Scudo Factory Service Manual (1996-2006): 55 Electrical equipment
Also sold as the Peugeot Expert (1996–2006) and Citroën Jumpy (1996–2006). This manual applies to all of them.
General
Engine
Steering & suspension
Electrical
Body & interior
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
Contents2 pages
Instrument panel11 pages
- Removing-refitting
- Standard specification
- Key
- WIRING DIAGRAM (Standard specifications)2
- WIRING DIAGRAM (Luxury specification)
- Key to instrument panel connectors (luxury specification)
- Removing-refitting instrument panel frame
- Removing-refitting fuel gauge
- Removing-refitting card for diodes and intermittent switch
- Removing-refitting
Various devices12 pages
- Stalk unit
- Ignition switch key block and steering lock
- Handbrake on warning light control button
- Reversing lights switch
- ELECTRONIC IMMOBILISER (Fiat-CODE)
- Release condition
- View of Fiat-CODE control unit
- Transponder receiver (aerial)
- Car immobiliser enablement warning light2
- Removing/refitting Fiat-CODE aerial
- Tester connection
Instrument panel (99 update)14 pages
- Front view
- Instrument panel
- Instrument panel wiring diagram
- MAINTENANCE INDICATOR/MILOMETER (milometer/trip meter)
- Principle operating diagram
- Maintenance intervals above 1000 Km
- Maintenance intervals below 1000 Km
- Maintenance interval exceeded in terms of mileage
- Maintenance interval exceeded in terms of time
- Procedure for zeroing planned maintenance indicator
- Procedure for setting planned maintenance indicator
- Instrument panel
- Milometer/trip meter
- Instrument panel light dimmer
Control units (99 update)10 pages
- Junction unit in bfoo dashboard
- Control units23
- LOCATION OF FUSES AND RELAYS IN JUNCTION UNIT PSF1 (engine compartment) FOR VERSIONS WITH A.B.S.
- Wiring diagram for interior of junction unit PSF1 (engine compartment)
- LOCATION OF FUSES AND RELAYS IN JUNCTION UNIT BF01-BMF1 (engine compartment) FOR VERSIONS WITH A.B.S.
- Connectors key
- Wiring diagram for interior of junction unit BMF1 (engine compartment)
- Version without A.B.S.
Passenger compartment protection (99 update)17 pages
- Passenger compartment protection (c.p.h.)
- Diagram showing Passenger Compartment Protection connections.
- Key to components
- Engine immobilizer function
- Transponder receiver (aerial)
- Radiofrequency function
- Central locking function
- Key to components
- Door unlocking/locking conditions.
- Central locking components
- Vehicle interior lighting function2
- Signalling and replacing run down transmitter battery
- Procedure for duplicating ignition key by the owner
- Key container retaining pin
- Removing - refitting passenger compartment protection control unit
- Removing-refitting fiat-code aerial
Various devices (99 update)3 pages
Wiring diagrams113 pages
- Wiring diagrams
- NOTE The numbers in the table correspond to the electrical equipment page number in the manual
- NOTE The numbers in the table correspond to the electrical equipment page number in the manual.
- Electrical symbols
- Electrical symbols
- Electrical symbols
- Explanation of how to read wiring diagrams
- Side lights and warning light - Number plate lights
- Location of components on vehicle - Side lights - Number plate lights
- Dipped headlamps and warning light - Main beam headlamps and warning light
- Location of components on vehicle - Dipped headlamps - Main beam headlamps
- Direction indicators and warning lights - Hazard warning lights and warning light
- Location of components on vehicle - Direction indicators - Hazard warning lights
- Preparation for fog lamps - Rear fog lamps and warning light
- Location of components on vehicle - Preparation for fog lights and rear fog lamps
- Preparation for fog lamps - Rear fog lamps and warning light (without A.B.S)
- Location of components on vehicle - Preparation for fog lights and rear fog lamps without A.B.S.
- Braking lights - Reversing lights - Brake pad wear warning light
- Location of components on vehicle - Braking - Reverse - Brake pad wear
- Engine cooling fan (without air conditioning)
- Location of components on vehicle - Engine cooling fan without air conditioning
- Engine cooling fan (without air conditioning and A.B.S)
- Location of components on vehicle - Engine cooling fan without air conditioning without A.B.S.
- Two engine cooling fans (without air conditioning)
- Location of components on vehicle - Two engine cooling fans without air conditioning
- Two engine cooling fans (without air conditioning and A.B.S)
- Location of components on vehicle - Two engine cooling fans without air conditioning without A.B.S.
- Heated rear windscreen and warning light - headlamp wash/wipe
- Location of components on vehicle - Heated rear windscreen - Headlamp washer
- Heated rear windscreen and warning light - Headlamp wash/wipe (without A.B.S)
- Location of components on vehicle - Heated rear windscreen - Headlamp washer without A.B.S.
- Windscreen wash/wipe - Horn
- Location of components on vehicle - Windscreen wash/wipe - Horn
- Petrol versions
- Location of components on vehicle - Coded anti-starting
- Coded anti-starting device
- Location of components on vehicle - Coded anti-starting diesel
- Anti-lock brakes and failure warning light
- Location of components on vehicle - Anti-lock brakes
- Electric front windows
- Location of components on vehicle - Electric front windows
- Headlamp alignment device - Radio
- Location of components on vehicle - Headlamp alignment device - Radio
- Air bag and failure warning light - Pre-tensioners
- Location of components on vehicle - Air-bag - Pre-tensioners
- Pre-tensioners
- Location of components on vehicle - Pre-tensioners
- Diagnostic sockets - Additional repair cables
- Location of components - N.D. Ultrasound welding taped in cable loom
- Tow hook socket connections
- Location of components on vehicle - Tow hook socket connections
- Starting - Electronic injection and ignition - Recharging and warning light - Injection system failure warning light - I
- Location of components - Starting - Electronic injection and ignition - Recharging and warning light - Injection system
- Starting - Electronic injection and ignition - Recharging and warning light - Injection system failure warning light - I
- Location of components - Starting - Electronic injection and ignition - Recharging and warning light - Injection system
- Starting - Recharging and warning light - Heater plugs - Water in fuel filter warning light - Insufficient engine oil pr
- Location of components - Starting - Electronic injection and ignition - Recharging and warning light - Injection system
- Starting - Recharging and warning light - Heater plugs - Water in fuel filter warning light - Insufficient engine oil pr
- Location of components - Starting - Recharging and warning light - Heater plugs - Water in fuel filter warning light - I
- Starting - Recharging and warning light - Heater plugs and warning light - Diesel pump operation - Water in fuel filter
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Diesel pump operatio
- Starting - Recharging and warning light - Heater plugs and warning light - Diesel pump operation - Water in fuel filter
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Diesel pump operatio
- Starting - Recharging and warning light - Heater plugs and warning light - Cooling system cut off control unit - Diesel
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling syste
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system cut out control unit -
- Location of components - Layout of cable loom in vehicle - Components key
- Vehicle interior lights - Ideogram lights
- Location of components - Vehicle interior lights - Ideogram lights
- Engine cooling two electric fans - Water temperature gauge and overheating warning light (1581 with air conditioning)
- Location of components - Engine cooling two electric fans - Water temperature gauge and overheating warning light
- Engine cooling two electric fans - Water temperature gauge and overheating warning light (1581 with air conditioning and
- Location of components - Engine cooling two electric fans - Water temperature gauge and overheating warning light (1581
- Engine cooling two electric fans - Water temperature gauge and overheating warning light - (See key at end of wiring dia
- Location of components - Engine cooling two electric fans - Water temperature gauge and overheating warning light - (See
- Engine cooling two electric fans - Water temperature gauge and overheating warning light (1905 D - 1905 Turbo D with air
- Location of components - Engine cooling two electric fans - Water temperature gauge and overheating warning light (1905
- Heater - Vehicle interior ventilation
- Location of components - Heater - Vehicle interior ventilation
- Heater - Vehicle interior ventilation (without A.B.S)
- Location of components - Heater - Vehicle interior ventilation (without A.B.S)
