Installing Left Or Right Front Seat (normal / Electric)23
- Removing And Installing/replacing Head Restraint Support On Front Seat (normal/e
- Removing And Installing Or Replacing Front Left Or Right Head Restraints (standa
- Additional Work (normal: Electric) With Defective Drive For Longitudinal Adjustm2
16 Front Seat, Sports, Electric2 pages
17 Front Seat, Comfort39 pages
- Removing And Installing Front Seat (comfort)
- Removing And Installing Or Replacing Both Seat Rails On Left Or Right Front Seat23
- Removing And Installing / Replacing Seat Frame On Left Or Right Front Seat (comf
- Removing And Installing/replacing Drive For Active Seat, Left Or Right2345
- Removing And Installing / Replacing Backrest Frame On Left Or Right Front Seat (
- Removing And Installing / Replacing Cover On Left Or Right Front Seat (comfort)2
- Removing And Installing / Replacing Inside Cover From Left Or Right Front Seat (
- Replacing Lumbar Support Cushion On Left Or Right Front Seat (comfort)2
- Removing And Installing/replacing Top Rear Panel On Front Seat Backrest (luxury2
- Removing And Installing/replacing Top Rear Panel On Front Seat Backrest (luxury23456
- Removing And Installing/replacing Bottom Rear Panel On Front Seat Backrest (luxu
- Removing And Installing/replacing Rear Panel On Front Seat Backrest (luxury Seat
- Removing And Installing / Replacing Headrest Support On Left Or Right Front Seat2
- Removing And Installing Or Replacing Front Left Or Right Head Restraints (comfor
- Replacing Seat Cover On Left Or Right Front Seat (comfort)23
- Replacing Back-rest Cover For Front Seat (comfort) On Left Or Right Sides2345
- Replacing Padding For Left Or Right Front Seat (comfort Seat)
- Replacing Support For Left Or Right Front Seat Backrest (comfort)
25 Rear Seat, Normal, Electric14 pages
- Removing And Installing / Replacing Rear Seat (normal: Electric)
- Removing And Installing / Replacing Left Or Right Side Section Of Rear Seat Back
- Removing And Installing / Replacing Backrest For Rear Seat (normal: Electric)2
- Removing And Installing / Replacing Headrest Support (normal / Electric) At Rear
- Removing And Installing / Replacing Rear Left Or Right Headrest (normal: Electri
- Replacing Back-rest Cover For Left Or Right Rear Seat (normal/electric)2
- Removing And Installing / Replacing Backrest Frame From Left Or Right Rear Seat2
- Removing And Installing / Replacing Transmission For Rear Seat Backrest (normal2
- Replacing Lumbar Support Cushion On Left Or Right Rear Seat (normal: Electric)
- Removing And Installing / Replacing Valve Housing On Lumbar Support For Rear Sea
- 26 Rear Seat, Through-loading › Replacing Seat Cover For Rear Seat (through-loading System)
54 Slide-tilt Sunroof And Convertible Top (SAL)65 pages
- 10 Sunroof › Repair Instructions For Bonded Seals23
12 Mechanical Sun Roof Components59 pages
- Notes On Steel And Glass Slide/tilt Sunroofs (initialization/normalization/learn23
- Removing And Installing / Replacing Bearing For Wind Deflector, Left Or Right
- Removing And Installing / Replacing Float Switch For Left Or Right Gutter On Gla
- Replacing Stop On Headliner For Glass Sliding/tilting Sunroof Lid On Left Or Rig2
- Adjusting Glass Sliding/tilting Sunroof Lid23
- Adjusting Sun Roof23
- Replacing Bellows For Glass Sliding/tilting Sunroof, Left Or Right
- Removing And Installing Sun Roof Lid234
- Removing And Installing Glass Sliding/tilting Sunroof Lid234
- Replacing Glass Sliding/tilting Sunroof Lid
- Replacing Seal For Glass Sliding/tilting Sunroof Lid
- Replacing Seal For Slide/tilt Sunroof Lid
- Removing And Installing / Replacing Roof Lining Frame Mechanism For Glass Slidin23
- Replacing Arm (positioner) For Sunroof Lid2
