Rover 600 Repair Manual - Volumes 1 and 2 - 2nd Edition: Electrical
Also for this vehicle: 600 Circuit Diagrams, 600 Electrical Library, 600 Repair Manual Supplement (1993-1999), 620 Diesel Repair Manual Supplement (1995-1999).
General
Engine
Transmission
Steering & suspension
Brakes
Body & interior
Heating & A/C
Electrical
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
Contents7 pages
Information22 pages
- Information
- Special tools
- Microcheck
- Original page
- 86M 1920
- How to Use This Section
- Wire Colour Codes
- Repair Techniques
- Pinched
- Cut or Broken
- Overheated (short circuit)
- Not long enough
- Symptom
- Paint on body contact point
- Loose
- Wire insulation under the crimp
- Introduction
- 1. Connectors with covers
- 3. Non - sealed connectors
- Crimped over insulation
- Bent or damaged terminal
- Loose
Relay and control unit locations10 pages
Wire harness and earth locations46 pages
- Engine Compartment2345
- Roof/Seat
- Floor (LHD)
- Floor (RHD)
- Floor (LHD)
- Wire harness and earth locations2
- Electrical
- Door2
- Engine Compartment Fuse/Relay Box23
- Wire harness and earth locations
- Front View23
- Circuit Identification (LHD)
- Under-hood fuse/relay box
- 86M 1952
- Combination light switch
- KS:
- Under – dash fuse/relay box
- Under-dash fuse/relay box
- Under–dash fuse/relay box
- Battery2
- 86M 19602
- Under – dash fuse/relay box
- Under – dash fuse/relay box
- Wht/blk
- Earth distribution
- G20123
- G501
- G201
- 86M 19712
- G701
- 86M 1974
Repairs268 pages
- Test
- Power relays *2
- Relay Test (Five – terminal Type)2
- Replacement
- 86M 2403
- 86M 1991
- Installation
- Component Location Index
- Original page
- Recommended Procedure:
- Starter Replacement2345
- Commutator Mica Depth
- Performance Test
- Starter No-load Test
- Starter Brush Inspection
- Overrunning Clutch Check2
- Component Location Index
- Ignition Timing Control23
- 86M 2031
- Ignition Control Module (ICM) Input Test
- Ignition Coil Test23
- Distributor Overhaul2
- Distributor Top End Inspection
- 86M 204223
- Component Location Index2345
- Alternator/Regulator Operation Test23
- Alternator Overhaul2
- Rotor Slip Ring Test
- 86M 2071
- Deflection Method
- Alternator Belt Adjustment (With A/C)
- Component Location Index
- Radiator Fan Control
- Original page
- Under fuse/relay box2
- Terminals
- 86M 2082
- Component Location Index234
- Circuit Diagram
- Ignition control module (icm)
- Dash lights brightness controller23456789
- Input Test/Replacement
- Engine oil pressure warning system
- Sending Unit Test/Replacement
- Indicator Light Test
- Engine coolant temperature (ect) gauge
- Sending Unit Test
- Brake Fluid Level Switch Test
- Safety indicator
- 86M 2113234
- Indicator Input Test2
- Component Location Index2
- Test
- Adjustment2
- Integrated control unit
- Combination light switch2
- Entry Light Timer System
- Lights – on Reminder System
- Ignition Key Light Test
- Electrical234567
- Combination light switch
- Combination Light Switch Test2
- Original page
- Dim-dip Headlight Control Input Test (KE)2345
- Circuit Diagram
- Input Test
- 86M 21552
- Bulb Replacement
- Adjustment
- Side indicator lights
- Number plate lights
- Rear fog light
- Glove box light2
- Components2
- Courtesy Light Test/Replacement
- Door Switch Test
- Rear Interior Light:
- Boot Light Test/Replacement23
- Brake lights2
- Reversing lights
- Manual transmission
- Component Location Index
- G30123
- Hazard Warning Switch Removal
- Component Location
- 86M 220823
- Circuit Diagram23
- Circuit Diagram2
- Circuit Diagram
- Removal
- Component Location
- Description23
- Unit Terminals
- Sticking Antenna
- Removal
- Power Antenna Motor Replacement
- Rear Speaker Replacement
- Component Location23
- Demister Wires Repair
- Switch Test
- Component Location
- Circuit Diagram (Without demister)2
- One or both mirrors inoperative2
- Mirror Switch
- Power Mirror Replacement23
- Switch Test
- Motor Test
- Component Location
- Circuit Diagram234
- Passenger Door Lock Actuator Test
- Component Location23
- Switch Test
- Heater Test
- Component Location
- Description234
- Driver's Window Motor Test23
- Control Unit Input Test234
- Driver's Switch
- Switch Removal
- Left Rear Window Switch23
- Motor Test
- Component Location23
- Driver's Window Motor Test23
- Wiper/washers23
- Windscreen Wiper/Washer
- Replacement2345
- Headlight Washer Switch Test
- Input Test234
- Ignition control module (icm)234
- Vacuum Diaphragm Actuator and Mount Testing
- Keyless entry and security alarm system23
- Original page
- Security Alarm System:2
- Battery replacement2
- KEYLESS ENTRY SYSTEM (KE) Without Security Alarm System
- Original page
- Keyless Entry System (Without security alarm system)23
- Front Passenger Door:
- Battery replacement
- Component Location – Engine Bay2
- SRS Type II2
- 86M 3366E
- Cruise control cannot be set:
- Control Unit Input Test
- Original page2345
- Main Switch Test2
- Clutch Switch Test
- Actuator cable adjustment23
- Vacuum Tank
- Remove