- Fuel level gauge and reserve warning light - Water temperature gauge and overheating warning light - Brake pad wear warn
- Location of components - Fuel level gauge and reserve warning light - Water temperature gauge and overheating warning li
- Fuel level gauge and reserve warning light - Water temperature gauge and overheating warning light - Brake pad wear warn
- Location of components - Fuel level gauge and reserve warning light - Water temperature gauge and overheating warning li
- Central locking
- Location of components - Central locking
- Air conditioning (1581)
- Location of components - Air conditioning
- Air conditioning (1581 without A.B.S)
- Location of components - Air conditioning (1581 without A.B.S)
- Air conditioning (1995 D - 1905 Turbo D)
- Location of components - Air conditioning (1905 D - 1905 TD)
- Air conditioning
- Location of components - Air conditioning
- Panel connections (1581)
- Location of components - Panel connections
- Panel connection (1905 D - 1905 Turbo D)
- Location of components - Panel connections (1905 D - 1905 Turbo D)
- Junction unit in engine compartment PSF1
- Junction unit in engine compartment BF01 - Maxi fuse control unit BMF1
- Junction unit in dashboard BF00
- Wiring diagrams index
- Location of complete cable loom in vehicle (1581)
- Location of complete cable loom on vehicle (1905 D - 1905 Turbo D)
- Location of complete cable loom on vehicle (1905 D - 1905 Turbo D)
- Location of cable loom in dashboard
- Location of cable loom in dashboard
- Location of components - List of junction unit fuse values in dashboard BF00
- Location of components - BB00 Battery
- Location of components - Location of cable loom in dashboard
- Location of components - 8036 Temperature display
- Location of components - MC50 Right rear door connections earth
Wiring diagrams (98 range, part 1)19 pages
- Contents
- NOTE Numbers in the table correspond to page numbers in electrical eqpt section
- Starting - Electronic ignition and injection (Bosch MA 1.7) - Recharging and warning light - Injection system failure wa
- Starting - Electronic ignition and injection (Bosch MA 1.7) - Recharging and warning light - Injection system failure wa
- Starting - Recharging and warning light - Glow plug preheating and warning light - Diesel pump control device - Water in
- Starting - Recharging and warning light - Glow plug preheating and warning light - Diesel pump control device - Water in
- Starting - Recharging and warning light - Glow plug preheating and warning light - Diesel pump control device - Water in
- Starting - Recharging and warning light - Glow plug preheating and warning light - Diesel pump control device - Water in
- Starting - Recharging and warning light - Glow plug preheating and warning light - Diesel pump control device - Water in
- Starting - Recharging and warning light - Glow plug preheating and warning light - Diesel pump control device - Water in
- Air conditioner (without A.B.S)
- Air conditioner (with A.B.S)
- Air conditioner (without A.B.S)
- Air conditioner (with A.B.S)
- Fiat CODE device and warning light
- Fiat CODE device and warning light
- Fiat CODE device and warning light
- BB00 Battery
- C001L Diagnostic socket
Wiring diagrams (98 range, part 2)162 pages
- Wiring diagrams (98 range, part 2)
- Electrical symbols
- Electrical symbols
- Electrical symbols
- Explanation of how to read wiring diagrams
- Side lights and warning light - Number plate lights
- Location of components on vehicle - Side lights - Number plate lights
- Dipped headlamps and warning light - Main beam headlamps and warning light (without A.B.S)
- Location of components on vehicle - Dipped beam headlamps - Main beam head-lamps (without A.B.S)
- Dipped headlamps and warning light - Main beam headlamps and warning light (with A.B.S)
- Location of components on vehicle - Dipped beam headlamps - Main beam head-lamps (with A.B.S)
- Preparation for fog lights - Rear fog lamps and warning light
- Location of components on vehicle - Preparation for fog lights - Rear fog lamps
- Direction indicators and warning lights - Hazard warning lights and warning light
- Location of components on vehicle - Direction indicators - Hazard warning lights
- North European Version (without A.B.S)
- Location of components - North European Version
- North European Version
- Location of components - North European Version (with A.B.S)
- Brake lights - Reversing lights - Brake pad wear warning light
- Location of components on vehicle - Braking lights - Reversing lights - Brake pad wear warning light
- Engine cooling with one electric fan (without air conditioning with A.B.S)
- Location of components on vehicle - Engine cooling with one electric fan (without air conditioning with A.B.S)
- Engine cooling with one electric fan (without air conditioning and A.B.S)
- Location of components on vehicle - Engine cooling with one electric fan (without air conditioning and A.B.S)
- Engine cooling with one electric fan with restricting resistance (without air conditioning with A.B.S)
- Location of components on vehicle - Engine cooling with one fan with restricter resistance (without air conditioning wit
- Engine cooling with one fan with restricter resistance (without air conditioning and A.B.S)
- Location of components on vehicle - Engine cooling with one fan with restricter resistance (without air conditioning and
- Engine cooling with two fans (without air conditioning with A.B.S)
- Location of components on vehicle - Engine cooling with two fans (without air conditioning with A.B.S)
- Engine cooling with two fans (without air conditioning and A.B.S)
- Location of components on vehicle - Engine cooling with two fans (without air conditioning and A.B.S)
- (cont')
- (cont')
- (cont')23
- Heated rear windscreen and warning light - Headlamp washer (without A.B.S)
- Location of components on vehicle - Heated rear windscreen - Headlamp washer (without A.B.S)
- Heated rear windscreen and warning light - Headlamp washer (with A.B.S)
- Location of components on vehicle - Heated rear windscreen - Headlamp washer (with A.B.S)
- Windscreen wash/wipe - Horn
- Location of components on vehicle - Windscreen wash/wipe - Horn
- Electric front windows (without A.B.S)
- Location of components on vehicle - Electric front windows (without A.B.S)
- Electric front windows (with A.B.S)
- Location of components on vehicle - Electric front windows (with A.B.S)
- Central locking
- Location of components on vehicle - Central locking
- Electrically adjustable heated external rear view mirrors
- Location of components on vehicle - Electrically adjustable heated rear view mirrors
- Pretensioners
- Location of components on vehicle - Pretensioners
- Air bag and failure warning light - Pretensioners
- Location of components on vehicle - Air-bag and failure warning light - Pretensioners
- Headlamp alignment - Radio
- Location of components on vehicle - Headlamp alignment - Radio
- Anti-lock brakes and failure warning light
- Location of components on vehicle - Anti-lock brakes
- Heated seats (without A.B.S)
- Location of components on vehicle - Heated seats (without A.B.S)
- Heated seats
- Location of components on vehicle - Heated seats (with A.B.S)
- Acoustic device signalling excessive speed
- Location of components on vehicle - Excessive speed acoustic warning
- Acoustic device signalling side lights on
- Location of components on vehicle - Side lights on acoustic signal
- Diagnostic socket connections - Preparation of positive cables for repairs - Supply for connecting trailer
- Location of components on vehicle - Diagnostic sockets - Additional repair cables - Supply for trailer connection
- Starting - Electronic injection and ignition - Recharging and warning light - Injection system failure warning light - I
- Location of components - Starting - Electronic injection and ignition - Recharging and warning light - Injection system
- Starting - Electronic injection and ignition - Recharging and warning light - Injection system failure warning light - I
- Location of components - Starting - Electronic injection and ignition - Recharging and warning light - Injection system
- Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - Water in fuel filter warni
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - W
- Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - Water in fuel filter warni
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - W
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system interruption control un
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling syste
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system interruption control un
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling syste
- Starting - Recharging and warning light - Heater plugs - Water in fuel filter warning light - Insufficient engine oil pr
- Location of components - Starting - Recharging and warning light - Heater plugs - Water in fuel filter warning light - I