- Removing And Installing/replacing Headliner For Sun-roof Lid2
- Removing And Installing Or Replacing Gutter Strip
- Removing And Installing/replacing Roof-lining Frame For Glass Sliding/tilting Su2
- Removing And Installing / Replacing Water Channel For Glass Sliding/tilting Sunr
- Removing And Installing Complete Sliding/tilting Sunroof (frame)2
- Removing And Installing Complete Glass Sliding/tilting Sunroof
- Replacing Control Rail For Glass Sliding/tilting Sunroof, Left Or Right234567
- Removing And Installing Both Drive Cables For Glass Sliding/tilting Sunroof Actu2345678
- Adjusting Both Drive Cables For Glass Sliding/tilting Sunroof Actuation
- Removing And Installing / Replacing Wind Deflector
- Removing And Installing / Replacing Wind Deflector For Glass Sliding/tilting Sun
- Replacing Sliding/tilting Sunroof Frame
- Replacing Glass Sliding/tilting Sunroof Frame
- 13 Electrical Sun Roof Components › Notes On Steel And Glass Slide/tilt Sunroofs (initialization/normalization/learn23
61 General Electrical System166 pages
0 Troubleshooting15 pages
- Instructions On Starting Aid
- Battery
- Notes For Cars With Twin-battery System2
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Treating Cables And Fibre-optic Cables
13 Plug Connection, Terminal, Fuse Box60 pages
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Butt Connector For Repairing A Plug Connection234
- Crimping Stop Parts234
- DME Master Relay Connector
- Installing Fan Connector For Retrofitting/repairs2345
- Special Tools For Wiring Harness Repairs23
- Unlocking And Disconnecting Different Plug Connections23
- Antenna Elbow Plug On Radio Receiver23
- Base Of Tab Connector Housings
- Crimping Micro Power Quadlock Contacts (MPQ)
- Crimping Micro Quadlock System Contacts (MQS)2
- Crimping Annular Contacts
- Crimping Optical Fibres2
- Cutting Off, Stripping Insulation And Cutting Optical Fibres To Length23
- Cutting To Length And Stripping Insulation From Cables
- Front Left Wiring Harness Repair23
- In-line Plugs, 30-pin, Hybrid System MQS/MPQ2
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Relay Carrier
- Repairing Front Right Wiring Harness2345678
- Repairing Ribbon Cables
- Retaining Bracket
- Socket Housing (radio Plug), Hybrid System MQS/MPQ23
- Treating Cables And Fibre-optic Cables
20 Battery17 pages
- Instructions For Disconnecting And Connecting Battery23
- Instructions On Starting Aid
- Battery
- Notes For Cars With Twin-battery System2
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Threshold Values For Battery Inspection Of All Battery (telephone Except For Tel
- AGM Battery234
- Battery Charging
- Battery Open-circuit Current Test
- 21 Battery-vapour Separator › Removing And Installing Battery2
31 Switch27 pages
- Removing And Installing/replacing Inclination Switch For Automatic Trunk Lid Act
- Removing And Installing/replacing Fixture For Steering Column Stalk23
- Removing And Installing/replacing Turn Indicator/headlight Dip Lever
- Removing And Installing The Ignition Switch
- Removing And Installing/replacing Steering Column Adjustment Lever2
- Removing And Installing/replacing Windshield Wiper Lever
- Removing And Installing Switch Unit In Center Console
- Replacing Switch Unit In Center Console
- Removing And Installing / Replacing Switch From Hazard Warning Lights
- Removing And Installing / Replacing Switch For Central Locking System
- Removing And Installing/replacing Switch For Automatic Trunk Lid Actuation
- Removing And Installing / Replacing Switch For Left Or Right Seat Heating
- Replacing Rocker Switch For Side-window Operation
- Replacing Switch Combination For Seat Adjustment
- Removing And Installing/replacing Switch For Front Lumbar Support
- Removing And Installing / Replacing Switch For Automatic Stability Control