- Starting - Recharging and warning light - Heater plugs - Water in fuel filter warning light - Insufficient engine oil pr
- Location of components - Starting - Recharging and warning light - Heater plugs - Water in fuel filter warning light - I
- Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - Water in fuel filter warni
- Location of components on vehicle - Components key
- Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - Water in fuel filter warni
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - W
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system interruption control un
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling syste
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system interruption control un
- Location of components on vehicle - Components key
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system interruption control un
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling syste
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system interruption control un
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling syste
- Starting - Recharging and warning light - Heater plugs and warning light - Water in fuel filter warning light - Insuffic
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Water in fuel filter
- Starting - Recharging and warning light - Heater plugs and warning light - Water in fuel filter warning light - Insuffic
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Water in fuel filter
- Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - Water in fuel filter warni
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - W
- Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - Water in fuel filter warni
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - W
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system interruption control un
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling syste
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system interruption control un
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling syste
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system interruption control un
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling syste
- Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling system interruption control un
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Engine cooling syste
- Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - Water in fuel filter warni
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device- Wa
- Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - Water in fuel filter warni
- Location of components - Starting - Recharging and warning light - Heater plugs and warning light - Fuel pump device - W
- Engine cooling with two fans - Water temperature gauge and overheating warning light (with air conditioning with A.B.S)
- Location of components - Engine cooling with two electric fans - Water temperature gauge and overheating warning light (
- Engine cooling with two fans - Water temperature gauge and overheating warning light (with air conditioning and without
- Location of components - Engine cooling with two fans - Water temperature gauge and overheating warning light
- Engine cooling with two fans with restricter resistance - Water temperature gauge and overheating warning light (with ai
- Location of components - Engine cooling with two fans with restricter resistance - Water temperature gauge and overheati
- Engine cooling with two fans with restrictor resistance - Water temperature gauge and overheating warning light (with ai
- Location of components - Engine cooling with two fans with restricter resistance - Water temperature gauge and overheati
- Engine cooling with two fans with restricter resistance - Water temperature gauge and overheating warning light (with ai
- Location of components - Engine cooling with two fans with restricter resistance - Water temperature gauge and overheati
- Engine cooling with two fans with restricter resistance - Water temperature gauge and overheating warning light (with ai
- Location of components - Engine cooling with two fans with restricter resistance - Water temperature gauge and overheati
- Heater - Car interior ventilation (without A.B.S)
- Location of components - Heater - Car interior ventilation (without A.B.S)
- Heater - Car interior ventilation (with A.B.S)
- Location of components - Heater - Car interior ventilation
- Vehicle interior lights - Ideogram lights
- Location of components - Vehicle interior lights - Ideogram lights
- Fuel gauge and reserve warning light - Water temperature gauge and overheating warning light - Brake pad wear warning li
- Location of components - Fuel gauge and reserve warning light - Water temperature gauge and overheating warning light -
- Fuel gauge and reserve warning light - Water temperature gauge and overheating warning light - Brake pad wear warning li
- Location of components - Fuel gauge and reserve warning light - Water temperature gauge and overheating warning light -
- Fiat-CODE
- Location of components - Fuel gauge and reserve warning light - Water temperature gauge and overheating warning light -
- Fiat-CODE
- Location of components - Fiat-CODE
- Fiat-CODE
- Location of components - Fiat-CODE
- Air conditioning (without A.B.S)
- Location of components - Air conditioning (without A.B.S)
- Air conditioning (with A.B.S)
- Location of components - Air conditioning
- Air conditioning (without A.B.S)
- Location of components - Air conditioning
- Air conditioning (with A.B.S)
- Location of components - Air conditioning (with A.B.S)
- Panel connections
- Location of components on vehicle - Components key
- Panel connection
- Location of components - Panel connection
- Junction unit in PSF1 engine compartment
- Junction unit in engine compartment BF01 - Maxi fuse control unit BMF1
- Junction unit in dashboard BF00
- Diagrammatic view of location of cable looms and components
Diagrammatic views (98 range)9 pages
- Diagrammatic views
- Diagrammatic view of location of cable looms and components
- Diagrammatic views
- Diagrammatic view of location of cable looms and components
- Diagrammatic views
- Co-ordinates for components in the complete diagrammatic views from page 157 to page 161
- BB00 Battery (G5*)2
- 8220 Fiat-CODE aerial (E10*) (E7**)
- Contents (2000 range) › Contents (2000 range)23
Control module (2000 range)4 pages
Control units (2000 range)10 pages
- Positioning bridge 8 (Shunt) in junction unit BF00
- Control units
- Wiring diagram for junction unit in BF00 dashboard
- Control units
- LOCATION OF FUSES AND RELAYS IN JUNCTION UNIT PSF1 (engine compartment)2
- LOCATION OF FUSES AND RELAYS IN JUNCTION UNIT BF01 BMF1 (engine compartment) FOR VERSIONS WITH A B S
- Location of connectors in junction unit BF01 (engine compartment)
- Wiring diagram for interior of junction unit BMF1 (engine compartment)
- Version writhout A B S
Wiring diagrams (2000 update, part 1)18 pages
- Index234
- Electrical symbols
- Explanation for reading wiring diagram
- Starting – Recharging and warning light – Insufficient engine oil pressure warning light (with A.B.S)
- Starting – Recharging and warning light – Insufficient engine oil pressure warning light (without A.B.S)
- Electronically controlled diesel pump – Injection system failure warning light – Heater plugs and warning light (with ai
- Electronically controlled diesel pump – Injection system failure warning light – Heater plugs and warning light – Genera
- Electronic ignition and injection – Injection system failure warning light – Engine coolant overheating warning light –
- 55. Version with air conditioning, with A.B.S., with manual gearbox
- Electronic ignition and injection – Injection system failure warning light – Engine coolant temperature gauge – Engine c
- Electronic ignition and injection – Injection system failure warning light – Engine coolant temperature gauge – Engine c
- Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light – General failure warning
- Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light – General failure warning
- Location of components - BB00 Battery
- Location of components - Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light –
Wiring diagrams (99 range)225 pages
- Wiring diagrams (99 range)2345
- Copyright Fiat Auto2
- Waring light
- Digital speedometer, Digital rev counter, Digital fuel gauge, Analogue fuel gauge, Analogue engine coolant temperature g
- Explanation for reading wiring diagram
- Side lights - Number plate lights
- Location of components on vehicle - Side lights - No. plate lights
- Dipped headlamps and warning light – Main beam headlamps and warning light (without A.B.S)
- Location of components on vehicle - Dipped headlamps - Main beam headlamps (without A.B.S)
- Dipped headlamps and warning light – Main beam headlamps and warning light (with A.B.S)
- Location of components on vehicle - Dipped headlamps - Main beam headlamps (with A.B.S)
- Trim level: North European - Version: without A.B.S.
- Location of components - Trim level: North Eurpoean (without A.B.S)
- Trim level: North European - Version: with A.B.S.
- Location of components - Trim level: North Eurpoean (with A.B.S)
- Preparation for fog lights - Rear fog lamps and warning light
- Location of components on vehicle - Preparation for fog lights - Rear fog lamps
- Direction indicators and warning lights – Hazard warning lights and warning light
- Location of components on vehicle - Direction indicators - Hazard warning lights
- Brake lights – Reversing lights – Brake pad wear warning light
- Location of components on vehicle - Brake lights - Reversing lights - Brake pad wear warning light
- Engine cooling with one fan (without air conditioning and A.B.S)
- Location of components on vehicle – Engine cooling with one fan (without air conditioning and A.B.S)
- Engine cooling with one fan (without air conditioning and A.B.S)
- Location of components on vehicle – Engine cooling with one fan (without air conditioning with A.B.S)
- Engine cooling with one fan with restricter resistance (without air conditioning and A.B.S)
- Location of components on vehicle – Engine cooling with one fan with restricer resistance (without air conditioning and
- Engine cooling with one fan with restricter resistance (without air conditioning with A.B.S)
- Location of components on vehicle – Engine cooling with one fan with restricter resistance (without air conditioning wit
- Engine cooling with two fans (without air conditioning and A.B.S)
- Location of components on vehicle – Engine cooling with two fans (without air conditioning and A.B.S)
- Engine cooling with two fans (without air conditioning with A.B.S)
- Location of components on vehicle - Engine cooling with two fans (without air conditioning with A.B.S)
- Engine cooling with one fan (with air conditioning and A.B.S)
- Location of components on vehicle - Engine cooling with one fan (with air conditioning and A.B.S)
- Engine cooling with one fan (with air conditioning without A.B.S)
- Location of components on vehicle - Engine cooling with one fan (with air conditioning without A.B.S)
- Heated rear windscreen and warning light – Headlamp washer (without A.B.S)
- Location of components on vehicle - Heated rear windscreen - Headlamp washer (without A.B.S)
- Heated rear windscreen and warning light – Headlamp washer (with A.B.S)
- Location of components on vehicle - Heated rear windscreen - Headlamp washer (with A.B.S)
- Windscreen wash/wipe – Horn (without A.B.S)
- Location of components on vehicle - Windscreen wash/wipe - Horn (without A.B.S)
- Windscreen wash/wipe – Horn (with A.B.S)
- Location of components on vehicle - Windscreen wash/wipe - Horn (with A.B.S)
- Electric front windows (without A.B.S)
- Location of components on vehicle - Electric front windows (without A.B.S)
- Electric front windows (with A.B.S)
- Location of components on vehicle - Electric front windows (with A.B.S)
- Central locking
- Location of components on vehicle - Central locking (with C.P.H)
- Door mirrors with electric adjustment and heating
- Location of components on vehicle - Electrically adjusted, heated rear view mirrors
- Pretensioners
- Location of components on vehicle - Pretensioners
- Air bag and failure warning light – Pretensioners
- Location of components on vehicle – Air-bag and failure warning light – Pretensioners
- Headlamp alignment – Radio
- Location of components on vehicle - Headlamp alignment - Radio
- Anti-lock braking system and failure warning light
- Location of components on vehicle - Anti-lock brakes and failure warning light
- Heated seats (without A.B.S)
- Location of components on vehicle - Heated seats (without A.B.S)
- Heated seats (with A.B.S)
- Location of components on vehicle - Heated seats (with A.B.S)
- Excessive speed auditory warning signal
- Location of components on vehicle - Excessive speed auditory signal device
- Auditory device signalling side lights on (without C.P.H)
- Location of components on vehicle - Auditory device signalling side lights on (without C.P.H)
- Auditory device signalling side lights on (with C.P.H)
- Location of components on vehicle - Auditory device signalling side lights on (with C.P.H)
- Auditory device signalling side lights on (without C.P.H)
- Location of components on vehicle - Auditory device signalling side lights on (without C.P.H)
- Side lights on auditory warning signal (with C.P.H)
- Location of components on vehicle - Side lights on auditory warning signal (with C.P.H)
- Cruise Control (without A.B.S)
- Location of components - Cruise Control (without A.B.S)
- Cruise Control (with A.B.S)
- Location of components - Cruise Control (with A.B.S)
- Diagnostic socket connections - Preparation for positive contacts for repairs - Tow hook connection supply
- Location of components on vehicle - Diagnostic sockets - Preparation for positive contacts for repairs - Tow hook connec
- Starting – Electronic ignition and injection – Recharging and warning light – Injection system failure warning light – I
- Location of components - Starting – Electronic ignition and injection – Recharging and warning light – Injection system
- Starting – Electronic ignition and injection – Recharging and warning light – Injection system failure warning light – I
- Location of components - Starting – Electronic ignition and injection – Recharging and warning light – Injection system
- Starting – Recharging and warning light – Heater plugs and warning light – Diesel pump – Insufficient engine oil pressur
- Location of components on vehicle - PSF1 Junction unit (engine compartment)
- Starting – Recharging and warning light – Heater plugs and warning light – Diesel pump – Insufficient engine oil pressur
- Location of components - Starting – Recharging and warning light – Heater plugs and warning light – Diesel pump – Insuff
- Starting – Recharging and warning light – Heater plugs and warning light – Engine cooling system cut out control unit –
- Location of components - Starting – Recharging and warning light – Heater plugs and warning light – Engine cooling syste
- Starting – Recharging and warning light – Heater plugs and warning light – Engine cooling system cut out control unit –
- Location of components - Starting – Recharging and warning light – Heater plugs and warning light – Engine cooling syste
- Starting – Recharging and warning light – Heater plugs and warning light – Diesel pump – Insufficient engine oil pressur
- Location of components - Starting – Recharging and warning light – Heater plugs and warning light – Diesel pump – Insuff
- Starting – Recharging and warning light – Heater plugs and warning light – Diesel pump – Insufficient engine oil pressur