- Removing And Installing / Replacing Switch For Electronic Damper Control
- Removing And Installing / Replacing Switch For Rear Window Roller Blind
- Removing And Installing / Replacing Switch For Park Distance Control
- Replacing Switch On Impact Cushion For Left Or Right Airbag
- Replacing Switch On Sports Steering Wheel On Left Or Right
- Replacing Brake-light Switch2
- Carrying Out Steering Angle Sensor Adjustment
35 ECUs, Modules16 pages
- Control Units, Switches, Relays
- Note On Replacing Codable/programmable Control Units
- Notes On ESD Protection (Electro Static Discharge)23
- Removing And Installing/replacing Rain Sensor
- Removing And Installing/replacing Control Unit For Active Seat
- Removing And Installing Or Replacing Door Module
- Initializing Rain Sensor
- Removing And Installing / Replacing Control Unit For Rear Window Sun Roller Blin
- Removing And Installing Or Replacing Sunroof Module
- Removing And Installing/replacing Ringantenna Of Electronic Immobiliser2
- Replacing Control Unit For Left Xenon Headlight
- Replacing Control Unit For Right Xenon Headlight
- Vehicle Programming And Coding
36 Relays2 pages
- 67 Headlight Washer System › Adjusting Spray Nozzles For Headlight-cleaning System
- 71 Window Washer System › Adjusting Windshield Washer Spray Nozzles2
62 Instruments3 pages
63 Lights47 pages
12 Headlights16 pages
- Removing And Installing/replacing Complete Left-hand Headlight Assembly2
- Removing And Installing Or Replacing Complete Right Headlight2
- Removing And Installing Or Replacing Lens/reflector For Left Headlight
- Removing And Installing Or Replacing Lens/reflector For Right Headlight
- Removing And Installing Or Replacing Lens With Cover Frame For Left Headlight
- Removing And Installing Or Replacing Lens With Cover Frame For Right Headlight
- Replacing Left Headlight Insert
- Replacing Right Headlight Insert
- Replacing Control Unit For Left Xenon Headlight
- Replacing Control Unit For Right Xenon Headlight
- Replacing Ignition Unit For Left Xenon Headlight
- Replacing Right Ignition Unit For Right Xenon Headlight
- Removing And Installing Or Replacing Headlight Vertical Aim Adjuster
- Removing And Installing Or Replacing Right Headlight Vertical Aim Adjuster
- 13 Turn Signal Indicator Lights › Removing And Installing/replacing Complete Front Left Or Right Turn Signal Lamp
- 17 Fog Lights, Auxiliary Lights › Removing And Installing Or Replacing Fog Lamp Insert (complete)
- 21 Rear Light Cluster › Removing And Installing Or Replacing Complete Tail Light Assembly
99 Light Bulbs19 pages
- Instructions For Handling Light Bulbs (exterior Lights)
- Instructions For Replacing Light Bulbs (interior Lights)
- Replacing Bulb For Refrigerator
- Replacing Halogen Light Bulb For Left Or Right High-beam Headlight
- Replacing Halogen Light Bulb For Left Or Right High-beam Headlight
- Replacing Lamp For Left Xenon Light
- Replacing Right Lamp For Xenon Light
- Replacing Bulb For Left Or Right Front Parking Light
- Replacing Halogen Bulb For Left Or Right Front Fog Lamp
- Replacing Bulb For Left Or Right Front Turn Indicator
- Replacing Bulb For Left Or Right Tail Light Assembly
- Replacing Bulb For Left Or Right License-plate Light
- Replacing Light Bulb(s) For Ceiling Light2
- Replacing Bulb(s) For Mirror Light
- Replacing Bulb For Outside Door Handle Light, Front Left Or Right
- Replacing Bulb For Inside Door Handle Light, Front Left Or Right
- Replacing Bulb For Outside Door Handle Light, Rear Left Or Right
- Replacing Bulb For Inside Door Handle Light, Rear Left Or Right
64 Heating And Air Conditioning125 pages
11 Heater With Operation30 pages
- Installing Servodrive
- Removing And Installing Or Replacing Heater