- Location of components - Starting – Recharging and warning light – Heater plugs and warning light – Diesel pump – Insuff
- Starting – Recharging and warning light – Heater plugs and warning light – Engine cooling system cut out control unit –
- Location of components - Starting – Recharging and warning light – Heater plugs and warning light – Engine cooling syste
- Starting – Recharging and warning light – Heater plugs and warning light – Engine cooling system cut out control unit –
- Location of components on vehicle - N.D. Ultrasound welding taped in cable loom
- Starting – Recharging and warning light – Electronically controlled diesel pump – Injection system failure warning light
- Location of components - Starting – Recharging and warning light – Electronically controlled diesel pump – Injection sys
- Starting – Recharging and warning light – Electronically controlled diesel pump – Injection system failure warning light
- Location of components on vehicle - PSF1 Junction unit (engine compartment)
- Starting – Recharging and warning light – Electronically controlled diesel pump – Injection system failure warning light
- Location of components - Starting – Recharging and warning light – Electronically controlled diesel pump – Heater plugs
- Starting – Recharging and warning light – Electronically controlled diesel pump – Injection system failure warning light
- Location of components - Starting – Recharging and warning light – Electronically controlled diesel pump – Injection sys
- Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (with air conditioning and
- Location of components - Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (
- Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (with air conditioning wit
- Location of components - Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (
- Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (with air conditioning wit
- Location of components - Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (
- Engine cooling with two fans – Engine coolant temperature gauge with overheating warning light (with air conditioning an
- Location of components - Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (
- Engine cooling with two fans with resistance restrictor – Engine coolant temperature gauge and overheating warning light
- Location of components - Engine cooling with two fans with resistance restrictor – Engine coolant temperature gauge and
- Engine cooling with two fans with restricter resistance – Engine coolant temperature gauge and overheating warning light
- Location of components - Engine cooling with two fans with restricter resistance – Engine coolant temperature gauge and
- Engine cooling with two fans with restricter resistance – Engine coolant temperature gauge and overheating warning light
- Location of components - Engine cooling with two fans with restricter resistance – Engine coolant temperature gauge with
- Engine cooling with two fans with restricter resistance – Engine coolant temperature gauge and overheating warning light
- Location of components - Engine cooling with two fans with restricter resistance – Engine coolant temperature gauge and
- Heater – Car interior ventilation (without A.B.S)
- Location of components - Heater – Vehicle interior ventilation (without A.B.S)
- Heater – Vehicle interior ventilation (with A.B.S)
- Location of components - Heater – Car interior fan (with A.B.S)
- Vehicle interior lighting – Ventilation - Ideogram lights (with C.P.H)
- Location of components - Vehicle interior lighting – Ideogramme lights (with C.P.H)
- Vehicle interior lighting – Ideogram lights (with C.P.H)
- Location of components - Vehicle interior lighting – Ideogram lights (with C.P.H)
- Vehicle interior lighting – Ideogram lights (without C.P.H)
- Location of components - Vehicle interior lighting – Ideogram lights (without C.P.H)
- Fiat-CODE (without C.P.H)
- Location of components - Fiat-CODE (without C.P.H)
- Fiat-CODE (with C.P.H)
- Location of components - Fiat-CODE (with C.P.H)
- Fiat-CODE (without C.P.H)
- Location of components on vehicle - BMF1 Maxi fuse control unit
- Fiat-CODE (with C.P.H)
- Location of components - Fiat-CODE (with C.P.H)
- Location of components - Fiat-CODE (without C.P.H)
- Location of components - Fiat-CODE
- Fiat-CODE (with C.P.H)
- Location of components on vehicle - N.D. Ultrasound welding taped in cable loom
- Fiat-CODE (without C.P.H)
- Location of components - Fiat-CODE (without C.P.H)
- Fiat-CODE (with C.P.H)
- Location of components - Fiat-CODE (with C.P.H)
- Fiat-CODE (without C.P.H)
- Location of components - Fiat-CODE (without C.P.H)
- Fiat-CODE (with C.P.H)
- Location of components - Fiat-CODE (with C.P.H)
- Comfort trim level
- Location of components - Comfort trim level
- Basic trim level
- Location of components - Basic trim level
- Fuel gauge and reserve warning light – Engine coolant temperature gauge and overheating warning light – Brake pad wear w
- Location of components on vehicle - BMF1 Maxi fuse control unit
- Fuel gauge and reserve warning light – Engine coolant temperature gauge and overheating warning light – Brake pad wear w
- Location of components on vehicle - N.D. Ultrasound welding taped in cable loom
- Air conditioning (without A.B.S)
- Location of components - Air conditioning (without A.B.S)
- Air conditioning (with A.B.S)
- Location of components on vehicle - PSF1 Junction unit (engine compartment)
- Air conditioning (without A.B.S)
- Location of components - Air conditioning (without A.B.S)
- Air conditioning (with A.B.S)
- Location of components - Air conditioning (with A.B.s)
- Air conditioning (without A.B.S)
- Location of components - Air conditioning (without A.B.S)
- Air conditioning (with A.B.S)
- Location of components - Air conditioning (with A.B.S)
- Maintenance indicator
- Location of components - Air conditioning (with A.B.S)
- Instrument panel connections
- Location of components - BB00 Battery
- Instrument panel connections
- Location of components - '99 range
- Instrument panel connections
- Location of components - Instrument panel connections
- Passenger compartment protection control unit connections (C.P.H.)
- Location of components - Passenger compartment protection control unit connections (C.P.H.)
- Location of components - Passenger compartment protection control unit connections (C.P.H.)
- Location of components on vehicle - N.D. Ultrasound welding taped in cable loom
- Location of components - Passenger compartment protection control unit connections (C.P.H.)
- Location of components - Passenger compartment protection control unit connections (C.P.H.)