- Replacing Heater Core (air Conditioner Control)2
- Replacing Heater Core (air Conditioner Control)234
- Removing And Installing Or Replacing Fan For Heater And Air Conditioner (air Con
- Removing And Installing Or Replacing Blower For Heater And Air Conditioner (auto2
- Removing And Installing Or Replacing Switch For Blower On Air Conditioner
- Removing And Installing / Replacing Auxiliary Water Pump
- Replacing Water Valve For Heater234
- Replacing Front Plate (air Conditioner Control)
- Replacing Front Plate (air Conditioner Controls)
- Removing And Installing Or Replacing Pushbutton Caps From Heater Controls (air C
- Replacing Baseplate For Heater Controls
- Removing And Installing Or Replacing Regulator For Heater Blower
- Removing And Installing Heater Control
- Removing And Installing / Replacing The Rear Fan Completely23
- Removing And Installing / Replacing The Rear Fan
- Removing And Installing / Replacing The Controller For The Rear Fan
- Removing And Installing The Heater Actuater For The Rear Fan Completely
- Replacing The Heater Actuater For The Rear Fan
12 Auxil. Heater With Control Elements21 pages
- Bleeding Independant Heating (Thermo Top S)2
- Checking Function Of Independant Heating (Thermo Top S)
- Removing And Installing Complete Auxiliary Heater (Thermo Top Z/C)2
- Replacing Complete Auxiliary Heater (Thermo Top Z/C)
- Removing And Installing / Replacing Complete Heater (Thermo Top S)2
- Removing And Installing / Replacing Glow Element (Thermo Top S)2
- Removing And Installing / Replacing Flame Detector (Thermo Top S)
- Removing And Installing / Replacing Control Unit With Heat Exchanger (Thermo Top2
- Removing And Installing / Replacing Combustion Air Blower (Thermo Top S)
- Removing And Installing / Replacing Burner Insert (Thermo Top S)
- Removing And Installing / Replacing Circulation Pump (Thermo Top S)
- Removing And Installing Or Replacing Muffler
- Removing And Installing Or Replacing Fuel Pump
- Removing And Installing / Replacing Receiver/Telestart Of Independent Heating2
- Overview Of Defects For Independent Heating Thermo Top S
22 Nozzles And Outlets11 pages
- Removing And Installing / Replacing Left Fresh-air Grill2
- Removing And Installing / Replacing Right Fresh-air Grill2
- Removing And Installing / Replacing Center Fresh-air Grill (air Conditioner Cont23
- Removing And Installing / Replacing Center Fresh-air Grill (climate Control)23
- Removing And Installing / Replacing Fresh-air Grill In Rear Of Car
50 Air Conditioning System19 pages
- Air Conditioner Test (R 134a)
- Instructions For Handling Refrigerant R 134a
- Instructions For Handling Refrigerant Oil (for Refrigerant R 134a)2
- Leak Testing With Ultraviolet Additives (UV Additives) (BMW Leak-testing Case)23
- Leak-testing With Leak Tester Device2
- Safety Instructions For Handling Refrigerant R134a
- Safety Instructions For Handling Refrigerant Oil2
- Troubleshooting By Pressure Measurement (R 134a)23
- Drawing Off, Evacuating And Filling A/C System (R 134a)2
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
51 AC Housing-evaporator, Switching Elemts10 pages
- Removing And Installing / Replacing Expansion Valve (air Conditioner Control)23
- Removing And Installing / Replacing Expansion Valve (air-conditioning)2
- Removing And Installing / Replacing Expansion Valve (automatic Air Conditioner)2
- Removing And Installing / Replacing Evaporator (air Conditioner Control)
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
53 Condenser And Dryer With Lines8 pages
- Removing And Installing Cassette (condenser For Air Conditioner)23
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
- Notes On Replacing Drier Bottle Or Drier Insert