- Fiat-CODE (right hand drive without C.P.H)
- Location of components - Fiat-CODE (right hand drive without C.P.H. Fiat-CODE)
- Fiat-CODE (right hand drive with C.P.H)
- Location of components on vehicle - N.D. Ultrasound welding taped in cable loom (right hand drive with C.P.H. Fiat-CODE)
- Fiat-CODE (right hand drive without C.P.H)
- Location of components - Fiat-CODE (right hand drive without C.P.H)
- Fiat-CODE (right hand drive with C.P.H)
- Location of components on vehicle - N.D. Ultrasound welding taped in cable loom (right hand drive with C.P.H. Fiat-CODE)
- Fiat-CODE (right hand drive without C.P.H)
- Location of components - Fiat-CODE (right hand drive without C.P.H)
- Fiat-CODE (right hand drive with C.P.H)
- Location of components - Fiat-CODE (right hand drive with C.P.H)
- Fiat-CODE (right hand drive without C.P.H)
- Location of components - Fiat-CODE (right hand drive without C.P.H)
- Fiat-CODE (right hand drive with C.P.H)
- Location of components - Fiat-CODE (right hand drive with C.P.H)
- Fiat-CODE (right hand drive without C.P.H)
- Location of components - Fiat-CODE (right hand drive without C.P.H)
- Fiat-CODE (right hand drive with C.P.H)
- Location of components - Fiat-CODE (right hand drive with C.P.H)
- Passenger compartment protection control unit connections (C.P.H.) (right hand drive)
- Location of components - Passenger compartment protection control unit connections (C.P.H.) (right hand drive)
- Passenger compartment protection control unit connections (C.P.H.) (right hand drive)
- Location of components - Passenger compartment protection control unit connections (C.P.H.) (right hand drive)
- Passenger compartent protection control unit connections (C.P.H.) (right hand drive)
- Location of components - Passenger compartment protection control unit connections (C.P.H.) (right hand drive)
- Location of components - Additional heater (without A.B.S)
- Location of components - Additional heater (without A.B.S)
- Location of components - Additional heater (with A.B.S)
- Location of components - Passenger compartent protection control unit connections (C.P.H.) (with A.B.S. Additional heate
- Perspective views
Perspective views (99 range)8 pages
- Perspective views
- Comprehensive perspective view showing location of cable loom and components
- Perspective views
- Comprehensive perspective view showing location of cable loom and components
- Perspective views
- Perspective view of facia assembly showing location of cable loom and components (right hand drive)
- BB00 Battery (G5*)
- 8043 Right vehicle interior fan control module (E9**)
Wiring diagrams (2000 update, part 2)160 pages
- Index2345
- N.B. The numbers in the table correspond to the page number of the electrical system in the manual
- Electrical symbols2
- Electrical symbols
- Explanation for reading wiring diagrams
- Dipped headlamps and warning light – Main beam headlamps and warning light (without A.B.S)
- Location of components on vehicle – Dipped headlamps – Main beam headlamps (without A.B.S)
- Dipped headlamps and warning light – Main beam headlamps and warning light (with A.B.S)
- Location of components on vehicle – Dipped headlamps – Main beam headlamps (with A.B.S)
- Trim level: North European – Version: without A.B.S.
- Location of components - Trim level: North Eurpoean (without A.B.S)
- Trim level: North European – Version: with A.B.S.
- Location of components - Trim level: North European
- Direction indicators and warning lights – Hazard warning lights and warning light
- Location of components on vehicle – Direction indicators – Hazard warning lights
- Brake lights – Reversing lights – Brake pad wear warning light
- Location of components on vehicle – Brake lights – Reversing lights – Brake pad wear warning light
- Engine cooling with one fan (without air conditioning and A.B.S)
- Location of components on vehicle – Engine cooling with one fan (without air conditioning)
- Engine cooling with one fan (without air conditioning with A.B.S)
- Location of components on vehicle – Engine cooling with one fan (without air conditioning)
- Engine cooling with one fan with restricter resistance (without air conditioning and A.B.S)
- Location of components on vehicle – Engine cooling with one fan with restricter resistance (without air conditioning and
- Engine cooling with one fan with restricter resistance (without air conditioning with A.B.S)
- Location of components on vehicle – Engine cooling with one fan with restricter resistance (without air conditioning wit
- Engine cooling with one fan (with air conditioning without A.B.S)
- Location of components on vehicle – Engine cooling with one fan (with air conditioning without A.B.S)
- Engine cooling with one fan (with air conditioning and A.B.S)
- Location of components on vehicle – Engine cooling with one fan (with air conditioning and A.B.S)
- Windscreen wash/wipe – Horn (without A.B.S)
- Location of components on vehicle – Windscreen wash/wipe – Horn (without A.B.S)
- Windscreen wash/wipe – Horn (with A.B.S)
- Location of components on vehicle – Windscreen wash/wipe – Horn (with A.B.S)
- Pretensioners
- N.A. Ultrasound welding taped in cable loom
- Air bag and failure warning light – Pretensioners
- Location of components on vehicle – Air-bag and failure warning light – Pretensioners
- Air Bag (50-way control unit) and warning light
- Location of components on vehicle – Air-bag and failure warning light – Pretensioners
- Side lights on auditory warning signal (without C.P.H)
- Location of components on vehicle – Side lights on auditory warning signal (without C.P.H)
- Side lights on auditory warning signal (with C.P.H)
- Location of components on vehicle – Side lights on auditory warning signal (with C.P.H)
- Diagnostic socket connections – Preparation for positive contacts for repairs – Tow hook connection supply (without A.B.
- Location of components on vehicle – Diagnostic sockets – Preparation for positive contacts for repairs – Tow hook connec
- Diagnostic socket connections – Preparation for positive contacts for repairs – Tow hook connection supply (with A.B.S)
- Location of components on vehicle – Diagnostic sockets – Preparation for positive contacts for repairs – Tow hook connec
- Starting – Recharging and warning light – Insufficient engine oil pressure warning light (without A.B.S.)
- Location of components on vehicle – Ignition – Recharging and warning light – Low engine oil pressure warning (without A
- Starting – Recharging and warning light – Insufficient engine oil pressure warning light (with A.B.S)
- Location of components on vehicle -Ignition – Recharging and warning light – Low engine oil pressure warning light (with
- Electronic ignition and injection – Injection system failure warning light – Engine coolant temperature gauge and overhe
- Location of components - Electronic ignition and injection – Injection system failure warning light – Engine coolant tem
- Electronic ignition and injection – Injection system failure warning light – Engine coolant temperature gauge and overhe
- Location of components - Electronic ignition and injection – Injection system failure warning light – Engine coolant tem
- Electronic ignition and injection – Injection system failure warning light – Engine coolant temperature gauge and overhe
- Location of components - Electronic ignition and injection – Injection system failure warning light – Engine coolant tem
- Electronic ignition and injection – Injection system failure warning light – Engine coolant temperature gauge and overhe
- Location of components - Electronic ignition and injection – Injection system failure warning light – Engine coolant tem
- Version: without A.B.S. (with automatic transmission)
- Location of components - Version: without A.B.S. (with automatic transmission)
- Version: with A.B.S. (with automatic transmission)
- Location of components - Version: with A.B.S. (with automatic transmission)
- Starting – Recharging and warning light – Insufficient engine oil pressure warning light – Heater plugs and warning ligh
- Location of components - Starting – Recharging and warning light – Heater plugs and warning light – Diesel pump control
- Starting – Recharging and warning light – Insufficient engine oil pressure warning light – Heater plugs and warning ligh
- Location of components - Starting – Recharging and warning light – Heater plugs and warning light – Diesel pump control
- Starting – Recharging and warning light – Insufficient engine oil pressure warning light – Heater plugs and warning ligh
- Location of components - Starting – Recharging and warning light – Heater plugs and warning light – Engine cooling syste
- Starting – Recharging and warning light – Insufficient engine oil pressure warning light – Heater plugs and warning ligh
- Location of components - Starting – Recharging and warning light – Heater plugs and warning light – Engine cooling syste
- Electronically controlled diesel pump – Heater plugs and warning light – Injection system failure warning light (without
- Location of components on vehicle - Electronically controlled diesel pump – Heater plugs and warning light – Injection s
- Electronically controlled diesel pump – Heater plugs and warning light – Injection system failure warning light (with A.