- Removing And Installing / Replacing Drier Flask For Air Conditioner
- Removing And Installing Or Replacing Condenser For Air Conditioner
99 Troubleshooting14 pages
- Fault 01 Combustion Air Blower
- Fault 02 Flame Detector
- Fault 03 Glow Plug
- Fault 04 Circulation Pump
- Fault 05 Temperature Sensor
- Fault 06 Park Heating Metering Pump
- Fault 07 Overheating Protection
- Fault 08 Burner Insert
- Fault 1
- Fault 4
- Fault 6
- Fault 6
- Overview Of Defects For Independent Heating Thermo Top S
- Reading Out Flashcode
65 Audio, Navigation And Information System45 pages
- 20 Aerial-antenna › Antenna Elbow Plug On Radio Receiver23
24 Rear Window Aerial-antenna2 pages
- 50 Video And TV Equipment › Removing And Installing/replacing Video Module For On-board Monitor (saloon)
52 Video Monitor11 pages
- Removing And Installing/replacing Cassette Drive2
- Removing And Installing Complete On-board Monitor (widescreen)
- Replacing Panel For On-board Monitor (control Panel, Widescreen)2
- Removing And Installing/replacing Housing With Drive For On-board Monitor (wides
- Removing And Installing On-board Monitor2
- Replacing Trim Panel For On-board Monitor (control Panel)
- Removing And Installing/replacing LC Display For On-board Monitor2
- 75 Anti-theft Alarm System › Removing And Installing/replacing Control Unit For Radio Interior Protection
77 Airbag Trigger Device, Diagnosis Unit5 pages
- 81 On-board Computer › Removing And Installing Or Replacing Multi-Information-Display (MID)
- 83 Car Communication Computer (CCC) › Removing And Installing/replacing Cassette Drive2
90 Navigation Systems9 pages
- Notes On Handling Navigation Computers
- Calibrating Wheels For Navigation System 1 (up To 9/97, Measured With Distance T
- Removing And Installing/replacing Navigation Computer With CD-drive
- Removing And Installing/replacing Receiver Module For Global Positioning System
- Removing And Installing Magnetic Field Sensor
- Removing And Installing/replacing Antenna For Global Positioning System (GPS)
- Replacing CD/DVD Drive For Navigation Computer23
66 Distance Systems, Cruise Control5 pages
12 Radio-controlled Locking System2 pages
- 20 Park Distance Control › Removing And Installing / Replacing A Rear Ultrasonic Converter (center)
31 Adaptive Cruise Control2 pages
67 Electrical Drives18 pages
- 32 Drive, Heating-ventilation-air Con › Removing And Installing Or Replacing Sensor Blower On Heating Controls
- 52 Transmission On Wiper System › Removing And Installing Or Replacing Contact Pressure Adjuster
- 61 Drive, Slide-tilt Sunroof-conv. Top › Removing And Installing Or Replacing Drive With Gear For Actuating Slide/tilt Su2
- 63 Drive Unit, Headlight Wipe-wash Unit › Removing And Installing Or Replacing Windshield Wiper Motor
- 65 Drive, Sun Roller Blind-sun Visor › Removing And Installing Or Replacing Drive For Sun Roller Blind23
72 Parts - Accessories (Body)68 pages
12 Airbag Generator-airbag Unit For Pass51 pages
- Repairing Airbag Cables2
- Safety Precautions And General Information
- Safety Regulations For Handling Airbag System Components2
- Safety Regulations For Handling Components With Gas Generators2
- Airbag System
- Deactivation Of Airbags234
- Procedure After Airbag Triggering As Result Of An Accident23
- Safety Regulations For Handling Airbag Modules, Airbag Components And Pyrotechni
- Scrapping Vehicles With Passenger Airbag And Pyrotechnic Belt Tensioners
- Unlocking/locking Airbag Plug Connections234
- Removing And Installing Or Replacing Airbag Module On Passenger Side2345
- Removing And Installing/replacing Airbag Module On Left Or Right Front Door23
- Removing And Installing/replacing Airbag Module On Left Or Right Rear Door2
- Removing And Installing / Replacing Left Or Right ITS Head Airbag (model Without23456789101112131415