- Location of components - Electronically controlled diesel pump – Injection system failure warning light – Heater plugs a
- Electronically controlled diesel pump – Heater plugs and warning light – Water in fuel filter warning light – Speedomete
- Location of components - Electronically-controlled diesel pump device – Injection system failure warning light – Heater
- Electronically controlled diesel pump – Heater plugs and warning light – Water in fuel filter warning light – Speedomete
- Location of components on vehicle - BMF2 Maxi fuse control unit (with A.B.S. Electronically-controlled diesel pump devic
- Automatic transmission (without A.B.S.)
- Location of components - Automatic transmission (without A.B.S)
- Automatic transmission (with A.B.S)
- Location of components - Automatic transmission (with A.B.S)
- Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (with air conditioning wit
- Location of components - Engine cooling with two fans – Engine coolant temperature gauge – Engine coolant overheating wa
- Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (with air conditioning and
- Location of components - Engine cooling with two fans – Engine coolant temperature gauge – Engine coolant overheating wa
- Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (with air conditioning wit
- Location of components - Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (
- Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (with air conditioning and
- Location of components - Engine cooling with two fans – Engine coolant temperature gauge and overheating warning light (
- Car interior lighting – Symbol lighting (without C.P.H)
- Location of components - Car interior lighting – Symbol lighting (without C.P.H)
- Car interior lighting – Symbol lighting (with C.P.H)
- Location of components on vehicle - BMF1 Maxi fuse control unit
- Fiat-CODE (without C.P.H)
- Location of components - Fiat-CODE (without C.P.H)
- Fiat-CODE (with C.P.H)
- Location of components on vehicle - Fiat-CODE (with C.P.H)
- Fiat-CODE (without C.P.H)
- Location of components on vehicle - N.D. Ultrasound welding taped in cable loom
- Fiat-CODE (with C.P.H)
- Location of components - Fiat-CODE (with C.P.H)
- Fiat-CODE (without C.P.H)
- Location of components - Fiat-CODE (without C.P.H)
- Fiat-CODE (with C.P.H)
- Location of components on vehicle - BMF1 Maxi fuse control unit
- Fiat-CODE (right hand drive without C.P.H)
- Location of components - Fiat-CODE (right hand drive without C.P.H)
- Location of components - Fiat-CODE (right hand drive with C.P.H)
- Fiat-CODE (right hand drive with C.P.H)
- Variant connections for versions without A.B.S.
- Location of components on vehicle - N.D. Ultrasound welding taped in cable loom
- Fiat-CODE (right hand drive with C.P.H)
- Location of components - Fiat-CODE (right hand drive with C.P.H)
- Fiat-CODE (right hand drive without C.P.H)
- Location of components - Fiat-CODE (right hand drive without C.P.H)
- Fiat-CODE (right hand drive with C.P.H)
- Location of components - Fiat-CODE (right hand drive with C.P.H)
- Fuel gauge and reserve warning light – Engine coolant temperature gauge and overheating warning light – Brake pad wear w
- Location of components - Fuel gauge and reserve warning light – Engine coolant temperature gauge and overheating warning
- Fuel gauge and reserve warning light – Brake pad wear warning light – Insufficient engine oil pressure warning light – H
- Location of components on vehicle - Fuel gauge and reserve warning light – Engine oil level gauge and warning light – Ha
- Location of components - Fuel gauge and reserve warning light – Engine coolant temperature gauge and overheating warning
- Location of components - Fuel gauge and reserve warning light – Engine coolant temperature gauge and overheating warning
- Fuel gauge and reserve warning light – Engine coolant temperature gauge and overheating warning light – Brake pad wear w
- Location of components on vehicle - BMF1 Maxi fuse control unit
- Air conditioning (without A.B.S)
- Location of components - Air conditioning (without A.B.S)
- Air conditioning (with A.B.S)
- Location of components - Air conditioning (with A.B.S)
- Additional engine heater (without A.B.S)
- Location of components - Additional engine heater (without A.B.S)
- Additional engine heater (with A.B.S)
- Location of components - Additional engine heater (with A.B.S)
- Instrument panel connections
- Location of components - Instrument panel connections
- Variant connections for the 1868 D version
- Location of components - Instrument panel connections
- Connector A instrument panel connections (with automatic transmission)
- Location of components on vehicle - BMF1 Maxi fuse control unit
- Connector B instrument panel connections (with automatic transmission)
- Location of components - Connector B instrument panel connections (with automatic transmission)
- Connector A instrument panel connections (right hand drive)
- Location of components - Connector A instrument panel connections (right hand drive)
- Connector B instrument panel connections (right hand drive)
- Location of components - Connector B instrument panel connections (right hand drive)
- Comprehensive perspective view showing location of cable loom and components
- Comprehensive perspective view showing location of cable loom and components
- Comprehensive perspective view showing location of cable loom and components (with automatic transmission)
- Perspective views
- Comprehensive perspective view of dashboard showing location of cable loom and components
- Perspective views
- Location of components - BB00 Battery (*G5)2
Wiring diagrams (2002 update)73 pages
- Wiring diagrams (2002 update)2
- N.B. The numbers in the table correspond to the page numbers for the electrical system in the manual.234
- Electrical symbols
- Electrical symbols
- Explanation for reading wiring diagram
- Side lights - No. plate lights
- Fog lights and warning light - Rear fog lamps and warning light
- Direction indicators and warning lights - Hazard warning lights and warning light
- Brake lights - Reversing lights - Brake pad wear warning light
- Engine cooling with one fan (without air conditioning)
- Engine cooling with one fan and restricter resistance (without air conditioning)
- Engine cooling with one fan (without air conditioning)
- Engine cooling with one fan
- Heated rear windscreen and warning light - Headlamp washers
- Electric front windows
- Central locking
- Electrically adjustable, heated rear view mirrors
- Radio
- Anti-lock brakes (A.B.S.) and failure warning light
- Park gear not engaged acoustic warning
- Excessive speed acoustic warning
- Side lights on acoustic warning (with C.P.H)
- Cruise Control
- Diagnostic socket connections
- Fiat-CODE (without CPH)
- Fiat-CODE (with CPH)
- Fiat-CODE (without CPH)
- Fiat-CODE (with CPH)
- Fiat-CODE (without CPH)
- Fiat-CODE (with CPH)
- Fiat-CODE (without CPH)
- Fiat-CODE (with CPH)
- Starting - Recharging and warning light -Insufficient engine oil pressure warning light
- Electronic injection and ignition - Injection system failure warning light - Engine coolant temperature gauge and over-h
- Electronic injection and ignition - Injection system failure warning light - Engine coolant temperature gauge and overhe
- Electronic injection and ignition - Injection system failure warning light - Engine coolant temperature gauge and over-h
- Starting - Recharging and warning light - Heater plugs and warning light - Diesel pump operation - Insufficient engine o
- Starting - Recharging and warning light - Heater plugs and warning light - Diesel pump operation - Insufficient engine o
- Electronically operated diesel pump - Heater plugs and warning light - Injection system failure warning light (without a
- Electronically operated diesel pump - Heater plugs and warning light - Injection system failure warning light (with air
- Heater plugs and warning light - Speedometer - Rev counter - Injection system failure warning light - Engine coolant tem
- Heater plugs and warning light - Speedometer - Rev counter - Injection system failure warning light - Engine coolant tem
- Automatic transmission
- Engine cooling with 2 fans (2 speed) - Engine coolant temperature gauge and overheating warning light (with air conditio
- Engine cooling with 2 fans (2 speed) - Engine coolant temperature gauge with overheating warning light (with air conditi
- Engine cooling with 2 fans (2 speed) - Engine coolant temperature gauge and overheating warning light (with air conditio
- Engine cooling with 2 fans with restricter resistance (2 speed) - Engine coolant temperature gauge with overheating warn
- Additional engine heater
- Fuel level gauge and reserve warning light - Engine coolant temperature gauge and overheating warning light - Brake pad
- Fuel level gauge and reserve warning light - Brake pad wear warning light - Insufficient engine oil pressure warning lig
- Fuel level gauge and reserve warning light - Engine coolant temperature gauge and overheating warning light - Brake pad
- Fuel level gauge and reserve warning light - Engine coolant temperature gauge and overheating warning light - Brake pad
- Fuel level gauge and reserve warning light - Engine coolant temperature gauge and overheating warning light - Brake pad
- Air conditioning
- Air conditioning
- Instrument panel connections (with manual gearbox)
- Instrument panel connections
- Instrument panel connections
- 55. Instrument panel connections
- Instrument panel connections connector A (with automatic transmission)
- Instrument panel connections connector B (with automatic transmission)
- Passenger compartment protection control unit connections (CPH)
- Comprehensive perspective view showing location of cable loom and components
- Comprehensive perspective view showing location of cable loom and components
- Comprehensive perspective view showing location of cable loom and components (with automatic transmission)
- Comprehensive perspective view showing location of cable loom and components
- Comprehensive perspective view showing location of cable loom and components
- Perspective view of dashboard showing location of cable loom and components
- Comprehensive perspective view showing location of cable loom and components (with automatic transmission)
Instrument panel (2003 update)20 pages
- Front view
- Instrument panel
- Connector a2
- Front view
- Instrument panel
- Connector a
- Instrument panel
- Version with automatic gearbox2
- Connector a
- Version with automatic gearbox
- Version with luxe instrument cluster
- Rear view
- Connector a
- Instrument panel
- Version with luxe instrument cluster
- Rear view
- Connector a
- Version with luxe instrument cluster
Air bag (2003 update)16 pages
- Safety rules to be observed for work on vehicles equipped with air bag system
- Air - Bag
- Painting works
- Safety rules for handling air bag modules
- Ordering procedures
- Disconnect - reconnect driver side air-bag device
- Disconnection - reconnection of spiral device
- Air - Bag
- Removal - refit air-bag system control unit2
- Disconnect - reconnect passenger side air-bag23
- Air - Bag
- Safety measures
- Air - Bag
Lighting (2004 update)2 pages
Air bag (2004 update)5 pages
Wiring diagrams (2003 update)62 pages
- Wiring diagrams (2003 update)2
- Copyright by Fiat Auto23
- Electrical symbols
- Electrical symbols
- Reference legend
- Position lights - Number plate lights
- Rear fog lights and related optical indicator - Front fog lights and related optical indicator
- Direction indicators and related optical indicators - Hazard warning lights and related optical indicator
- Vehicle stop lights - Reverse lights - Brake pad wear optical indicator
- Engine cooling with a single electric fan and limiting resistance (without air conditioning)
- Engine cooling with one electric fan (without air conditioning)
- Engine cooling with a single electric fan
- Heated rear windscreen and warning light - Headlamp washers
- Front electric window lifters
- Door locking device
- External rear-view mirrors with electric adjustment and heating
- Car radio
- Anti-lock braking system (ABS) and its optical failure indicator
- Excessive speed audible warning device
- Acoustic warning device for position lights switched on (with C.P.H)
- Cruise Control vehicle speed adjustment
- Diagnostic socket connections
- Fiat CODE device (without C.P.H)
- Fiat CODE device (with C.P.H)
- Fiat CODE device (without C.P.H)
- C.P.H. version
- Electronic ignition and injection - Injection system fault optical indicator - Engine coolant temperature level indicato
- Electronic injection ignition - Electronic injection system fault indicator - Engine coolant temperature level indicator
- Scudo [1.9 JTD 16V]
- Electronic-controlled diesel fuel pump - Glow plug preheating and related optical indicator - Injection system fault ind
- Electronically controlled diesel fuel pump - Glow plug preheating and related optical indicator - Optical injection syst
- Pre-glow device for glow plugs and related optical indicator - Speedometer - Tachometer - Optical indicator for injectio
- Glow plug pre-heating device and related optical indicator - Speedometer - Tachometer - Injection system fault optical i
- Additional engine heater device
- Update 2003
- Engine cooling with 2 electric fans (2 speeds) - Engine coolant temperature indicator and relative excessive temperature
- Update 2003
- Engine cooling with 2 electric fans with limiting resistors (2 speeds) - Engine coolant temperature indicator and relati
- Engine cooling with 2 electric fans with limiting resistor (2 speeds) - Engine coolant temperature indicator and related
- Fuel level indicator and corresponding reserve optical indicator - Engine coolant temperature indicator and correspondin
- Instrument panel Lux version
- Fuel level indicator and corresponding reserve optical indicator - Engine coolant temperature indicator and correspondin
- 2003 Update
- Fuel level indicator and corresponding reserve optical indicator - Engine coolant temperature indicator and correspondin
- Fuel level indicator and related reserve optical indicator - Engine coolant temperature indicator and related excessive
- Air conditioning
- Air conditioning
- Air conditioner
- Instrument panel connections
- Instrument panel connections (with Luxe instrument panel)
- Instrument panel connections
- Instrument panel connections (with Luxa instrument panel)
- Instrument panel connections
- Instrument panel connections (with Luxe instrument panel)
- Automatic transmission version
- Automatic transmission version
- Passenger compartment protection (C.P.H.) control unit connections2
- Update 2003