- Removing And Installing Left Or Right ITS Head Airbag (model Fitted With Sliding
- Removing And Installing/replacing Left Or Right Head Airbag In Rear Compartment23
- Removing And Installing/replacing Left Or Right Head Airbag In Rear Compartment
84 Communication Systems9 pages
11 Transceiver, Handset-support, Card Reade7 pages
- Removing And Installing / Replacing Eject Box2
- Removing And Installing/replacing Transceiver
- Removing And Installing/replacing Interface For D-Network Car Phone
- Replacing Cordless Keypad Handset
- Removing And Installing/replacing Line Compensator (cellular Phone)
- Removing And Installing/replacing Hands-free Charging Electronics
86 Trailers107 pages
10 Loading Platform71 pages
- Body And Underbody: Checking For Corrosion And Damage
- Raising BMW Multi-trailer23
- Adjusting Brake System23
- Adjusting Spring Force Accumulator
- Disassembly Of Camlock Retaining Cam
- Disassembly Of Base Plate
- Disassembly Of Bracket On Platform Base
- Disassembly Of Front Apron
- Disassembly Of Front Protection Bar
- Disassembly Of Jockey Wheel Or Jockey Wheel Mount
- Disassembly Of Left And Right Aprons
- Disassembly Of Left And Right Lamp Housings
- Disassembly Of Left And Right Wheel Boxes
- Disassembly Of Licence Plate Mounting Plate
- Disassembly Of Loading Ramp Frame/disassembly Of Rail, Left/right
- Disassembly Of Rear Apron
- Disconnecting Plug Connection, Wiring Harness, Front/rear
- Installation Position Of BMW Lettering
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Removing Camlock Retaining Cam On Loading Ramp
- Removing Camlock Screw Cap
- Removing And Installing Or Replacing Left Or Right Coil Spring2
- Removing Bolt On Loading Ramp
- Removing Brake Shoes2345
- Removing Entry Profile Section On Loading Ramp, Left, Right And Center
- Removing Left Or Right Shock Absorber
- Removing Loading Ramp Lock2
- Removing Mounting Bracket Sealing Cap
- Removing Mounting Bracket, Center, Left And Right
- Removing Outer Pull Rod Mount, Left And Right
- Removing Overrunning Equipment/maintaining Or Replacing Guide Bush/installing Ov2345
- Removing Plastic Bush/metal Bush
- Removing Rear Supports And Bracket
- Removing Reflecting Rear Light
- Removing Rest On Loading Ramp, Left, Right And Center
- Removing Shock Absorber From Overrunning Equipment
- Removing Trailing Arm, Removing And Installing Or Replacing Mounting23
- Removing Wheel Bearing2
- Removing Wooden Rest On Loading Ramp, Left, Right And Center
- Repair Work On GFP Components With Gelcoat Surface
- Replacing 12 Volt Socket2
- Replacing Bar
- Replacing Drawbar Members, Left And Right2
- Replacing Gaiter
- Replacing Holder For Chock
- Replacing Lashing Plate And Lashing Eye
- Replacing License Plate Light
- Replacing Position Light
- Replacing Rear Light
- Troubleshooting On Multi-trailer2
21 Hood36 pages
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Adjusting Hood Pretension - Camloc Fastener With Spacers23
- Adjusting Rear Lid To Fit2
- Adjusting Rotary Striker Lock
- Adjusting Side Lid To Fit2
- Attaching/replacing BMW Badge2
- Fitting BMW Logo
- Installing Hood Seal
- Installing Rubber Roof Strip
- Installing Seal For Rear Lid And Side Lid
- Installing Sponge Rubber Seal
- Removing Ball Pivot
- Removing Centering Pin From Mounting Bracket
- Removing Gas Spring
- Removing Gas Spring Retaining Bracket
- Removing Hinge Bracket On Rear Lid
- Removing Lid
- Removing Lock Barrel
- Removing Lock Striker Fixture On Rear Lid
- Removing Plug For Inside Light2
- Removing Roof Railing
- Removing Roof Railing Adapter2
- Removing Rotary Striker Lock2
- Removing Side Lid Hinge
- Replacing Inside Light
- Replacing Inside Light Power Cable2
99 Paintwork2 pages